飞灰颗粒与平板表面撞击过程的实验研究

doi:10.3969/j.issn.0438-1157.2013.09.012

化工学报 ›› 2013, Vol. 64 ›› Issue (9): 3161-3167.DOI: 10.3969/j.issn.0438-1157.2013.09.012

飞灰颗粒与平板表面撞击过程的实验研究

韩健, 东明, 李素芬, 谢俊

大连理工大学能源与动力学院, 辽宁大连 116024

收稿日期:2013-01-21 修回日期:2013-04-19 出版日期:2013-09-05 发布日期:2013-09-05
通讯作者: 东明
作者简介:韩健(1989- ),男,硕士研究生。
基金资助:
国家自然科学基金青年科学基金项目(51006055)。

Experimental research on fly ash particles impacting planar surface

HAN Jian, DONG Ming, LI Sufen, XIE Jun

School of Energy and Power Engineering, Dalian University of Technology, Dalian 116024, Liaoning, China

Received:2013-01-21 Revised:2013-04-19 Online:2013-09-05 Published:2013-09-05
Supported by:
supported by the National Natural Science Foundation of China(51006055).

摘要/Abstract

摘要： 以煤粉锅炉积灰过程为研究背景,在常温常压环境下对飞灰颗粒与平板表面撞击过程进行实验研究,分析飞灰颗粒入射法向速度对颗粒法向反弹速度的影响,以及飞灰颗粒粒径对临界捕集速度的影响。实验结果表明,飞灰颗粒粒径相同时,法向恢复系数随入射法向速度的增大先增大后平缓最后减小,在增大区域具有相当陡的斜率,反映了不同形式的力在不同阶段所占的比重不同;颗粒入射法向速度相同时,法向恢复系数随着颗粒粒径的增大而增大;而临界捕集速度随颗粒粒径的增大而减小。

关键词: 颗粒沉积, 入射法向速度, 法向恢复系数, 临界速度

Abstract: The formation of fly ash deposition on heat transfer tubes in a boiler taken as the research background,an experiment of fly ash particle impacting plate at ambient temperature and pressure was carried out to investigate the effects of initial velocity and fly ash particle diameter on normal coefficient of restitution.The experimental results show that when particle diameter remained constant,normal coefficient of restitution e_n first increased,then leveled,and finally decreased as normal incident velocity v_i,n increased,and in the rapid increase region of e_n,the slope of the experimental curve(e_n vs v_i,n)was very large.This was due to the variation of the ratios of different types of energy to the total energy in the different ranges of normal impact velocity.When normal incident velocity remained constant,normal coefficient of restitution increased as particle diameter increased.The critical capture velocity changed with microsphere diameter,the larger the size,the smaller the capture velocity.

Key words: particle deposition, incident normal velocity, normal coefficient of restitution, critical velocity

中图分类号:

TK16

韩健, 东明, 李素芬, 谢俊. 飞灰颗粒与平板表面撞击过程的实验研究[J]. 化工学报, 2013, 64(9): 3161-3167.

HAN Jian, DONG Ming, LI Sufen, XIE Jun. Experimental research on fly ash particles impacting planar surface[J]. CIESC Journal, 2013, 64(9): 3161-3167.

参考文献 22

[1]	van Beek M C,Rindt C C M,Wijers J G,van Steenhoven A A.Rebound characteristics for 50 μm particles impacting a powdery deposit[J].Powder Technology,2006,165:53-64
[2]	Lokare S S,Dunaway J D,Moulton D,Rogers D,Tree D R,Baxter L.Investigation of ash deposition rates for a suite of biomass fuels and fuel blends[J].Energy & Fuels,2006,20:1008-1014
[3]	Baxter L L.Ash deposition during biomass and coal combustion:a mechanistic approach[J].Biomass and Bioenergy,1993,4(2):85-102
[4]	Wang Xi(王希),Liu Kai(刘恺),You Changfu(由长福).Influence on bond behavior of coarse particle with various distributing wind measures[J].CIESC Journal(化工学报),2011,62(1):53-58
[5]	Sandia National Laboratories.Ash deposit formation and deposit properties:a comprehensive summary of research conducted at Sandia's combustion research facility[R].Albuquerque:Combustion Research Facility,2000
[6]	Suriyawong A,Gamble M,Lee M H,Axelbaum R,Biswas P.Submicrometer particle formation and mercury speciation under oxygen-carbon dioxide coal combustion[J].Energy Fuels,2006,20:2357-2363
[7]	Liu Ruolei(刘若雷),Yang Ruichang(杨瑞昌),You Changfu(由长福),Zhao Lei(赵磊),Zhou Tao(周涛).Kinematic characteristics and thermophoretic deposition of inhalable particles in temperature gradient field[J].CIESC Journal(化工学报),2009,60(7):1623-1628
[8]	Walsh P M,Sayre A N,Loehden D O,Monroe L S,Beer J M,Sarofim A F.Deposition of bituminous coal ash on an isolated heat exchanger tube:effects of coal properties on deposit growth[J].Progress in Energy and Combustion Science,1990,16:327-346
[9]	Walsh P M,Sarofim A F,Beer J M.Fouling of convection heat exchangers by lignitic coal ash[J].Energy & Fuels,1992,6:709-715
[10]	Nielsen H P,Baxter L L,Sclippab G,Morey C,Frandsen F J,Johansen K D.Deposition of potassium salts on heat transfer surfaces in straw-fired boiler:a pilot-scale study[J].Fuel,2000,79:131-139
[11]	Kweon S C,Ramer E,Robinson A L.Measurement and simulation of ash deposit microstructure[J].Energy Fuels,2003,17:1311-1323
[12]	Theis M.Interaction of biomass fly ashes with different fouling tendencies[D].Turku:ABO University,2006
[13]	Xu Xiaoguang(徐晓光).Experimental investigation on the formation mechanisms of ash deposition during biomass combustion[D].Beijing:Tsinghua University,2009
[14]	Xu Xiaoguang,Li Shuiqing,Li Gengda,Yao Qiang.Effect of co-firing straw with two coals on the ash deposition behavior in a down-fired pulverized coal combustor[J].Energy Fuels,2010,24:241-249
[15]	Mu Lin(穆林),Zhao Liang(赵亮),Yin Hongchao(尹洪超).Fouling and slagging characteristics in wastewater incinerator[J].CIESC Journal(化工学报),2012,63(11):3645-3651
[16]	Dahneke B.The capture of aerosol particles by surfaces[J].Journal of Colloid and Interface Science,1971,37:342-353
[17]	Dahneke B.Measurements of the bouncing of small latex spheres[J].Journal of Colloid and Interface Science,1973,45:584-590
[18]	Dahneke B.Further measurements of the bouncing of small latex spheres[J].Journal of Colloid and Interface Science,1975,51:58-65
[19]	Abd-Elhady M S,Rindt C C M,Wijers J G,van Steenhoven A A.Modeling the impaction of a micron particle with a powdery layer[J].Powder Technology,2006,168:111-124
[20]	Johnson K L,Kendall K,Roberts A D.Surface energy and the contact of elastic solids[J].Proceedings of the Royal Society of London A,1971, 324:301-313
[21]	Liu Guanqing(柳冠青).Discrete element methods of fine particle dynamics in presence of van der Waals and electrostatic forces[D].Beijing:Tsinghua University,2011
[22]	Liu Guanqing,Li Shuiqing,Yao Qiang.A JKR-based dynamic model for the impact of micro-particle with a flat surface[J].Powder Technology,2011, 207:215-223

飞灰颗粒与平板表面撞击过程的实验研究

Experimental research on fly ash particles impacting planar surface

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 3

编辑推荐

Metrics

本文评价

[1]	柏斌, 潘艳秋. 错流微滤制备动态膜过程中细微颗粒沉积机理[J]. 化工学报, 2012, 63(11): 3553-3559.
[2]	刘升, 郝英立, 杜敏, 陶明春. 气流床煤气化炉壁面反应模型 [J]. 化工学报, 2010, 61(5): 1219-1225.
[3]	熊焱军, 郭晓镭, 龚欣, 黄万杰, 赵锦超, 陆海峰. 水平管煤粉密相气力输送堵塞临界状态 [J]. 化工学报, 2009, 60(6): 1421-1426.