Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

CIESC Journal ›› 2010, Vol. 18 ›› Issue (3): 478-485.

Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

郑雄¹, 陈银广¹, 刘晨晨²

1. State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, Shanghai 200092, China;
2. Kuang Yaming Honors School, Nanjing University, Nanjing 210093, China

收稿日期:2009-11-03 修回日期:2010-03-11 出版日期:2010-06-28 发布日期:2010-06-28
通讯作者: CHEN Yinguang,E-mail:yg2chen@yahoo.com
基金资助:
Supported by the National High Technology Research and Development Program of China(2007AA06Z326);the Programfor New Century Excellent Talents(06-0373)in University

Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

ZHENG Xiong¹, CHEN Yinguang¹, LIU Chenchen²

1. State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, Shanghai 200092, China;
2. Kuang Yaming Honors School, Nanjing University, Nanjing 210093, China

Received:2009-11-03 Revised:2010-03-11 Online:2010-06-28 Published:2010-06-28
Supported by:
Supported by the National High Technology Research and Development Program of China(2007AA06Z326);the Programfor New Century Excellent Talents(06-0373)in University

摘要/Abstract

摘要： Activated sludge process has been widely used to remove phosphorus and nitrogen from wastewater. However,the nitrogen and phosphorus removal is sometimes unsatisfactory due to the low influent COD.Another problem with the activated sludge process is that large amount of waste activated sludge is produced,which needs further treatment.In this study,the waste activated sludge alkaline fermentation liquid was used as the main carbon source for phosphorus and nitrogen removal under anaerobic followed by alternating aerobic-anoxic conditions,and the results were compared with those using acetic acid as the carbon source.The use of alkaline fermentation liquid not only affected the transformations of phosphorus,nitrogen,intracellular polyhydroxyalkanoates and glycogen, but also led to higher removal efficiencies for phosphorus and nitrogen compared with acetic acid.It was observed that ammonium was completely removed with either alkaline fermentation liquid or acetic acid as the carbon source. However,the former resulted in higher removal efficiencies for phosphorus(95%)and nitrogen(82%),while the latter showed lower ones(87% and 74%,respectively).The presence of a large amount of propionic acid in the alkaline fermentation liquid was one possible reason for its higher phosphorus removal efficiency.Exogenous instead of endogenous denitrification was the main pathway for nitrogen removal with the alkaline fermentation liquid as the carbon source,which was responsible for its higher nitrogen removal efficiency.It seems that the alkaline fermentation liquid can replace acetic acid as the carbon source for phosphorus and nitrogen removal in anaerobic followed by alternating aerobic-anoxic sequencing batch reactor.

关键词: nutrients removal, alkaline fermentation liquid, waste activated sludge, endogenous denitrification, carbon source

Abstract: Activated sludge process has been widely used to remove phosphorus and nitrogen from wastewater. However,the nitrogen and phosphorus removal is sometimes unsatisfactory due to the low influent COD.Another problem with the activated sludge process is that large amount of waste activated sludge is produced,which needs further treatment.In this study,the waste activated sludge alkaline fermentation liquid was used as the main carbon source for phosphorus and nitrogen removal under anaerobic followed by alternating aerobic-anoxic conditions,and the results were compared with those using acetic acid as the carbon source.The use of alkaline fermentation liquid not only affected the transformations of phosphorus,nitrogen,intracellular polyhydroxyalkanoates and glycogen, but also led to higher removal efficiencies for phosphorus and nitrogen compared with acetic acid.It was observed that ammonium was completely removed with either alkaline fermentation liquid or acetic acid as the carbon source. However,the former resulted in higher removal efficiencies for phosphorus(95%)and nitrogen(82%),while the latter showed lower ones(87% and 74%,respectively).The presence of a large amount of propionic acid in the alkaline fermentation liquid was one possible reason for its higher phosphorus removal efficiency.Exogenous instead of endogenous denitrification was the main pathway for nitrogen removal with the alkaline fermentation liquid as the carbon source,which was responsible for its higher nitrogen removal efficiency.It seems that the alkaline fermentation liquid can replace acetic acid as the carbon source for phosphorus and nitrogen removal in anaerobic followed by alternating aerobic-anoxic sequencing batch reactor.

Key words: nutrients removal, alkaline fermentation liquid, waste activated sludge, endogenous denitrification, carbon source

郑雄, 陈银广, 刘晨晨. Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors[J]. CIESC Journal, 2010, 18(3): 478-485.

ZHENG Xiong, CHEN Yinguang, LIU Chenchen. Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors[J]. , 2010, 18(3): 478-485.

参考文献

1 Lee, D.S., Jeon, C.O., Park, J.M., “Biological nitrogen removal with enhanced phosphate uptake in a sequencing batch reactor using single sludge system”, Water Res., 35(16), 3968-3976(2001).
2 Yilmaz, G., Lemaire, R., Keller, J., Yuan, Z., “Effectiveness of an alternating aerobic, anoxic/anaerobic strategy for maintaining biomass activity of BNR sludge during long-term starvation”, Water Res., 41(12), 2590-2598(2007).
3 Kerrn-Jespersen, J.P., Henze, M., “Biological phosphorus uptake under anoxic and aerobic conditions”, Water Res., 27(4), 617-624(1993).
4 Kuba, T., Smolders, G., van Loosdrecht, M., Heijnen, J., “Biological phosphorus removal from wastewater by anaerobic–anoxic sequencing batch reactor”, Water Sci. Technol., 27, 241-252(1993).
5 Mino, T., Van Loosdrecht, M.C.M., Heijnen, J.J., “Microbiology and biochemistry of the enhanced biological phosphate removal process”, Water Res., 32(11), 3193-3207(1998).
6 Elefsiniotis, P., Wareham, D.G., Smith, M.O., “Use of volatile fatty acids from an acid-phase digester for denitrification”, J. Biotechnol., 114(3), 289-297(2004).
7 Bernat, K., Wojnowska-Baryla, I., Dobrzynska, A., “Denitrification with endogenous carbon source at low C/N and its effect on P(3HB) accumulation”, Bioresource Technol., 99(7), 2410-2418(2008).
8 Moser-Engeler, R., Udert, K.M., Wild, D., Siegrist, H., “Products from primary sludge fermentation and their suitability for nutrient removal”, Water Sci. Technol., 38(1), 265-273(1998).
9 Jonsson, K., Johansson, P., Christensson, M., Lee, N., Lie, E., Welander, T., “Operational factors affecting enhanced biological phosphorus removal at the waste water treatment plant in Helsingborg, Sweden”, Water Sci. Technol., 34, 67-74(1996).
10 Thomas, M., Wright, P., Blackall, L., Urbain, V., Keller, J., “Optimisation of Noosa BNR plant to improve performance and reduce operating costs”, Water Sci. Technol., 47(12), 141-148(2003).
11 Yuan, H., Chen, Y., Zhang, H., Jiang, S., Zhou, Q., Gu, G., “Improved bioproduction of short-chain fatty acids(SCFAs) from excess sludge under alkaline conditions”, Environ. Sci. Technol., 40(6), 2025-2029(2006).
12 Tong, J., Chen, Y., “Enhanced biological phosphorus removal driven by short-chain fatty acids produced from waste activated sludge alkaline fermentation”, Environ. Sci. Technol., 41(20), 7126-7130(2007).
13 Chen, Y., Jiang, S., Yuan, H., Zhou, Q., Gu, G., “Hydrolysis and acidification of waste activated sludge at different pHs”, Water Res., 41(3), 683-689(2007).
14 Comeau, Y., Hall, K.J., Oldham, W.K., “Determination of poly-βhydroxybutylate and poly-β-hydroxyvalerate in activated sludge by gas-liquid chromatography”, Appl. Environ. Microb., 54, 2325-2327(1988).
15 Oehmen, A., Keller-Lehmann, B., Zeng, R.J., Yuan, Z., Keller, E., “Optimisation of poly-beta-hydroxyalkanoate analysis using gas chromatography for enhanced biological phosphorus removal systems”, J. Chromatogr. A, 1070, 131-136(2005).
16 Jenkins, D., Richard, M.G., Daigger, G.T., Manual on the Causes and Control of Activated Sludge Bulking and Foaming, 2nd edition, Lewis Publishers, Florida(1993).
17 APHA, Standard Methods for the Examination of Water and Wastewater, 20th edition, American Public Health Association, Washington, DC(1998).
18 Chen, Y., Randall, A.A., McCue, T., “The efficiency of enhanced biological phosphorus removal from real wastewater affected by different ratios of acetic to propionic acid”, Water Res., 38(1), 27-36(2004).
19 Oehmen, A., Lemos, P.C., Carvalho, G., Yuan, Z., Keller, J., Blackall, L.L., Reis, M.A.M., “Advances in enhanced biological phosphorus removal:From micro to macro scale”, Water Res., 41(11), 2271-2300(2007).
20 Li, H., Chen, Y., Gu, G., “The effect of propionic to acetic acid ratio on anaerobic-aerobic(low dissolved oxygen) biological phosphorus and nitrogen removal”, Bioresource Technol., 99(10), 4400-4407(2008).
21 Zhang, C., Chen, Y., Randall, A.A., Gu, G., “Anaerobic metabolic models for phosphorusand glycogen-accumulating organisms with mixed acetic and propionic acids as carbon sources”, Water Res., 42(14), 3745-3756(2008).
22 Li, D., “Denitrification using volatile fatty acids(VFAs):the effects of nitrate concentrations, types of VFAs, C/N ratio and temperature”, M.E. Thesis, University of Auckland, Auckland, New Zealand(2001).
23 Xu, Y., “Volatile fatty acids carbon source for biological denitrification”, J. Environ. Sci., 8(3), 257-268(1996).
24 Min, K.S., Park, K.S., Jung, Y.J., Khan, A.R., Kim, Y.J., “Acidogenic fermentation:utilization of wasted sludge as a carbon source in the denitrification process”, Environ. Technol., 23(3), 293-302(2002).
25 Chae, S.R., Lee, S.H., Kim, J.O., Paik, B.C., Song, Y.C., Park, H.S., Shin, H.S., “Simultaneous removal of organic and strong nitrogen from sewage in a pilot-scale BNR process supplemented with food waste”, Water Sci. Technol., 49, 257-264(2004).
26 Aesoy, A., Odegaard, H., “Denitrification in biofilms with biologically hydrolyzed sludge as carbon source”, Water Sci. Technol., 29, 93-100(1994).

[1]	孙洪伟, 杨庆, 彭永臻, 时晓宁, 王淑莹, 张树军. Nitrite Accumulation during the Denitrification Process in SBR for the Treatment of Pre-treated Landfill Leachate[J]. CIESC Journal, 2009, 17(6): 1027-1031.
[2]	王伟, 王淑莹, 彭永臻, 张善锋, 殷芳芳. Enhanced Biological Nutrients Removal in Modified Step-feed Anaerobic/Anoxic/Oxic Process[J]. CIESC Journal, 2009, 17(5): 840-848.

Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

Waste Activated Sludge Alkaline Fermentation Liquid as Carbon Source for Biological Nutrients Removal in Anaerobic Followed by Alternating Aerobic-Anoxic Sequencing Batch Reactors

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 2

编辑推荐

Metrics

本文评价