小球藻对奶牛场沼液处理能力及生物质生产的探究

doi:10.11949/j.issn.0438-1157.20180739

化工学报 ›› 2019, Vol. 70 ›› Issue (1): 227-233.DOI: 10.11949/j.issn.0438-1157.20180739

小球藻对奶牛场沼液处理能力及生物质生产的探究

冯思然^1,^2,^3,⁴(),丰平仲^1,^2,³,朱顺妮^1,^2,³(),王忠铭^1,^2,³,袁振宏^1,^2,³

1. 中国科学院广州能源研究所，广东广州 510640
2. 中国科学院可再生能源重点实验室，广东广州 510640
3. 广东省新能源与可再生能源研究开发与应用重点实验室，广东广州 510640
4. 中国科学院大学，北京 100049

收稿日期:2018-07-04 修回日期:2018-09-28 出版日期:2019-01-05 发布日期:2019-01-05
通讯作者: 朱顺妮
作者简介:冯思然(1993—)，男，硕士研究生，<email>fengsr@ms.giec.ac.cn</email>|朱顺妮（1981—），女，副研究员，<email>zhusn@ms.giec.ac.cn</email>
基金资助:
国家重点研发项目(2016YFB0601004);广东省自然科学基金研究团队项目(2016A030312007);广州市科技计划项目珠江科技新星专项(201610010155)

Nutrient removal and biomass production from dairy farm liquid digestate treatment using microalga Chlorella vulgaris

Siran FENG^1,^2,^3,⁴(),Pingzhong FENG^1,^2,³,Shunni ZHU^1,^2,³(),Zhongming WANG^1,^2,³,Zhenhong YUAN^1,^2,³

1. Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences, Guangzhou 510640, Guangdong, China
2. CAS Key Laboratory of Renewable Energy, Guangzhou 510640, Guangdong, China
3. Guangdong Provincial Key Laboratory of New and Renewable Energy Research and Development, Guangzhou 510640, Guangdong, China
4. University of Chinese Academy of Sciences, Beijing 100049, China

Received:2018-07-04 Revised:2018-09-28 Online:2019-01-05 Published:2019-01-05
Contact: Shunni ZHU

摘要/Abstract

摘要：

为资源化处理奶牛场沼液、探究小球藻Chlorella vulgaris NIES-227对奶牛场沼液的处理能力以及生物质利用潜力，在柱式光生物反应器中利用小球藻处理沼液占比分别为25%、50%、75%和 100% 4种不同浓度的未灭菌污水。研究结果显示，各浓度污水中总氮、总磷和COD的去除率分别为36.0%～92.5%、42.8%～100%和6.9%～32.2%。在沼液占比为25%的污水中氮磷的去除率最高，氨氮、总氮和总磷的去除效率分别可达99.9%、91.0%和100%。微藻在低浓度沼液（25%～50%）中生长状态良好，在沼液占比为50%的污水中可获得最高生物质产率393.6 mg/(L·d)。但是在高浓度沼液（75%～100%）中微藻生长受到一定抑制，导致氮磷的去除效果变差。培养期间细菌的数量增长显著，促进了COD的去除。各浓度沼液生物质中总脂、总糖和蛋白质含量分别为13.2%～32.2%、12.3%～27.6%和16.2%～30.9%。实验数据表明，低浓度沼液能产生更多高能量组分的生物质，适合用作生物燃料的开发；高浓度沼液能产生含较多蛋白质的生物质，更适合用作动物饲料。

关键词: 小球藻, 奶牛场沼液, 营养去除, 生物质生产, 资源利用

Abstract:

In this study, the treatment performance of dairy farm liquid digestate by freshwater microalga Chlorella vulgaris NIES-227 was investigated and the potential of biomass utilization was evaluated. In column photobioreactors, Chlorella vulgaris was used to treat wastewaters containing unsterilized liquid digestate at concentrations of 25%, 50%, 75%, and 100%. The results showed that the removal of total nitrogen (TN), total phosphorus (TP) and COD were 36.0%—92.5%, 42.8%—100% and 6.9%—32.2%, respectively. The microalgae exhibited the maximum removal efficiencies of nitrogen and phosphorus in 25% liquid digestate, and the maximum removals of ammonia nitrogen (NH₃-N), TN and TP were 99.9%, 91.0% and 100%, respectively. The microalgae grew well in low concentrations of liquid digestate (25%—50%), and the highest biomass productivity was obtained in 50% liquid digestate with the value of 393.6 mg/(L·d). However, microalgal growth was inhibited in higher concentrations of liquid digestate (75%—100%), which led to the decreases of the removal of nitrogen and phosphorus. The number of bacteria increased significantly during the cultivation among all the treatment groups, which was beneficial to the COD removal. The contents of total lipid, total sugar and protein in biomass harvested from different concentrations of liquid digestate were 13.2%—32.2%, 12.3%—27.6% and 16.2%—30.9%, respectively. The experimental data show that low-concentration biogas slurry can produce more high-energy components of biomass, which is suitable for biofuel development; high-concentration biogas slurry can produce biomass with more protein, which is more suitable for animal feed.

Key words: Chlorella, dairy farm liquid digestate, nutrition removal, biomass production, resource utilization

中图分类号:

Q 938

冯思然, 丰平仲, 朱顺妮, 王忠铭, 袁振宏. 小球藻对奶牛场沼液处理能力及生物质生产的探究[J]. 化工学报, 2019, 70(1): 227-233.

Siran FENG, Pingzhong FENG, Shunni ZHU, Zhongming WANG, Zhenhong YUAN. Nutrient removal and biomass production from dairy farm liquid digestate treatment using microalga Chlorella vulgaris[J]. CIESC Journal, 2019, 70(1): 227-233.

图/表 8

表1 猪场沼液和奶牛场沼液中COD及氮磷含量

Table 1 Contents of COD, nitrogen and phosphorous in swine and dairy liquid digestate

Liquid digestate type	COD/(mg/L)	TN/(mg/L)	NH₃-N/(mg/L)	Phosphate/(mg/L)	Ref.
pig farm liquid digestate	1046	254	220	85.9	[8]
dairy farm liquid digestate	1480	621.1	575.4	252.7	[9]

表2 奶牛场沼液不同处理下的水质特征

Table 2 Water characteristics of dairy farm liquid digestate under different treatments

Digestate	pH	COD/(mg/L)	NH₃-N/(mg/L)	TN/(mg/L)	TP/(mg/L)	TSS/(g/L)
raw liquid digestate	7.15	1724	567	605	82	2.6
after stored at 4℃	7.94	1498	545	650	11.3	—
experimental liquid digestate	7.62	1446	529.5	535	77.6	0.13

图1 不同浓度沼液中COD（a）、磷酸根（b）、氨氮（c）、总氮（d）的去除

Fig.1 Removal of COD(a), phosphate(b), NH3-N (c) and TN (d) in liquid digestate with different concentrations

图2 各浓度沼液中生物质浓度变化

Fig.2 Growth of biomass in different liquid digestate concentrations

图3 各浓度沼液中小球藻细胞数目变化

Fig.3 Microalgal cell number among all cultures

图4 各浓度沼液中细菌菌落在第0、3、7 d数目变化

Fig.4 Changes in bacterial colonies on day 0, 3 and 7 among all cultures

图5 各浓度沼液生物质中总脂、总糖、蛋白质含量

Fig.5 Contents of total lipid, total sugar and protein among all cultures

表3 各组沼液生物质中N、C、H元素含量

Table 3 Contents of N, C and H elements in biomass from different concentrations of liquid digestate

Liquid digestate concentrations/%	Elements contents/%
Liquid digestate concentrations/%	N	C	H
25	5.1	55.7	7.8
50	8.8	49.5	7.2
75	9.2	50.5	7.0
100	9.7	50.9	7.1

参考文献 29

1	万风, 王海燕, 周岳溪, 等 . 养猪废水处理技术研究进展[J]. 农业灾害研究, 2012, 2(1): 25-29.
	Wan F , Wang H Y , Zhou Y X , et al . Research progress on the processing technology of piggery wastewater[J]. Journal of Agricultural Catastrophology, 2012, 2(1): 25-29.
2	Feng C , Sugiura N , Shimada S , et al . Development of a high performance electrochemical wastewater treatment system[J]. Journal of Hazardous Materials, 2003, 103(1/2): 65-78.
3	Wang Y , Ho S H , Cheng C L , et al . Perspectives on the feasibility of using microalgae for industrial wastewater treatment[J]. Bioresource Technology, 2016, 222: 485-497.
4	Ji M K , Abou-Shanba R A I , Seongheon K , et al . Cultivation of microalgae species in tertiary municipal wastewater supplemented with CO₂ for nutrient removal and biomass production[J]. Ecological Engineering, 2013, 58(13): 142-148.
5	Oswald W J , Gotaas H B , Golueke C G , et al . Algae in waste treatment[J]. Sewage & Industrial Wastes, 1957, 29(4): 437-457.
6	Spolaore P , Joannis-Cassan C , Duran E , et al . Commercial applications of microalgae[J]. Journal of Bioscience and Bioengineering, 2006, 101(2): 87-96.
7	Wen Y , He Y , Ji X , et al . Isolation of an indigenous Chlorella vulgaris from swine wastewater and characterization of its nutrient removal ability in undiluted sewage[J]. Bioresource Technology, 2017, 243: 247-253.
8	李岩, 周文广, 张晓东, 等 . 微藻培养技术处理猪粪厌氧发酵废水效果[J]. 农业工程学报, 2011, 27(13): 101-104.
	Li Y , Zhou W G , Zhang X D , et al . Effect of microalgae culture on treatment of wastewater from anaerobic digested swine manure[J]. Translations of the Chinese Society of Agricultural Engineering, 2011, 27(13): 101-104.
9	靳红梅, 常志州, 叶小梅, 等 . 江苏省大型沼气工程沼液理化特性分析[J]. 农业工程学报, 2011, 27(1): 291-296.
	Jin H M , Chang Z Z , Ye X M , et al . Physical and chemical characteristics of anaerobically digested slurry from large-scale biogas project in Jiangsu Province[J]. Translations of the Chinese Society of Agricultural Engineering, 2011, 27(1): 291-296.
10	舒庆 . 奶牛场废水培养产油微藻研究[D]. 北京: 中国科学院大学, 2014.
	Shu Q . Microalgae cultivation utilizing dairy wastewater[D]. Beijing: University of Chinese Academy of Sciences, 2014.
11	孙中亮, 冯雪珂, 李丹, 等 . 小球藻净化沼液的预处理方法[J]. 生物学杂志, 2017, 34(3): 99-104.
	Sun Z L , Feng X K , Li D , et al . Different pretreatment methods for biogas slurry purification by Chlorella vulgaris [J]. Journal of Biology, 2017, 34(3): 99-104.
12	Bigogno C , Khozin-Goldberg I , Boussiba S , et al . Lipid and fatty acid composition of the green oleaginous alga Parietochloris incisa, the richest plant source of arachidonic acid[J]. Phytochemistry, 2002, 60(5): 497-503.
13	Dubois M , Gilles K A , Hamilton J K , et al . Colorimetric method for determination of sugars and related substances[J]. Analytical Chemistry, 1956, 28(3): 350-356.
14	王忠江, 隋超, 王泽宇, 等 . 小球藻对不同沼液添加量培养液的适应性及净化效果[J]. 农业工程学报, 2017, 33(3): 221-226.
	Wang Z J , Sui C , Wang Z Y , et al . Adaptation of Chlorella to culture liquid with different biogas slurry adding proportion and its purified effect[J]. Translations of the Chinese Society of Agricultural Engineering, 2017, 33(3): 221-226.
15	王愿珠, 程鹏飞, 刘德富, 等 . 生物膜贴壁培养小球藻净化猪粪沼液废水的效果[J]. 环境科学, 2017, 38(8): 3354-3361.
	Wang Y Z , Cheng P F , Liu D F , et al . Purification effect of piggery wastewater with Chlorella pyrenoidosa by immobilized biofilm-attached culture[J]. Environmental Science, 2017, 38(8): 3354-3361.
16	He P J , Mao B , Lü F , et al . The combined effect of bacteria and Chlorella vulgaris on the treatment of municipal wastewaters[J]. Bioresource Technology, 2013, 146(10): 562-568.
17	Chen R , Li R , Deitz L , et al . Freshwater algal cultivation with animal waste for nutrient removal and biomass production[J]. Biomass & Bioenergy, 2012, 39(39): 128-138.
18	Cai T , Park S Y , Li Y . Nutrient recovery from wastewater streams by microalgae: status and prospects[J]. Renewable & Sustainable Energy Reviews, 2013, 19(1): 360-369.
19	Tam N F , Wong Y S . Wastewater nutrient removal by Chlorella pyrenoidosa and Scenedesmus sp[J]. Environmental Pollution, 1989, 58(1): 19-34.
20	Emerson K , Russo R C , Lund R E , et al . Aqueous ammonia equilibrium calculations: effect of pH and temperature[J]. Journal of the Fisheries Research Board of Canada, 1975, 32(12): 2379-2383.
21	Lewin R A . Extracellular polysaccharides of green algae[J]. Revue Canadienne De Microbiologie, 1956, 2(7): 665-672.
22	Min M , Wang L , Li Y , et al . Cultivating Chlorella sp. in a pilot-scale photobioreactor using centrate wastewater for microalgae biomass production and wastewater nutrient removal[J]. Applied Biochemistry & Biotechnology, 2011, 165(1): 123-137.
23	高影影 . 富油海洋微藻的筛选及营养条件对其生长和油脂积累的影响[D]. 南京: 南京农业大学, 2013.
	Gao Y Y . Screening of oil-rich marine microalgae and the effect of nutritional conditions on the growth and lipid accumulation of it[D]. Nanjing: Nanjing Agricultural University, 2013.
24	Huo S , Wang Z , Zhu S , et al . Cultivation of Chlorella zofingiensis in bench-scale outdoor ponds by regulation of pH using dairy wastewater in winter, South China[J]. Bioresource Technology, 2012, 121(7): 76-82.
25	朱顺妮, 王亚杰, 黄伟, 等 . 缺氮培养对小球藻碳水化合物和油脂积累的影响[J]. 太阳能学报, 2016, 37(8): 2118-2122.
	Zhu S N , Wang Y J , Huang W , et al . Effect of nitrogen starvation culture on carbohydrate and lipid accumulation in Chlorella sp. [J]. Acta Energiae Solaris Sinica, 2016, 37(8): 2118-2122.
26	Khozin-Goldberg I , Cohen Z . The effect of phosphate starvation on the lipid and fatty acid composition of the fresh water eustigmatophyte Monodus subterraneus [J]. Phytochemistry, 2006, 67(7): 696-701.
27	Feng Y , Li C , Zhang D . Lipid production of Chlorella vulgaris cultured in artificial wastewater medium[J]. Bioresour. Technol., 2011, 102(1): 101-105.
28	Rodolfi L , Chini Z G , Bassi N , et al . Microalgae for oil: strain selection, induction of lipid synthesis and outdoor mass cultivation in a low-cost photobioreactor[J]. Biotechnology & Bioengineering, 2009, 102(1): 100-112.
29	Feng P , Deng Z , Hu Z , et al . Lipid accumulation and growth of Chlorella zofingiensis in flat plate photobioreactors outdoors[J]. Bioresource Technology, 2011, 102(22): 10577-10584.

[1]	王亚杰, 朱顺妮, 王忠铭, 袁振宏. 氮胁迫下小球藻淀粉与脂肪的合成关系[J]. 化工学报, 2015, 66(6): 2189-2195.
[2]	石磊，杨俊红，康利改，罗梦圆，?左鹏鹏，巩启涛. 曝气间隔对普通小球藻生物质积累的影响[J]. 化工进展, 2014, 33(10): 2735-2738.

小球藻对奶牛场沼液处理能力及生物质生产的探究

Nutrient removal and biomass production from dairy farm liquid digestate treatment using microalga Chlorella vulgaris

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 8

参考文献 29

相关文章 2

编辑推荐

Metrics

本文评价