基于多点耦合的低温多股流换热过程动态模拟

doi:10.11949/j.issn.0438-1157.20181120

化工学报 ›› 2018, Vol. 69 ›› Issue (S2): 167-173.DOI: 10.11949/j.issn.0438-1157.20181120

基于多点耦合的低温多股流换热过程动态模拟

张镨^1,2, 周理^1,2,3, 郭开华³, 陈正华^1,2, 王伟杰^1,2

1 中国石油西南油气田分公司天然气研究院, 四川成都 610213;
2 中国石油天然气集团公司天然质量控制与能量计量重点实验室, 四川成都 610213;
3 中山大学工学院, 广东广州 510006

收稿日期:2018-09-29 修回日期:2018-10-24 出版日期:2018-12-31 发布日期:2018-12-31

Dynamic simulation on cryogenic multi-stream heat exchange processes with multi-node coupling method

ZHANG Pu^1,2, ZHOU Li^1,2,3, GUO Kaihua³, CHEN Zhenghua^1,2, WANG Weijie^1,2

1 Research Institute of Natural Gas Technology, PetroChina Southwest Oil and Gasfield Company, Chengdu 610213, Sichuan, China;
2 CNPC Key Laboratory of Natural Gas Quality and Energy Measurement, Chengdu 610213, Sichuan, China;
3 School of Engineering, Sun Yat-Sen University, Guangzhou 510006, Guangdong, China

Received:2018-09-29 Revised:2018-10-24 Online:2018-12-31 Published:2018-12-31

摘要/Abstract

摘要：

多股流换热器是气体液化低温系统的核心部件，其工作性能对低温系统的降温特性和热力效率的影响显著。基于气液两相的容积节点原理建立多节点耦合的混合工质低温换热器动态模型及计算方法，对多股流换热器动态降温特性进行研究，重点分析换热器的漏热率和（屯液）液位波动对系统降温特性的影响。研究结果表明漏热对启动过程降温特性影响不大，而在降温至低温区时较为显著。换热器液位波动对系统动态降温特性会有显著影响，低温多股流换热器通道内液位波动会引起循环工质组分、有效制冷量、降温速度的波动，从而造成系统降温速度显著偏离优化工作状态，效率降低。这表明在混合工质低温多股流换热器的设计和操作过程中应尽量采取措施，以避免通道内积液波动现象出现。

Abstract:

Multi-Stream Heat Exchanger (MSHE) is the core component of gas liquefaction system, its working performance can significantly affect the cooling characteristics and thermal efficiency of system. Based on the principle of two-phase volume node, this article established dynamic simulation method for Mixed-Refrigerant (MR) cryogenic system with a Multi-Node Coupling (MNV) MSHE model. The study results reveal that the heat leak's influence on cooling characteristics of MSHE is negligible during start-up process, while significant and can't negligible in low temperature situation. The liquid-level oscillation in MSHE channel can significantly impact the cooling characteristics, and induce the circulating MR composition shift, cooling capacity and cooling-down rate oscillation in further, which may deteriorate the cooling performance of the MSHE. The results suggest that measures should be taken in design and operation process to avoid the liquid level oscillation phenomenon in MR low-temperature MSHE channels.

中图分类号:

张镨, 周理, 郭开华, 陈正华, 王伟杰. 基于多点耦合的低温多股流换热过程动态模拟[J]. 化工学报, 2018, 69(S2): 167-173.

ZHANG Pu, ZHOU Li, GUO Kaihua, CHEN Zhenghua, WANG Weijie. Dynamic simulation on cryogenic multi-stream heat exchange processes with multi-node coupling method[J]. CIESC Journal, 2018, 69(S2): 167-173.

参考文献 31

[1]	LIM W, CHOI K, MOON I.Current status and perspectives of liquefied natural gas (LNG) plant design[J].Industrial & Engineering Chemistry Research, 2013, 52(9):3065-3088.
[2]	FINN A J, JOHNSON G L, TOMLINSON T R.Developments in natural gas liquefaction[J].Hydrocarbon Processing, 1999, 78(4):47-59.
[3]	陈永东, 周兵, 程沛.LNG工厂换热技术的研究进展[J].天然气工业, 2012, 32(10):80-85.CHEN Y D, ZHOU B, CHENG P.Research progress in heat transfer technology in LNG plants[J].Natural Gas Industry, 2012, 32(10):80-85.
[4]	WANG T, DING G, DUAN Z, et al.A distributed-parameter model for LNG spiral wound heat exchanger based on graph theory[J].Applied Thermal Engineering, 2015, 81:102-113.
[5]	FARUQUE H M, KARIMI I A, ALFADALA H, et al.Modeling and simulation of main cryogenic heat exchanger in a base-load liquefied natural gas plant[J].Computer Aided Chemical Engineering, 2007, 24:219-224.
[6]	GIULIANI G, HEWITT N J, MARCHESI D F, et al.Composition shift in liquid-recirculation refrigerating systems:an experimental investigation for the pure fluid R134a and the mixture R32/134a[J].International Journal of Refrigeration, 1999, 22(6):486-498.
[7]	RAJAPAKSHA L, SUEN K O.Influence of liquid receiver on the performance of reversible heat pumps using refrigerant mixtures[J].International Journal of Refrigeration, 2004, 27(1):53-62.
[8]	LAKSHMI N N, VENKATARATHNAM G.A method for estimating the composition of the mixture to be charged to get the desired composition in circulation in a single stage JT refrigerator operating with mixtures[J].Cryogenics, 2010, 50(2):93-101.
[9]	XU X, LIU J, CAO L, et al.Local composition shift of mixed working fluid in gas-liquid flow with phase transition[J].Applied Thermal Engineering, 2012, 39:179-187.
[10]	LAKSHMI N N, VENKATARATHNAM G.Effect of mixture composition and hardware on the performance of a single stage JT refrigerator[J].Cryogenics, 2011, 51(8):446-451.
[11]	SUN H, SHU D, JIANG Z.Simulation study of the dynamic performance of a MRC plant with refrigerant charged or leaked[J].Cryogenics, 2012, 52(1):8-12.
[12]	GONG M Q, ZHOU W, WU J F.Composition shift due to the different solubility in the Lubricant oil for multicomponent mixtures[J].Cryocoolers, 2007, 14:459-467.
[13]	JIN S, HRNJAK P.Refrigerant and lubricant distribution in MAC system[J].SAE International Journal of Passenger Cars-Mechanical Systems, 2013, 6(2):1013-1020.
[14]	公茂琼.两相流中相积存造成多元混合制冷剂浓度变化分析[J].制冷学报, 2006, 27(4):10-12.GONG M Q.Composition shift due to phase hold-up in two-phase flow for multicomponent mixed refrigerant[J].Journal of Refrigeration, 2006, 27(4):10-12.
[15]	MELAAEN E.Dynamic simulation of the liquefaction section in Base load LNG plants[D].Norwegian:Norwegian University of Science and Technology, 1994.
[16]	NELLIS G F.A heat exchanger model that includes axial conduction, parasitic heat loads, and property variations[J].Cryogenics, 2003, 43(9):523-538.
[17]	HASAN M F, KARIMI I A, ALFADALA H, et al.Modeling and simulation of main cryogenic heat exchanger in a base-load liquefied natural gas plant[J].Computer Aided Chemical Engineering, 2007, 24(7):219-224.
[18]	SINGH A, HOVD M.Model requirement for control design of an LNG process[J].Computer Aided Chemical Engineering, 2007, 24(7):533-538.
[19]	HEYDWEILLER J C, SINCOVEC R F, FAN L T.Dynamic simulation of chemical processes described by distributed and lumped parameter models[J].Computers & Chemical Engineering, 2015, 1(2):113-124.
[20]	HASAN M M, KARIMI I A, ALFADALA H E, et al.Operational modeling of multistream heat exchangers with phase changes[J].AIChE Journal, 2009, 55(1):150-171.
[21]	MICHELSEN F A, HALVORSEN I J, LUND B F, et al.Modeling and simulation for control of the TEALARC liquified natural gas process[J].Industrial & Engineering Chemistry Research, 2010, 49(16):7389-7397.
[22]	PACIO J C, DORAO C A.A review on heat exchanger thermal hydraulic models for cryogenic applications[J].Cryogenics, 2011, 51(7):366-379.
[23]	NEERAAS B O, FREDHEIM A O, AUNAN B.Experimental data and model for heat transfer, in liquid falling film flow on shell-side, for spiral-wound LNG heat exchanger[J].International Journal of Heat and Mass Transfer, 2004, 47(14):3565-3572.
[24]	NEERAAS B O, FREDHEIM A O, AUNAN B.Experimental shell-side heat transfer and pressure drop in gas flow for spiral-wound LNG heat exchanger[J].International Journal of Heat and Mass Transfer, 2004, 47(2):353-361.
[25]	NELLIS G, HUGHES C, PFOTENHAUER J.Heat transfer coefficient measurements for mixed gas working fluids at cryogenic temperatures[J].Cryogenics, 2005, 45(8):546-556.
[26]	孙兆虎, 公茂琼, 李志坚, 等.多元混合工质池核沸腾传热实验研究[J].制冷学报, 2006, 27(1):9-14.SUN Z H, GONG M Q,LI Z J,et al.Experiment study of pool boiling heat transfer of multicomponent mixed-refrigerants[J].Journal of Refrigeration, 2006, 27(1):9-14
[27]	ØIVIND W, GEIR S, MORTEN H, et al.Time efficient solution of phase equilibria in dynamic and distributed systems with differential algebraic equation solvers[J].Industrial and Engineering Chemistry Research, 2013, 52(5):2130-2140.
[28]	王坤, 徐风雨, 李红艳, 等.小型MRC天然气液化装置中板翅式换热器动态特性仿真研究[J].低温工程, 2007, (3):44-49.WANG K, XU F Y, LI H Y, et al.Dynamic performance simulation of plate-fin heat exchangers in small scale MRC-LNG plant[J].Cryocenics, 2007, (3):44-49.
[29]	张镨, 鹿来运, 郭开华,等.小型混合工质循环气体液化系统实验及优化[J].制冷学报, 2011, 32(3):48-52.ZHANG P, LU L Y, GUO K H, et al.Experiment and optimization of a small-scale mixed-refrigerant-cycle natural gas liquefaction system[J].Journal of Refrigeration, 2011,32(3):48-52.
[30]	波林B E, 普劳斯尼茨J M, 奥康奈尔J P.气液物性估算手册[M].北京:化学工业出版社, 2005.POLING B E, PRAUSNITZ J M, O'CONNELL J P.The Properties of Gases and Liquids[M].Beijing:Chemical Industry Press, 2005.
[31]	张镨, 郭开华, 邓文源, 等.混合工质低温气体液化系统降温规律动态模拟研究[J].制冷学报, 2015, 36(2):71-77.ZHANG P, GUO K H, DENG W Y, et al.Dynamic simulation on temperature decreasing characteristics of mixed-refrigerant cryogenic liquefaction system[J].Journal of Refrigeration, 2015, 36(2):71-77.

基于多点耦合的低温多股流换热过程动态模拟

Dynamic simulation on cryogenic multi-stream heat exchange processes with multi-node coupling method

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 31

相关文章 8

编辑推荐

Metrics

本文评价

[1]	任滔, 段钟弟, 丁国良. 微肋结构对储罐失压下液化气瞬态暴沸特性的影响[J]. 化工学报, 2018, 69(S2): 512-516.
[2]	任其龙, 薛文峰, 张铭, 吴剑骅, 潘腾云, 金军魁, 闻光东, 苏宝根. 旋转弧等离子体转化油脂制合成气[J]. 化工学报, 2015, 66(12): 4966-4971.
[3]	王辉, 陈福胜, 宋琦, 任彬, 王勤, 陈光明. 新型精馏型自复叠小型天然气液化系统性能优化[J]. 化工学报, 2015, 66(S2): 231-237.
[4]	任彬, 陈福胜, 王辉, 宋琦, 王勤, 徐象国, 陈光明. 精馏型自复叠小型天然气液化系统配比优化[J]. 化工学报, 2014, 65(z2): 169-174.
[5]	李焱, 李玉星, 胡其会, 王武昌, 谢彬, 喻西崇. 一种新型板翅式换热器气液分配器分配特性的敏感性分析[J]. 化工学报, 2013, 64(6): 2007-2014.
[6]	朱建鲁, 李玉星, 王武昌, 刘永浩, 谢彬, 喻西崇. 晃荡条件下氮膨胀液化过程冷箱运行可靠性[J]. 化工学报, 2013, 64(4): 1183-1190.
[7]	何金波, 房建威, 闻光东, 马杰, 苏宝根, 邢华斌, 任其龙. 热等离子体重整二氧化碳和甲烷制合成气的研究进展[J]. 化工学报, 2013, 64(3): 779-787.
[8]	朱建鲁, 李玉星, 王武昌, 多志丽, 谢彬, 喻西崇. LNG接收终端工艺流程动态仿真[J]. 化工学报, 2013, 64(3): 1000-1007.