乙醇/硫酸铵双水相体系从丹参粗提液中分离丹酚酸B

doi:10.3969/j.issn.0438-1157.2012.06.017

化工学报 ›› 2012, Vol. 63 ›› Issue (6): 1773-1779.DOI: 10.3969/j.issn.0438-1157.2012.06.017

乙醇/硫酸铵双水相体系从丹参粗提液中分离丹酚酸B

郭永学1,王立红1,张大勇1，周丽莉1,修志龙2

1沈阳药科大学制药工程学院,辽宁沈阳 110016；2大连理工大学生命科学与技术学院,辽宁大连 116024

收稿日期:2011-11-07 修回日期:2012-03-20 出版日期:2012-06-05 发布日期:2012-06-05
通讯作者: 郭永学

A new aqueous two-phase system of ethanol/ammonium sulphate to recovery lithospermic acid B from extract of Salvia miltiorrhiza Bge

GUO Yongxue1, WANG Lihong1, ZHANG Dayong1, ZHOU Lili1, XIU Zhilong2

1School ofPharmaceutical Engineering, Shenyang PharmaceuticalUniversity, Shenyang 110016，Liaoning, China;2School ofBioscience and Biotechnology, DalianUniversity of Technology, Dalian 116024, Liaoning, China

Received:2011-11-07 Revised:2012-03-20 Online:2012-06-05 Published:2012-06-05

摘要/Abstract

摘要： 采用中心复合设计的响应曲面法优化了乙醇/硫酸铵双水相体系从丹参粗提液中分离丹酚酸B的工艺参数，并对放大效果进行了对比研究。结果表明，在确定pH2.0和30℃的条件下，当硫酸铵和乙醇质量分数分别为20%和29%时，丹酚酸B的分配系数最大为58.7，回收率为97.3%。上相加乙醇脱除硫酸铵，减压浓缩、干燥，丹酚酸B的纯度为57.4%。与小试相比，放大40倍后，分配系数(59.3)、回收率(98.2%)和纯度（58.6%）均无显著差异（p<0.05）。500g丹参，经煮提，双水相萃取，脱硫酸铵，氯仿脱脂，乙酸乙脂萃取，可得26.1g浸膏，丹酚酸B的纯度为78.1%，总回收率为87.0%。因此，双水相萃取可以作为从丹参粗提液中规模分离丹酚酸B的有效手段。

关键词: 丹酚酸B, 双水相萃取, 乙醇/硫酸铵, 响应面分析

Abstract: The separation of lithospermic acid B (LAB) by aqueous two-phase systems was studied. According to the partition coefficient and the yield of LAB, the various ethanol and (NH4)2SO4 system were investigated using response surface methodology to find the optimal condition. The results showed that the optimum phase composition was 20% (w) (NH4)2SO4 and 29% (w) of ethanol for crude extraction at pH2.0 and 30 oC. The partition coefficient and yield　of LAB were 58.7 and 97.3% respectively. To remove the salt, the purity is 57.4%. Compared with small scale, the partition coefficient (59.3), yield (98.2%) and purity (58.6%) of LAB are no significant different in scale up 40 folds. Subsequently, the (NH4)2SO4 was removed from the top phase with ethanol. The concentrated extracts were partitioned with chloroform, and the H2O layer was extracted by EtOAc. The EtOAc fraction was evaporated in vacuo at 40 oC, and 26.1g LAB with the purity of 78.1% and the overall yield of 87.0% was obtained from 500g powders. Thus aqueous two-phase system may provide efficient technique for extraction of LAB from the crude extract.

Key words: lithospermic acid B, aqueous two-phase extraction, ethanol/ammonium sulphate, response surface methodology

中图分类号:

TQ464.9

郭永学,王立红,张大勇，周丽莉,修志龙. 乙醇/硫酸铵双水相体系从丹参粗提液中分离丹酚酸B[J]. 化工学报, 2012, 63(6): 1773-1779.

GUO Yongxue, WANG Lihong, ZHANG Dayong, ZHOU Lili, XIU Zhilong. A new aqueous two-phase system of ethanol/ammonium sulphate to recovery lithospermic acid B from extract of Salvia miltiorrhiza Bge[J]. CIESC Journal, 2012, 63(6): 1773-1779.

[1]	党艳艳, 郭禹熙, 曹文静, 修志龙. 葡萄籽多酚类物质的盐析萃取[J]. 化工学报, 2014, 65(8): 3048-3053.
[2]	周红航，王维香. 聚乙二醇/硫酸铵双水相体系萃取猪胰蛋白酶 [J]. CIESC Journal, 2009, 28(2): 305-.
[3]	刘国兴, 江波, 王元好, 戴建英, 修志龙. 乙醇/碳酸钾双水相萃取盾叶薯蓣发酵液中的2,3-丁二醇 [J]. 化工学报, 2009, 60(11): 2798-2804.
[4]	朱自强; 关怡新; 李勉. 双水相系统在抗生素提取和合成中的应用 [J]. CIESC Journal, 2001, 52(12): 1039-1048.
[5]	修志龙,姜炜,苏志国. 用聚乙二醇沉淀法清除细胞碎片 [J]. CIESC Journal, 1993, 44(6): 757-760.

乙醇/硫酸铵双水相体系从丹参粗提液中分离丹酚酸B

A new aqueous two-phase system of ethanol/ammonium sulphate to recovery lithospermic acid B from extract of Salvia miltiorrhiza Bge

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 5

编辑推荐

Metrics

本文评价