压缩/喷射制冷循环中两相喷射器性能

doi:10.3969/j.issn.0438-1157.2012.10.013

化工学报 ›› 2012, Vol. 63 ›› Issue (10): 3094-3100.DOI: 10.3969/j.issn.0438-1157.2012.10.013

压缩/喷射制冷循环中两相喷射器性能

王菲¹, 吕恒林¹, 冯伟¹, 沈胜强²

1. 中国矿业大学力学与建筑工程学院, 江苏徐州 221116;
2. 大连理工大学能源与动力学院, 辽宁省海水淡化重点实验室, 辽宁大连 116024

收稿日期:2012-01-05 修回日期:2012-05-22 出版日期:2012-10-05 发布日期:2012-10-05
通讯作者: 王菲
作者简介:王菲(1979- ),女,博士,讲师。
基金资助:
江苏省自然科学基金项目(BK2011216);中国矿业大学启航计划。

Performance of two-phase ejector in compression/ejection refrigeration cycle

WANG Fei¹, LV Henglin¹, FENG Wei¹, SHEN Shengqiang²

1. School of Architecture and Engineering, China University of Mining and Technology, Xuzhou 221116, Jiangsu, China;
2. Key Laboratory for Desalination of Liaoning Province, School of Energy and Power Engineering, Dalian University of Technology, Dalian 116024, Liaoning, China

Received:2012-01-05 Revised:2012-05-22 Online:2012-10-05 Published:2012-10-05
Supported by:
supported by the Natural Science Foundation of Jiangsu Province(BK2011216)and the Sailing Plan of China University of Mining and Technology.

摘要/Abstract

摘要： 考虑引射流体的壅塞现象和混合室内的凝结激波现象,对混合室采用恒面积混合模型,应用质量守恒、动量守恒和能量守恒对两相喷射器建立了热力学模型。以R141b为工质,研究了在不同混合压力条件下喷射器内的压力变化趋势,分析了混合压力对系统性能、喷射器喷射系数和出口压力的影响,探讨了喷射器最优引射室压降、系统最优性能系数及相应的性能提高率随冷凝温度和蒸发温度的变化情况。结果表明:在本文计算工况范围内,两相喷射器混合室内无凝结激波的发生;对混合室采用恒面积混合模型相比等压混合模型更合理;恰当选择混合压力对优化系统的性能非常重要,其最佳值略低于引射流体压力,而远高于引射流体的临界压力,且其对应于喷射器取得最高的喷射系数。

关键词: 压缩/喷射, 两相喷射器, 壅塞, 凝结激波, 混合压力

Abstract: Taking into account of the phenomena of choking in entrained flow and condensation shock in mixing chamber,a thermodynamic model of two-phase ejector was established by using mass,momentum and energy balances.In the simulation,the mixing area in the mixing chamber is constant.With R141b as refrigerant,the pressure change in the ejector at various mixing pressures was studied,and the effects of mixing pressure on the performance of compression/ejection cycle,the entrainment ratio and exit pressure of ejector were analyzed.The variations of optimum suction chamber pressure drop,the corresponding ejector entrainment ratio,the system optimum performance coefficient and the corresponding performance improvement ratio with condensation temperature and evaporation temperature were presented.The results show that under the operation conditions in this study,no condensation shock occurs in the mixing chamber of two-phase ejector.The constant area model for mixing chamber is more appropriate than constant pressure model.It is important to choose appropriate mixing pressure for optimizing the system performance,and the optimum mixing pressure,at which the ejector has the highest entrainment ratio,is slightly lower than the pressure of entrained flow but far larger than the critical pressure entrained flow.

Key words: compression/ejection, two-phase ejector, choking, condensation shock, mixing pressure

中图分类号:

TB61

王菲, 吕恒林, 冯伟, 沈胜强. 压缩/喷射制冷循环中两相喷射器性能[J]. 化工学报, 2012, 63(10): 3094-3100.

WANG Fei, LV Henglin, FENG Wei, SHEN Shengqiang. Performance of two-phase ejector in compression/ejection refrigeration cycle[J]. CIESC Journal, 2012, 63(10): 3094-3100.

参考文献 11

[1]	Kemper G A,Harper G F,Brown G A.Multiple phase ejector refrigeration system:US,3277660.1966-10-11
[2]	Kornhauser A A.The use of an ejector as a refrigerant expander//Proceeding of the 1990 USNC/IIR-Perdue Refrigeration Conference.West Lafayette,USA:Purdue University,1990:10-19
[3]	Nehdi E,Kairouani L,Bouzaina M.Performance analysis of vapour compression cycle using ejector as an expander[J].Int.J.Energ.Res.,2007,31(4):364-375
[4]	Deng Jianqiang(邓建强),Jiang Peixue(姜培学),Lu Tao(卢涛),Wang Guoliang(王国梁),Lu Wei(卢苇).Theoretical analysis of a transcritical CO2 vapor compression/ejection refrigeration cycle[J].J.Tsinghua Univ.:Sci.&Tech.(清华大学学报:自然科学版),2006,46(5):670-673
[5]	Fan Xiaowei(范晓伟),Yin Jianmin(阴建民),Liu Haifeng(刘海峰),Chen Zhongqi(陈钟颀).Study on a new kind of vapor-compression/ejection hybrid refrigeration cycle[J].Journal of Xi'an Jiaotong University(西安交通大学学报),1996,30(5):5-11
[6]	Bilir N,Ersoy H K.Performance improvement of the vapour compression refrigeration cycle by a two-phase constant area ejector[J].Int.J.Energ.Res.,2009,33(5):569-480
[7]	Liu Jinghui(刘敬辉),Chen Jiangping(陈江平),Chen Zhijiu(陈芝久).Ejector in compression/ejection hybrid refrigerator:design and performances[J].Journal of Applied Sciences(应用科学学报),2006,24(6):64f2-646
[8]	Li Tao(李涛),Sun Min(孙民),Li Qiang(李强),Chen Yunguang(陈蕴光),Yuan Xiuling(袁秀玲).Performance of transcritical carbon dioxide system with ejector[J].Journal of Xi'an Jiaotong University(西安交通大学学报),2006,40(5):553-557
[9]	Li D Q,Groll E A.Transcritical CO2 refrigeration cycle with ejector-expansion device[J].International Journal of Refrigeration,2005,28(5):766-773
[10]	Liao S M,Zhao T S,Jakobsen A.Correlation of optimal heat rejection pressures in transcritical carbon dioxide cycles[J].Applied Thermal Engineering,2000,20(9):831-841
[11]	Young J B,Guha A.Normal shock-wave structure in two-phase vapour-droplet flows[J].J.Fluid Mech.,1991,228:243-274

压缩/喷射制冷循环中两相喷射器性能

Performance of two-phase ejector in compression/ejection refrigeration cycle

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 11

相关文章 2

编辑推荐

Metrics

本文评价

[1]	耿利红, 刘华东, 魏新利, 王珍珍, 邵龙. 操作参数对双蒸发压缩/喷射制冷系统性能的影响[J]. 化工学报, 2017, 68(3): 1146-1154.
[2]	陈亮;陈江平;陈芝久. 电子膨胀阀壅塞特性与冷凝压力的关系 [J]. CIESC Journal, 2009, 60(4): 820-825.