Fe0对SBBR工艺处理腈纶废水性能影响

doi:10.3969/j.issn.0438-1157.2013.08.042

化工学报 ›› 2013, Vol. 64 ›› Issue (8): 2996-3002.DOI: 10.3969/j.issn.0438-1157.2013.08.042

Fe⁰对SBBR工艺处理腈纶废水性能影响

王亚娥, 李杰, 翟思媛, 冯娟娟

兰州交通大学环境与市政工程学院, 甘肃兰州 730070

收稿日期:2012-12-19 修回日期:2013-01-30 出版日期:2013-08-05 发布日期:2013-08-05
通讯作者: 王亚娥(1964- ),女,硕士,教授。
作者简介:王亚娥(1964- ),女,硕士,教授。
基金资助:
国家自然科学基金项目(51068015);国家水体污染控制与治理科技重大专项项目(2012ZX07201-005-05-02)。

Effect of Fe⁰ on acrylic fiber wastewater treatment in SBBR

LI Jie, ZHAI Siyuan, FENG Juanjuan

School of Environmental and Municipal Engineering, Lanzhou Jiaotong University, Lanzhou 730070, Gansu, China

Received:2012-12-19 Revised:2013-01-30 Online:2013-08-05 Published:2013-08-05
Supported by:
supported by the National Natural Science Foundation of China(51068015)and the National Water Pollution Control and Management Technology Major Projects(2012ZX07201-005-05-02).

摘要/Abstract

摘要： 以吉林某化纤集团公司污水处理车间腈纶废水为对象,通过平行对比试验考察了Fe⁰对SBBR反应器处理腈纶废水性能的影响。结果表明:(1)添加Fe⁰可提高SBBR反应器的启动速率;(2)在反应器进入稳定运行阶段后,添加Fe⁰的2^#反应器与对照组1^#反应器的COD_Cr平均去除率分别为70.7%和60.5%,NH₃-N平均去除率分别为60.6%和13.5%,外加Fe⁰的SBBR反应器COD_Cr与NH₃-N平均去除率分别提高了10.2%和47.1%;(3)添加Fe⁰的2^#反应器的MLSS与MLVSS分别是对照组1^#反应器的1.60倍和1.35倍。同时,添加Fe⁰更有利于异养型硝化菌——产碱杆菌属的生长,从而大大提高了反应器NH₃-N的去除率。

关键词: 腈纶废水, SBBR, 零价铁, 菌种鉴定

Abstract: In this paper,taking acrylic wastewater from the sewage treatment workshop of a chemical fiber company in Jilin as an object,the effect of Fe⁰ on acrylic wastewater treatment in SBBR reactor was studied via parallel comparison test.The test results showed that:(1)It could improve the start-up rate of SBBR reactor by adding Fe⁰.(2)While the reactor was at the stable operation stage,in 2^# reactor with added Fe⁰ and 1^# reactor without adding Fe⁰,the average removal rates of COD_Cr were 70.7% and 60.5% and the average removal rate of NH₃-N were 60.6% and 13.5%,respectively.The average removal rate of COD_Cr and NH₃-N were improved by 10.2% and 47.1% by adding Fe⁰.(3)The mixed liquor suspended solids(MLSS)and mixed liquor volatile suspended solids(MLVSS)in 2^# reactor with added Fe⁰ were 1.60 and 1.35 times than those in 1^# reactor,respectively.Adding Fe⁰ was beneficial to the growth of heterotrophic nitrification bacteria-Alcaligenes sp.,thus significantly improving NH₃-N removal rate.

Key words: acrylic fiber wastewater, sequencing batch biofilm reactor, zero-valent iron, identification of typical colonies

中图分类号:

X505

王亚娥, 李杰, 翟思媛, 冯娟娟. Fe⁰对SBBR工艺处理腈纶废水性能影响[J]. 化工学报, 2013, 64(8): 2996-3002.

WANG Ya'e, LI Jie, ZHAI Siyuan, FENG Juanjuan. Effect of Fe⁰ on acrylic fiber wastewater treatment in SBBR[J]. CIESC Journal, 2013, 64(8): 2996-3002.

参考文献 28

[1]	Wang Ya'e(王亚娥),Sun Liting(孙莉婷),Li Jie(李杰),Zhou Yuexi(周岳溪),Jiang Jinyuan(蒋进元),Zhang Wenxiu(张文秀).Treatment characteristics and research progress of acrylic fiber wastewater[J].China Water & Wastewater(中国给水排水),2011,27(22):1-5
[2]	Zhou Xiufeng(周秀凤).Treatment of wastewater from chemical fiber industry[J].China Chemicals(化工文摘),2007(4):52-53
[3]	Li Jie(李杰),Wang Xia(王霞),Bai Qiaoxia(白巧霞),Wang Ya'e(王亚娥),Jiang Jinyuan(蒋进元),Zhou Yuexi(周岳溪).Biochemical treatment of wet process acrylic fiber wastewater[J].Enviromental Protection of Chemical Industry(化工环保),2012,32(2):145-148
[4]	Wang Mingming(王明明),Yang Fenglin(杨凤林),Xu Xiaochen(徐晓晨),Zhang Hanmin(张捍民),An Peng(安鹏).Flocculation of the effluent of acrylic fiber wastewater by biochemical treatment[J].Industrial Water Treatment(工业水处理),2011,31(11):23-27
[5]	Regina Nogueira,Cláudia Alves,Maria Matos,António G Brito. Synthesis and degradation of poly-b-hydroxybutyrate in a sequencing batch biofilm reactor[J].Bioresource Technology,2009,100:2106-2110
[6]	Wang Yongjie(王永杰),Jiang Jinyuan(蒋进元),Zhou Yuexi(周岳溪),Xu Jixian(许吉现),Zhang Xiaojuan(张小娟).Study on acrylic fiber wastewater treatment by sequencing batch biofilm reactor[J].Technology of Water Treament(水处理技术),2012,38(1):93-95
[7]	Wang Guowei(王国威),Jiang Jinyuan(蒋进元),Zhou Yuexi(周岳溪),Zhang Sheng(张胜),Wang Yongjie(王永杰),Wang Xiaosong(王晓松).Study the effect on treatment of acrylic fibers wastewater by combined filier membrane A/O process[J].Technology of Water Treatment(水处理技术),2011,37(7):116-119
[8]	Wang Yongjie(王永杰),Zhou Yuexi(周岳溪),Li Jie(李杰),Xu Jixian(许吉现).Study on the effect of PVF-Ⅰ carrier removal from acrylic fiber wastewater by sequencing batch biofilm reactor[J].Technology of Water Treatment(水处理技术),2011,37(9):101-104
[9]	Liu Shiyi(刘诗一),Jiang Jinyuan(蒋进元),Xu Jixian(许吉现),Zhou Yuexi(周岳溪),Zhang Binghu(张炳虎),Wang Yuntian(王云田).Study on medium-sized treatment acrylic fiber wastewater using anaerobic and aerobic biofilm process[J].Technology of Water Treatment(水处理技术),2012,38(6):66-69
[10]	Zhang Binghu(张炳虎),Jiang Jinyuan(蒋进元),Zhou Yuexi(周岳溪),Yang Weihua(杨卫华),Liu Shiyi(刘诗一),Xu Yansheng(徐延生).Study on the strengthened treatment of acrylic fiber wastewater by two-grade A/O[J].Industrial Water Treatment(工业水处理),2012,32(10):31-34
[11]	Li Jie(李杰),Wang Ya'e(王亚娥),Wang Zhiying(王志盈),Yang Yuhua(杨玉华).Study on application of biological sponge iron in nitrogen and phosphorus removal from domestic wastewater[J].China Water & Wastewater(中国给水排水),2007,23(1):97-100
[12]	Peng Yongzhen(彭永臻),Li Jun(李军).Microbe and Water Treatment Engineering(微生物与水处理工程)[M].2nd ed.Beijing:Chemical Industry Press,2002
[13]	Wang Xiaomao,David Waite T.Iron speciation and iron species transformation in activated sludge membrane bioreactors[J].Water Research,2010,44:3511-3521
[14]	Zhang Yuan(张媛),Li Jie(李杰),Shi Zongli(石宗利).Immobilized carrier of nano-attapulgite clay compounded hydrophilic urethane foam microorganisms[P]:CN,200910117393.2010-01-06
[15]	Wang Ya'e(王亚娥).Biological sponge iron preparation and its uses in water disposal[P]:CN,200610104990.9
[16]	State Environmental Protection Administration.Water and Wastewater Monitoring Method[M].4th ed.Beijing:China Environmental Science Press,2002
[17]	Ren Xuefeng(任雪锋),Bi Xuejun(毕学军),Cheng Lihua(程丽华),Zhu Zhengsheng(祝征圣),Chang Gongfa(常功法).Research on enhanced biological nitrogen and phosphorus removal by compound ferric enzymatic activated sludge[J].China Water & Wastewater(中国给水排水),2011,27(3):24-28
[18]	Long Tengrui(龙腾锐),Meng Xuezheng(孟雪征),Lai Zhenhong(赖震宏).Fe3+ effect on activated sludge system[J].Water & Wastewater Engineering(给水排水),2004,30(12):15-17
[19]	Franzmann P D,Haddad C M,Hawkes R B,Robertson W J,Plumb J J.Effects of temperature on the rates of iron and sulfur oxidation by selected bioleaching Bacteria and Archaea: Application of the Ratkowsky equation[J].Minerals Engineering,2005,18(13/14):1304-1314
[20]	Teruyuki Umita.Biological mine drainage treatment[J].Resources,Conservation and Recycling,1996,16(1/2/3/4):179-188
[21]	Pham A N,Waite T D.Oxygenation of Fe(Ⅱ)in natural waters revisited: kinetic modeling approaches,rate constant estimation and the importance of various reaction pathways[J].Geochim. Cosmochim.Acta,2008a,72,3616-3630
[22]	Pham A N,Waite T D.Oxygenation of Fe(Ⅱ)in the presence of citrate in aqueous solutions at pH 6.0-8.0 and 25 degrees:interpretation from an Fe(Ⅱ)/citrate speciation perspective[J].Phys.Chem.A,2008b,112:643-651
[23]	Gu Yingying(顾莹莹),Gao Mengchun(高孟春),Jia Yonggang(贾永刚).Preliminary study on reduction of nitrate in water with sponge iron[J].China Water & Wastewater(中国给水排水),2006,22(7):82-84
[24]	Wang Xiuheng(王秀蘅),Ren Nanqi(任南琪),Wang Aijie(王爱杰),Ma Fang(马放).Study on the effect of iron and manganese ion from nitration[J].Journal of Harbin Institute of Technology(哈尔滨工业大学学报),2003,35(1):122-125
[25]	Jiang Hongxia(姜红霞),Wang Shenghui(王圣惠),Xue Qingjie(薛庆节),Yan Yanchun(闫艳春).Isolation,identification and characterization of a methyl-parathion degrading bacterium[J].Journal of Agro-Environment Science(农业环境科学学报),2005,24(5):962-965
[26]	Qiu Lequan(邱乐泉),Yang Lin(杨琳),Zhong Weihong(钟卫鸿).Isolation and characterization of dibenzothiophene-degrading bacterium Agrobacterium tumefaciens W3[J].Journal of Zhejiang University of Technology(浙江工业大学学报),2009,37(5):520-524
[27]	Zhang Liqing(张丽青),Zhou Bo(周波),Zhang Qingle(张庆乐),Wu Shoulin(吴守林).Screening of flocculant producing bacteria and application in treatment of azo dye wastewater[J].J. Environ.Health(环境与健康杂志),2009,26(3):192-195
[28]	John G H,Noel R K,Peter H A S,et al.Bergey's Manual of Determinative Bacteriology[M].9th ed. Lippineott:Williams & Wilkens,1994:23-26

Fe⁰对SBBR工艺处理腈纶废水性能影响

Effect of Fe⁰ on acrylic fiber wastewater treatment in SBBR

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 28

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王承泽, 顾凯丽, 张晋华, 石建轩, 刘艺娓, 李锦祥. 硫化协同老化零价铁增效去除水中Cr（Ⅵ）的作用机制[J]. 化工学报, 2023, 74(5): 2197-2206.
[2]	朱文会, 王夏晖, 杨欣桐, 王兴润, 何俊, 黄国鑫, 季国华. 海藻酸钙固定化零价铁抗团聚及堵塞的作用机制[J]. 化工学报, 2020, 71(5): 2344-2351.
[3]	赵斌,刘念,王虹利,钱怡冉,张朝晖,王亮. 道南渗析-零价铁耦合工艺除砷效果研究[J]. 化工学报, 2020, 71(11): 5303-5308.
[4]	李艳鹰, 李先春. 生物质活性炭负载零价铁纳米晶簇直接催化还原NO[J]. 化工学报, 2019, 70(3): 1111-1119.
[5]	李德生, 张超, 邓时海, 胡智丰, 李金龙, 刘元辉. 基于铁基质高效催化还原污水中硝酸盐氮的实验研究[J]. 化工学报, 2019, 70(3): 1065-1074.
[6]	樊鹏, 陈杰, 关小红, 乔俊莲. 过硫酸盐强化零价铁还原去除硝基苯的实验研究[J]. 化工学报, 2018, 69(5): 2175-2182.
[7]	曹贝, 李锦祥, 关小红. 弱磁场强化零价铁对水中U(Ⅵ)去除效能[J]. 化工学报, 2017, 68(8): 3282-3290.
[8]	俸志荣, 焦纬洲, 刘有智, 许承骋, 郭亮, 余丽胜. 铁碳微电解处理含硝基苯废水[J]. 化工学报, 2015, 66(3): 1150-1155.
[9]	赵雅光, 万俊锋, 王杰, 余飞, 王岩. 零价铁(ZVI)去除水中的As(Ⅲ)[J]. 化工学报, 2015, 66(2): 730-737.
[10]	朱文会, 王兴润, 董良飞, 王琪, 何洁. 海藻酸钠包覆型Fe-Cu双金属PRB填料的除Cr(Ⅵ)特性[J]. 化工学报, 2013, 64(9): 3373-3380.
[11]	殷其亮1，李筱琴1，2，李瑛1，肖阳1. 羧甲基纤维素钠改性零价铁在石英砂中的迁移能力[J]. 化工进展, 2013, 32(07): 1598-1603.
[12]	杨梅梅1，周少奇1，2，3，郑永鑫1，郑可1. 零价铁活化过硫酸钠降解甲基橙[J]. 化工进展, 2012, 31(09): 2093-2096.
[13]	樊明德1，2，袁鹏3，何宏平3，陈天虎4，朱建喜3，刘冬3，郝娇1. 化学液相还原法制备零价铁纳米颗粒研究进展及展望[J]. 化工进展, 2012, 31(07): 1542-1548.
[14]	庞龙1，周庆祥1，2，苏现伐1. 纳米零价铁修饰技术研究进展 [J]. CIESC Journal, 2011, 30(6): 1361-.
[15]	贾汉忠，宋存义，李晖. 纳米零价铁处理地下水污染技术研究进展 [J]. CIESC Journal, 2009, 28(11): 2028-.