对置液柱撞击液膜破裂特征

doi:10.3969/j.issn.0438-1157.2014.10.007

化工学报 ›› 2014, Vol. 65 ›› Issue (10): 3789-3797.DOI: 10.3969/j.issn.0438-1157.2014.10.007

对置液柱撞击液膜破裂特征

黄国峰, 李伟锋, 屠功毅, 王辅臣

华东理工大学煤气化及能源化工教育部重点实验室, 上海煤气化工程技术研究中心, 上海 200237

收稿日期:2014-01-24 修回日期:2014-03-28 出版日期:2014-10-05 发布日期:2014-10-05
通讯作者: 李伟锋
基金资助:
国家重点基础研究发展计划项目（2010CB227004）。

Characteristics of breakup of liquid sheet of axisymmetric opposed jets

HUANG Guofeng, LI Weifeng, TU Gongyi, WANG Fuchen

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, Shanghai Engineering Research Center of Coal Gasification, East China University of Science and Technology, Shanghai 200237, China

Received:2014-01-24 Revised:2014-03-28 Online:2014-10-05 Published:2014-10-05
Supported by:
supported by the National Basic Research Program of China (2010CB227004).

摘要/Abstract

摘要： 采用高速摄像仪对两液柱撞击产生液膜的破裂过程进行了实验研究。分析了撞击液膜的破裂过程及表面波产生和传播过程，考察了射流直径、喷嘴间距和射流Weber数（We）对撞击液膜破裂的影响；定量分析了液膜表面波频率的变化及液膜破裂后的粒径分布情况。研究结果表明，液膜表面波传播频率随We的增大而增大，并沿液膜径向方向逐渐减小；随着射流We的增加，液膜边缘的液滴脱落频率增加；当We>1000时，液膜表面产生大量液滴团，且液滴团对液膜破裂具有促进作用；液柱撞击液膜发生破裂后90%以上的量纲1液滴粒径分布在0～1之间。

关键词: 液柱撞击, 液膜破裂, 表面波

Abstract: The breakup process of liquid sheet formed by two axisymmetric opposed jets was experimentally studied with a high-speed camera. The breakup process, the generation and propagation process of surface wave of liquid sheet were analyzed. The influences of jet diameter, nozzle separation and jet Weber number on the breakup of liquid sheet were investigated. The frequency variation of surface wave and the size distribution of sheet disintegration were quantitatively analyzed. The propagation frequency of surface wave increased with increasing We, but decreased along the radial direction. The droplet shedding frequency of sheet edge increased with increasing We. At We>1000, a large number of droplet dots appeared at surface of liquid sheet, which promoted the breakup of liquid sheet. The non-dimensional drop size disintegrated from liquid sheet was mainly in the range of 0-1.

Key words: liquid impinging jets, sheet disintegration, surface wave

中图分类号:

TQ021.1

黄国峰, 李伟锋, 屠功毅, 王辅臣. 对置液柱撞击液膜破裂特征[J]. 化工学报, 2014, 65(10): 3789-3797.

HUANG Guofeng, LI Weifeng, TU Gongyi, WANG Fuchen. Characteristics of breakup of liquid sheet of axisymmetric opposed jets[J]. CIESC Journal, 2014, 65(10): 3789-3797.

参考文献 20

[1]	Elperin I T. Heat and mass transfer in opposing currents (in Russian) [J]. J.Engng.Phy., 1961, 6: 62-68
[2]	Li Weifeng (李伟锋). Applicable and fundamental studies on the flow characteristics of impinging streams [D]. Shanghai: East China University of Science and Technology, 2008
[3]	Li Qin (李勤). Experiment research on the wet flue gas desulfurization in the impinging stream absorber [D]. Changchun: Northeastern University, 2006
[4]	Hu Lishun (胡立舜), Wang Xingjun (王兴军). Study on absorption characteristics of impinging stream and its application in methanol synthesis [J]. Journal of Chemical Engineering of Chinese Universities (高校化学工程学报), 2009, 23 (3): 404-410
[5]	Wu Yuan, Li Qin, Li Fang. Desulfurization in the gas-continuous impinging stream gas-liquid reactor [J]. Chem.Eng.Sci., 2007, 62 (6): 1814-1824
[6]	Dehkordi A M. Application of a novel opposed jets contacting device in liquid-liquid extraction [J]. Chem.Eng.Process., 2002, 41 (3): 251-258
[7]	Hou Yanbing (侯妍冰), Tian Xiushan (田秀山), Zhao Hui (赵辉), Li Weifeng (李伟锋), Xu Jianliang (许建良), Liu Haifeng (刘海峰). Influence of viscoelasticity on liquid primary atomization [J]. CIESC Journal (化工学报), 2013, 64 (5): 1601-1606
[8]	Asghar Molaei Dehkordi, Chiya Savari. Determination of interfacial area and overall volumetric mass-transfer coefficient in a novel type of two impinging streams reactor by chemical method [J]. Ind.Eng.Chem.Res., 2011, 50: 6426-6435
[9]	Asghar Molaei Dehkordi. Novel type of impinging streams contactor for liquid-liquid extraction [J]. Ind.Eng.Chem.Res., 2001, 40: 681-688
[10]	Asghar Molaei Dehkordi. Liquid-liquid extraction with chemical reaction in a novel impinging-jets reactor [J]. AIChE J., 2002, 48 (10): 2230-2239
[11]	Heidmann M F, Priem R J, Humphrey J C. A study of sprays formed by two impacting jets [J]. NACA Tech.Note, 1957: 3835
[12]	Huang J C P. The break-up of axisymmetric liquid sheets [J]. J.Fluid Mech., 1970, 43: 305-319
[13]	Ri Li, Nasser Ashgriz. Characteristics of liquid sheets formed by two impinging jets [J]. Phys.Fluids, 2006, 18: 087104
[14]	Bremond N, Villermaux E. Atomization by jet impact [J]. J.Fluid Mech., 2006, 549: 273-306
[15]	Anderson William E, Ryan Harry M, Santoro Robert J. Impact wave-based model of impinging jet atomization [J]. Atomization Spray., 2006, 16: 791-805
[16]	Ri Li, Nasser Ashgriz. Edge instability and velocity of liquid sheets formed by two impinging jets [J]. Atomization Spray., 2007, 17: 71-97
[17]	Ashgriz N. Handbook of Atomization and Sprays [M]. New York: Springer, 2011: 75-95
[18]	Dombrowski N, Hooper P C. A study of the sprays formed by impinging jets in laminar and turbulent flow [J]. J.Fluid Mech., 1963, 19: 392-400
[19]	John W M, Alexander E. On the collision of laminar jets: fluid chains and fishbones [J]. J.Fluid Mech., 2004, 511: 285-310
[20]	Zhao Hui (赵辉). Study on the mechanism of coaxial air-blast atomization [D]. Shanghai: East China University of Science and Technology, 2012

对置液柱撞击液膜破裂特征

Characteristics of breakup of liquid sheet of axisymmetric opposed jets

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 1

编辑推荐

Metrics

本文评价