CIESC Journal

• 多相流 • 上一篇    下一篇

液体黏度对气液固逆流三相湍动床动力学行为的影响

曹长青;刘明言;王一平;秦秀云;胡宗定   

  1. 天津大学化工学院,天津 300072

  • 出版日期:2005-04-25 发布日期:2005-04-25

Effect of liquid viscosity on hydrodynamic behavior in inverse three-phase turbulent bed

CAO Changqing;LIU Mingyan;WANG Yiping;QIN Xiuyun;HU Zongding

  

  • Online:2005-04-25 Published:2005-04-25

Abstract: Local phase holdups in an inverse three-phase turbulent bed of 150 mm i.d. and 4350 mm height were measured simultaneously by micro-electrical conductivity probe technique in this study.The experiments were carried out with polyethylene particles (dp=4.01 mm, ρs=926 kg•m-3),air, and water[0.05%(mass)SCMC, 0.20%(mass)SCMC] as solid phase,gas phase and liquid phase respectively.540 sets of experimental data of local phase holdups in radial direction were obtained under Ug=Ug3. It was found that the distribution of local solid holdup showed a maximum peak at r/R=(0.75—0.90). The range of maximum peaks was larger than that of conventional fluidized beds. The distribution of local gas holdup in radial direction showed a maximum value at the column center and a minimum value near the wall.Moreover,the non-homogeneous distribution of local gas holdup in radial directions was more evident than that of conventional fluidized beds.The different operation regimes as well as the corresponding three specific gas velocities (Ug1,Ug2 and Ug3) were obtained on the basis of the axial distribution characteristics of cross-sectional average solid holdups.The effect of the operating conditions (liquid viscosity, initial volume fraction of solids Hs0/H0, initial liquid height Hl0) on the specific gas velocities was presented.