Measurements of Hydrate Equilibrium Conditions for CH4,CO2,and CH4+C2H6+C3H8 in Various Systems by Step-heating Method

CIESC Journal ›› 2009, Vol. 17 ›› Issue (4): 635-641.

Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method

陈立涛, 孙长宇, 陈光进, 聂运强, 孙占松, 刘延涛

State Key Laboratory of Heavy Oil Processing, China University of Petroleum, Beijing 102249, China

收稿日期:2008-10-06 修回日期:2009-04-17 出版日期:2009-08-28 发布日期:2010-12-30
通讯作者: CHEN Guangjin, E-mail: gjchen@cup.edu.cn
作者简介:
基金资助:
Supported by the National Natural Science Foundation of China(20676145,U0633003);the National Basic Research Program of China(2009CB219504);the Program for New Century Excellent Talents in University of the State Ministry of Education

Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method

CHEN Litao, SUN Changyu, CHEN Guangjin, NIE Yunqiang, SUN Zhansong, LIU Yantao

State Key Laboratory of Heavy Oil Processing, China University of Petroleum, Beijing 102249, China

Received:2008-10-06 Revised:2009-04-17 Online:2009-08-28 Published:2010-12-30
Supported by:
Supported by the National Natural Science Foundation of China(20676145,U0633003);the National Basic Research Program of China(2009CB219504);the Program for New Century Excellent Talents in University of the State Ministry of Education

摘要/Abstract

摘要： Phase equilibrium conditions of gas hydrate in several systems were measured by the step-heating method using the cylindrical transparent sapphire cell device.The experimental data for pure CH₄ or CO₂+deionized water systems showed good agreement with those in the literatures.This kind of method was then applied to CH₄/CO₂+sodium dodecyl sulfate(SDS)aqueous solution,CH₄/CO₂+SDS aqueous solution+silica sand,and(CH₄+C₂MH₆C₃H₈)gas mixture+SDS aqueous solution systems,where SDS was added to increase the hydrate formation rate without evident influence on the equilibrium conditions.The feasibility and reliability of the step-heating method,especially for porous media systems and gas mixtures systems were determined.The experimental data for CO₂+silica sand data shows that the equilibrium pressure will change significantly when the particle size of silica sand is less than 96μm.The formation equilibrium pressure was also measured by the reformation of hydrate.

关键词: equilibrium condition, hydrate, step-heating, sodium dodecyl sulfate, silica sand

Abstract: Phase equilibrium conditions of gas hydrate in several systems were measured by the step-heating method using the cylindrical transparent sapphire cell device.The experimental data for pure CH₄ or CO₂+deionized water systems showed good agreement with those in the literatures.This kind of method was then applied to CH₄/CO₂+sodium dodecyl sulfate(SDS)aqueous solution,CH₄/CO₂+SDS aqueous solution+silica sand,and(CH₄+C₂MH₆C₃H₈)gas mixture+SDS aqueous solution systems,where SDS was added to increase the hydrate formation rate without evident influence on the equilibrium conditions.The feasibility and reliability of the step-heating method,especially for porous media systems and gas mixtures systems were determined.The experimental data for CO₂+silica sand data shows that the equilibrium pressure will change significantly when the particle size of silica sand is less than 96μm.The formation equilibrium pressure was also measured by the reformation of hydrate.

Key words: equilibrium condition, hydrate, step-heating, sodium dodecyl sulfate, silica sand

陈立涛, 孙长宇, 陈光进, 聂运强, 孙占松, 刘延涛. Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method[J]. CIESC Journal, 2009, 17(4): 635-641.

CHEN Litao, SUN Changyu, CHEN Guangjin, NIE Yunqiang, SUN Zhansong, LIU Yantao. Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method[J]. , 2009, 17(4): 635-641.

参考文献

1 Sloan,E.D.,Koh,C.A.,Clathrate Hydrates of Natural Gases,3rd edition,CRC Press,New York(2008).
2 Makogon,Y.F.,Hydrates of Hydrocarbons,Pennwell Publishing Company,Tulsa Oklahoma(1997).
3 Qiu,J.H.,Guo,T.M.,“Kinetics of methane hydrate formation in pure water and inhibitor containing systems”,Chin.J.Chem.Eng., 10(3),316-322(2002).
4 Nixdorf,J.,Oellrich,L.R.,“Experimental determination of hydrate equilibrium conditions for pure gases,binary and ternary mixtures and natural gases”,Fluid Phase Equilibium,139,325-333(1997).
5 Kang,S.P.,Chun,M.K.,Lee,H.,“Phase equilibria of methane and carbon dioxide hydrates in the aqueous MgCl₂ solutions”,Fluid Phase Equilibrium,147,229-238(1998).
6 Fan,S.S,Liang,D.Q.,Guo,K.H.,“Hydrate equilibrium conditions for cyclopentane and a quaternary cyclopentane-rich mixture”,J. Chem.Eng.Data,46(4),930-932(2001).
7 Majumdar,A.,Mahmoodaghdam,E.,Bishnoi,P.R.,“Equilibrium hydrate formation conditions for hydrogen sulfide,carbon dioxide, and ethane in aqueous solutions of ethylene glycol and sodium chloride”,J.Chem.Eng.Data,45,20-22(2000).
8 Sun,C.Y.,Chen,G.J.,Lin,W.,Guo,T.M.,“Hydrate formation conditions of sour natural gases”,J.Chem.Eng.Data,48,600-602(2003).
9 Cha,S.B.,Ouar,H.,Wildeman,T.R.,Sloan,E.D.,“A third-surface effect on hydrate formation”,J.Phys.Chem.,92,6492-6494(1988).
10 Uchida,T.,Ebinuma,T.,Ishizaki,T.,“Dissociation condition measurements of methane hydrate in confined small pores of porous glass”,J.Phys.Chem.B,103,3659-3662(1999).
11 Seo,Y.T.,Lee,H.,“Multiple-phase hydrate equilibria of the ternary carbon dioxide,methane,and water mixtures”,J.Phys.Chem.B, 105,10084-10090(2001).
12 Dicharry,C.,Gayet,P.,Marion,G.,Graciaa,A.,Nesterov,A.N., “Modeling heating curve for gas hydrate dissociation in porous media”,J.Phys.Chem.B,109,17205-17211(2005).
13 Anderson,R.,Llamedo,M.,Tohidi,B.,Burgass,R.W.,“Experimental measurement of methane and carbon dioxide clathrate hydrate equilibria in mesoporous silica”,J.Phys.Chem.B,107,3507-3514 (2003).
14 Handa,Y.P.,Stupin,D.,“Thermodynamic properties and dissociation characteristics of methane and propane hydrates in 70Åradius silica gel pores”,J.Phys.Chem.,96,8599-8603(1992).
15 Zhang,W.,Wilder,J.W.,Smith,D.H.,“Methane hydrate-ice equilibria in porous media”,J.Phys.Chem.B,107,13084-13089(2003).
16 Seshadri,K.,Wilder,J.W.,Smith,D.H.,“Measurements of equilibrium pressures and temperatures for propane Hydrate in silica gels with different pore-size distributions”,J.Phys.Chem.B,105, 2627-2631(2001).
17 Ma,C.F.,Chen,G.J.,Wang,F.,Sun,C.Y.,Guo,T.M.,“Hydrate formation of(CH₄+C₂H4)and(CH₄+C3H6)gas mixtures”,Fluid Phase Equilibrium,191,41-47(2001).
18 Zhang,L.W.,Huang,Q.,Sun,C.Y.,Ma,Q.L.,Chen,G.J.,“Hydrate formation conditions of methane+ethylene+tetrahydrofuran+water systems”,J.Chem.Eng.Data,51,419-422(2006).
19 Huang,Q.,Sun,C.Y.,Chen,G.J.,Yang,L.Y.,“Hydrate formation conditions of(CH₄+CO₂+H₂S)ternary sour natural gases”,J. Chem.Ind.Eng.(China),56(7),1159-1163(2005).(in Chinese)
20 Luo,Y.T.,Zhu,J.H.,Chen,G.J.,“Numerical simulation of separating gas mixtures via hydrate formation in bubble column”,Chin.J. Chem.Eng.,15(3),345-352(2007).
21 Zhong,Y.,Rogers,R.E.,“Surfactant effects on gas hydrate formation”,Chem.Eng.Sci.,55,4175-4187(2000).
22 Karaaslan,U.,Uluneye,E.,Parlaktuna,M.,“Effect of an anionic surfactant on different type of hydrate structures”,J.Petrol.Sci. Eng.,35,49-57(2002).
23 Lin,W.,Chen,G.J.,Sun,C.Y.,Guo,X.Q.,Wu,Z.K.,Liang,M.Y., Chen,L.T.,Yang,L.Y.,“Effect of surfactant on the formation and dissociation kinetic behavior of methane hydrate”,Chem.Eng.Sci., 59,4449-4455(2004).
24 Sun,C.Y.,Chen,G.J.,Ma,C.F.,Huang,Q.,Luo,H.,Li,Q.P.,“The growth kinetics of hydrate film on the surface of gas bubble suspended in water or aqueous surfactant solution”,J.Cryst.Growth, 306,491-499(2007).
25 Gayet,P.,Dicharry,C.,Marion,G.,Graciaa,A.,Lachaise,J., Nesterov,A.,“Experimental determination of methane hydrate dissociation curve up to 55 MPa by using a small amount of surfactant as hydrate promoter”,Chem.Eng.Sci.,60,5751-5758(2005).
26 Schicks,J.M.,Naumann,R.,Erzinger,J.,Hester,K.C.,Koh,C.A., Sloan,E.D.,“Phase transitions in mixed gas hydrates:Experimental observations versus calculated data”,J.Phys.Chem.B,110, 11468-11474(2006).

[1]	刘蓓, 王秀林, 唐绪龙, 杨兰英, 孙长宇, 陈光进. Recovery of Hydrogen from Ammonia Plant Tail Gas by Absorption-Hydration Hybrid Method[J]. CIESC Journal, 2011, 19(5): 784-791.
[2]	张保勇, 程远平, 吴强. Sponge Effect on Coal Mine Methane Separation Based on Clathrate Hydrate Method [J]. CIESC Journal, 2011, 19(4): 610-614.
[3]	孙长宇, 李文志, 杨新, 李风光, 袁青, 穆亮, 陈俊, 刘蓓, 陈光进. Progress in Research of Gas Hydrate[J]. CIESC Journal, 2011, 19(1): 151-162.
[4]	李士凤, 樊栓狮, 王金渠, 郎雪梅, 王燕鸿. Clathrate Hydrate Capture of CO₂ from Simulated Flue Gas with Cyclopentane/Water Emulsion[J]. CIESC Journal, 2010, 18(2): 202-206.
[5]	杨明军, 宋永臣, 刘瑜, 陈拥军, 李清平. Influence of Pore Size,Salinity and Gas Composition upon the Hydrate Formation Conditions[J]. CIESC Journal, 2010, 18(2): 292-296.
[6]	彭效明, 胡玉峰, 杨兰英, 金传伟. Decomposition Kinetics for Formation of CO₂ Hydrates in Natural Silica Sands[J]. CIESC Journal, 2010, 18(1): 61-65.
[7]	李淑霞, 夏晞冉, 玄建, 刘亚平, 李清平. Resistivity in Formation and Decomposition of Natural Gas Hydrate in Porous Medium[J]. CIESC Journal, 2010, 18(1): 39-42.
[8]	臧小亚, 杜建伟, 梁德青, 樊栓狮, 唐翠萍. Influence of A-type Zeolite on Methane Hydrate Formation[J]. CIESC Journal, 2009, 17(5): 854-859.
[9]	程文婷, 李志宝, George P. Demopoulos. Effects of Temperature on the Preparation of Magnesium Carbonate Hydrates by Reaction of MgCl₂ with Na₂CO₃[J]. CIESC Journal, 2009, 17(4): 661-666.
[10]	高健, 任瑛, 葛蔚. Molecular Dynamics Simulation of Effect of Salt on the Compromise of Hydrophilic and Hydrophobic Interactions in Sodium Dodecyl Sulfate Micelle Solutions[J]. CIESC Journal, 2009, 17(4): 654-660.
[11]	王秀林, 陈光进, 孙长宇, 杨兰英, 马庆兰, 陈俊, 刘鹏, 唐绪龙, 赵焕伟, 陈卫东. The Dependence of the Dissociation Rate of Methane-SDS Hydrate below Ice Point on Its Manners of Forming and Processing[J]. CIESC Journal, 2009, 17(1): 128-135.
[12]	罗艳托, 朱建华, 陈光进. 鼓泡塔中水合物法分离混合气体的数值模拟[J]. CIESC Journal, 2007, 15(3): 345-352.
[13]	高军, Kenneth N. Marsh. 天然气水合物生成焓的实验研究[J]. CIESC Journal, 2003, 11(3): 276-279.
[14]	王静康, 刘勇, 尹秋响. 一水盐酸环丙沙星初级成核机理的研究[J]. CIESC Journal, 2002, 10(4): 375-380.
[15]	裘俊红, 郭天民. 甲烷水合物在纯水和抑制剂体系中的生成动力学[J]. CIESC Journal, 2002, 10(3): 316-322.

Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method

Measurements of Hydrate Equilibrium Conditions for CH₄,CO₂,and CH₄+C₂H₆+C₃H₈ in Various Systems by Step-heating Method

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价