超临界压力水在垂直上升内螺纹管中的传热特性

摘要/Abstract

摘要：

在压力22.5～30 MPa，质量流速430～1200 kg·m^-2·s^-1，内壁热负荷284～719 kW·m^-2范围内，对超临界压力水在均匀加热垂直上升内螺纹管内的传热特性进行了实验研究，得到了内螺纹管内超临界压力水的传热特性，分析了压力、热负荷和质量流速变化对内螺纹管壁温及传热系数的影响，探讨了拟临界区的传热机理，并给出了能用于工程实际的传热实验关联式。实验结果表明：垂直上升内螺纹管中超临界水具有良好的传热特性。在低焓值区内螺纹管壁温随焓增平缓增加，而在高焓值区壁温随焓增的升高明显。由于热物性的剧烈变化，超临界水在拟临界焓值区发生了明显的传热强化。压力与热负荷的增大以及质量流速的减小均会导致内螺纹管壁温的升高和传热系数的减小，使得传热强化现象削弱，甚至出现传热恶化。

关键词: FONT-FAMILY: 宋体, mso-bidi-font-size: 11.0pt, mso-bidi-font-family: 宋体, mso-font-kerning: 1.0pt, mso-ansi-language: EN-US, mso-fareast-language: ZH-CN, mso-bidi-language: AR-SA, mso-ascii-font-family: Calibri">超临界压力；内螺纹管；壁温；传热系数；拟临界点；传热强化

Abstract:

In the range of pressure from 22. 5 MPa to 30 MPa, mass flow rate from 430 kg·m-2·s^-1 to 1200 kg·m^-2·s^-1, and heat flux at inner wall from 284 kW·m^-2 to 719 kW·m^-2^, an experiment was conducted under supercritical pressure to investigate the heat transfer characteristics of water in a vertical upward rifled tube.The temperature distribution in the tube wall was obtained.The effects of pressure, heat flux at inner wall and mass flow rate on heat transfer coefficient and temperature at inner wall were analyzed, the enhancement mechanism for heat transfer was discussed, and the corresponding empirical correlations were presented.The experimental results show that the supercritical pressure water in the vertical upward rifled tube presents very good heat transfer characteristics.The wall temperature in the rifled tube increases slowly with fluid enthalpy when the bulk temperature of fluid is lower than the pseudo-critical temperature and increases considerably when the bulk temperature is above the pseudo-critical temperature.At the temperature near the pseudo-critical temperature, the thermophysical properties of water under supercritical pressure change abruptly.Therefore, the heat transfer is enhanced in the pseudo-critical enthalpy region.With the increase of pressure and heat flux of inner wall and with the decrease of mass flow rate, the temperature of inner wall increases and the heat transfer coefficient decreases obviously, the enhancement on heat transfer is weakened and the heat transfer may be deteriorated.

Key words: FONT-FAMILY: 宋体, mso-bidi-font-size: 11.0pt, mso-bidi-font-family: 宋体, mso-font-kerning: 1.0pt, mso-ansi-language: EN-US, mso-fareast-language: ZH-CN, mso-bidi-language: AR-SA, mso-ascii-font-family: Calibri">超临界压力；内螺纹管；壁温；传热系数；拟临界点；传热强化

潘杰, 杨冬, 朱探, 董自春, 毕勤成. 超临界压力水在垂直上升内螺纹管中的传热特性 [J]. 化工学报, 2011, 62(2): 307-314.

PAN Jie, YANG Dong, ZHU Tan, DONG Zichun, BI Qincheng. Heat transfer characteristics of supercritical pressure water in vertical upward rifled tube[J]. CIESC Journal, 2011, 62(2): 307-314.

[1]	胡朝发, 贾力. 脉动热管气液塞振荡运动模型 [J]. 化工学报, 2011, 62(S1): 113-117.
[2]	李旺, 王情愿, 李瑞龙, 李超, 宇波, 张劲军, 代鹏飞. 大型浮顶油罐温度场数值模拟 [J]. 化工学报, 2011, 62(S1): 108-112.
[3]	刘绩伟, 吴玉庭, 马重芳. 管肋式空间辐射器设计 [J]. 化工学报, 2011, 62(S1): 103-107.
[4]	何奎, 汪双凤, 黄间珍. 气液两相流在微小T型三通中的相分配特性 [J]. 化工学报, 2011, 62(S1): 92-96.
[5]	崔福庆, 何雅玲, 程泽东, 李东, 陶于兵. 有压腔式吸热器内辐射传播过程的Monte Carlo模拟 [J]. 化工学报, 2011, 62(S1): 60-65.
[6]	马维刚, 王海东, 张兴, 王玮. 多晶金薄膜电子-声子耦合的实验研究 [J]. 化工学报, 2011, 62(S1): 48-53.
[7]	王建立, 朱建军, 宋辰兴, 张兴. 3ω法测量纳米流体热导率 [J]. 化工学报, 2011, 62(S1): 42-47.
[8]	张艾萍, 谢立强, 徐志明. 超声空化对换热器协同场的影响 [J]. 化工学报, 2011, 62(S1): 130-133.
[9]	曾庆, 郭印诚, 牛振祺, 林文漪. 填料塔中氨水吸收二氧化碳的传质性能 [J]. 化工学报, 2011, 62(S1): 146-150.
[10]	褚燕彬, 曹柳林, 王晶. 利用组合B样条神经网络实现对间歇反应过程的动态建模 [J]. 化工学报, 2011, 62(S1): 157-162.
[11]	吴海波, 方岩雄, 纪红兵. 助溶剂促进的β-环糊精与肉桂醛的包结性能 [J]. 化工学报, 2011, 62(S1): 168-173.
[12]	任楠, 王涛, 吴玉庭, 马重芳. 混合碳酸盐的DSC测量与比热容分析 [J]. 化工学报, 2011, 62(S1): 197-202.
[13]	王勤辉，杨秋辉，吴学成，骆仲泱，岑可法. 多相流中颗粒旋转运动特性的研究进展 [J]. CIESC Journal, 2011, 62(9): 2381-2390.
[14]	刘夺, 杜瑾, 赵广荣, 元英进. 合成生物学在医药及能源领域的应用 [J]. 化工学报, 2011, 62(9): 2391-2397.
[15]	马淳安，储诚普，徐颖华，张虹. 3,6-二氯吡啶甲酸合成方法进展 [J]. CIESC Journal, 2011, 62(9): 2398-2405.

超临界压力水在垂直上升内螺纹管中的传热特性

Heat transfer characteristics of supercritical pressure water in vertical upward rifled tube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价