飞灰酸碱性对二噁英从头合成的影响

doi:10.11949/j.issn.0438-1157.20150769

化工学报 ›› 2015, Vol. 66 ›› Issue (12): 4972-4979.DOI: 10.11949/j.issn.0438-1157.20150769

飞灰酸碱性对二噁英从头合成的影响

詹明秀¹, 陈彤¹, 付建英^1,2, 侯霞丽^1,3, 李晓东¹, 严建华¹

1 浙江大学能源清洁利用国家重点实验室, 浙江杭州 310027;
2 中国联合工程公司, 浙江杭州 310052;
3 江苏江南环保有限公司, 江苏宜兴 214214

收稿日期:2015-06-01 修回日期:2015-07-21 出版日期:2015-12-05 发布日期:2015-12-05
通讯作者: 陈彤
基金资助:
国家重点基础研究发展计划项目(2011CB201503);国家自然科学基金项目(51476138)。

Effects of acidity and alkaline of fly ash on de novo synthesis of dioxins

ZHAN Mingxiu¹, CHEN Tong¹, FU Jianying^1,2, HOU Xiali^1,3, LI Xiaodong¹, YAN Jianhua¹

1 State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, Zhejiang, China;
2 China United Engineering Corporation, Hangzhou 310052, Zhejiang, China;
3 Jiangsu Jiannan Environmental Protection Company, Yixing 214214, Jiangsu, China

Received:2015-06-01 Revised:2015-07-21 Online:2015-12-05 Published:2015-12-05
Supported by:
supported by the National Basic Research Program of China (2011CB201503) and the National Natural Science Foundation of China (51476138).

摘要/Abstract

摘要：

飞灰表面的酸碱性对二噁英的从头合成反应影响较大,不仅能够改变二噁英的生成量,而且对二噁英同分异构体的分布也存在一定的影响。本文通过在实验室可控条件下添加不同比例的Ca(H₂PO₄)₂和CaO酸碱性物质,改变模拟飞灰表面的pH,研究不同酸碱性对二噁英从头合成反应的影响。研究表明,添加5%(质量)的Ca(H₂PO₄)₂时,飞灰表面的pH由原始的5.5下降至4.3,二噁英总量增加,而毒性当量基本不变;添加20%(质量)的Ca(H₂PO₄)₂时,pH降低到3.6,生成的二噁英总量和毒性当量均下降;而添加0.4%(质量)、5%(质量)和20%(质量)的CaO调节pH至9.8、12.4和12.6时,二噁英总量及毒性当量均有减少。因此,飞灰表面碱性环境较酸性环境对二噁英从头合成反应的抑制效果好。此外,本文还研究实际焚烧炉飞灰中二噁英总量与碱酸比的相关性,结果表明流化床飞灰中二噁英总量与碱酸比的相关系数高达0.95,而炉排炉飞灰中两者之间不存在相关性。

关键词: 模拟飞灰, 酸碱性, 二噁英, 从头合成, 相关性

Abstract:

The acidity and alkaline of fly ash could significantly affect the de novo synthesis of dioxins. It could not only influence the total concentration of dioxins, but also the distribution of congeners. In this study, different amounts of Ca(H₂PO₄)₂ and CaO were added to control the pH values of model fly ashes. Experiments were conducted to study the effects of acidity and alkaline of fly ash on de novo synthesis of dioxins. The results suggested that the amount of dioxins increased and the I-TEQ values didn't change when pH values decreased from 5.5 to 4.3 with an addition of 5% (mass) Ca(H₂PO₄)₂. When pH value decreased to 3.6 with an addition of 20% (mass) Ca(H₂PO₄)₂, the total concentration of dioxins and I-TEQ value went down. While with additions of 0.4% (mass), 5% (mass) and 20% (mass) CaO, the pH values increased to 9.8, 12.4 and 12.6 and the total concentration of dioxins went down as well as the I-TEQ values. Therefore, the alkaline environment of fly ash could be better to suppress the formation of dioxins than the acidic environment. Meanwhile, the correlations between the total concentrations of dioxins in fly ash and base/acid ratios were studied. The results revealed that the correlation value for fly ashes produced from fluidized bed was 0.95, however, there is no relationship for fly ashes which were collected from grate furnace.

Key words: model fly ash, acidity and alkaline, dioxins, de novo synthesis, correlation

中图分类号:

X705

詹明秀, 陈彤, 付建英, 侯霞丽, 李晓东, 严建华. 飞灰酸碱性对二噁英从头合成的影响[J]. 化工学报, 2015, 66(12): 4972-4979.

ZHAN Mingxiu, CHEN Tong, FU Jianying, HOU Xiali, LI Xiaodong, YAN Jianhua. Effects of acidity and alkaline of fly ash on de novo synthesis of dioxins[J]. CIESC Journal, 2015, 66(12): 4972-4979.

参考文献 28

[1]	National Bureau of Statistics of the People's Republic of China (中华人民共和国国家统计局). China Statistical Yearbook-2014 (中国统计年鉴-2014) [G]. Beijing: China Statistics Press, 2014.
[2]	Olie K, Vermeulen P L, Hutzinger O. Chlorodibenzo-p-dioxins and chlorodibenzofurans are trace components of fly ash and flue gas of some municipal incinerators in the Netherlands [J]. Chemosphere, 1977, 6 (8): 455-459.
[3]	Mckay G. Dioxin characterisation, formation and minimisation during municipal solid waste (MSW) incineration: review [J]. Chemical Engineering Journal, 2002, 86 (3): 343-368.
[4]	Zhang G, Hai J, Cheng J. Characterization and mass balance of dioxin from a large-scale municipal solid waste incinerator in China [J]. Waste Management, 2012, 32 (6): 1156-1162.
[5]	Pan Y, Yang L, Zhou J, Liu J, Qian G, Ohtsuka N. Characteristics of dioxins content in fly ash from municipal solid waste incinerators in China [J]. Chemosphere, 2013, 92 (7): 765-771.
[6]	Sun Y, Watanabe N, Qiao W, Gao X, Wang W, Zhu T. Polysulfide as a novel chemical agent to solidify/stabilize lead in fly ash from municipal solid waste incineration [J]. Chemosphere, 2010, 81 (1): 120-126.
[7]	Shen Dongsheng (沈东升), Zheng Yuange (郑元格), Yao Jun (姚俊), Wang Meizhen (汪美贞), Zhang Yu (张宇), Wang Fengtao (王峰涛), Fan Xingen (范信根). Analysis of pollution characteristics of solid waste incinerator fly ash in Zhejiang province [J]. Chinese Journal of Environmental Science (环境科学), 2011, 32 (9): 2610-2616.
[8]	Naikwadi K P, Albrecht I D, Karasek F W. Mechanism of formation of PCDD/PCDF in industrial waste incineration and a method of prevention of their formation [J]. Chemosphere, 1993, 27 (1/2/3): 335-342.
[9]	Lu S, Chen T, Yan J, Li X, Ni M, Cen K. Effects of calcium-based sorbents on PCDD/F formation from pentachlorophenol combustion process [J]. Journal of Hazardous Materials, 2007, 147 (1/2): 663-671.
[10]	Yan Jianhua (严建华), Lu Shengyong (陆胜勇), Li Xiaodong (李晓东), Chen Tong (陈彤), Chi Yong (池涌), Ni Mingjiang (倪明江), Cen Kefa (岑可法). Dioxin contets in fly ash from a fluidized bed co-firing incinerator [J]. Journal of Engineering Thermophysics (工程热物理学报), 2004, 25 (1): 155-158.
[11]	Liu W, Liu W, Zheng M, Zhang B, Qian Y, Ma X. Inhibition of PCDD/Fs formation from dioxin precursors by calcium oxide [J]. Chemosphere, 2005, 60 (6): 785-790.
[12]	Wang Y, Liu W. Effect of temperature and CaO addition on the removal of polychlorinated dibenzo-p-dioxins and dibenzofurans in fly ash from a medical waste incinerator [J]. Aerosol and Air Quality Research, 2012, 12 (2): 191-199.
[13]	Zheng M, Liu W. Method for treating fly ash by using calcium oxide (CaO) [P]: CN, 20091235469. 2009-10-14.
[14]	Addink R, Cnubben P A J P, Olie K. Formation of polychlorinated dibenzo-p-dioxins/dibenzofurans on fly ash from precursors and carbon model compounds [J]. Carbon, 1995, 33 (10): 1463-1471.
[15]	Gullett B, Bruce K, Beach L, Drago A. Mechanistic steps in the production of PCDD and PCDF during waste combustion [J]. Chemosphere, 1992, 25 (7/8/9/10): 1387-1392.
[16]	Fu J, Li X, Chen T, Lin X, Alfons B, Lu S, Yan J, Cen K. PCDD/Fs' suppression by sulfur-amine/ammonium compounds [J]. Chemosphere, 2015, 123: 9-16.
[17]	Chen T, Zhan M, Lin X, Li X, Lu S, Yan J, Cen K. Inhibition of the de novo synthesis of PCDD/Fs on model fly ash by sludge drying gases [J]. Chemosphere, 2014, 114: 226-232.
[18]	Bhavsar S P, Reiner E J, Hayton A, Fletcher R, MacPherson K. Converting toxic equivalents (TEQ) of dioxins and dioxin-like compounds in fish from one toxic equivalency factor (TEF) scheme to another [J]. Environment International, 2008, 34 (7): 915-921.
[19]	Chen T, Yan J, Lu S, Li X, Gu Y, Dai H, Ni M, Cen K. Characteristic of polychlorinated dibenzo-p-dioxins and dibenzofurans in fly ash from incinerators in china [J]. Journal of Hazardous Materials, 2008, 150 (3): 510-514.
[20]	López N, Gómez-Segura J, Marín R, Pérez-Ramírez J. Mechanism of HCl oxidation (Deacon process) over RuO2 [J]. Journal of Catalysis, 2008, 255 (1): 29-39.
[21]	Tsuyumoto I, Kinomura M, Kuzuhara K. Inhibition of dioxin formation in flue gas by removal of hydrogen chloride using foaming water glass [J]. Journal of the Ceramic Society of Japan, 2006, 114 (1329): 408-410.
[22]	Qian Yong (钱永), Zheng Minghui (郑明辉), Liu Wenbin (刘文彬), Zhang Bing (张兵). Inhibition of calcium oxide, hydroxide and salts on PCDD/Fs formation from precursors [J]. Environmental Chemistry (环境化学), 2005, (6): 4-8.
[23]	Huang Qianjun (黄千钧). The product of base/acid and silica/alumina of ash in steal coal-an index to ash slagging tendency [J]. Power Engineering (动力工程), 2004, 24 (3): 340-344.
[24]	Takaoka M, Shiono A, Yamamoto T, Uruga T, Takeda N, Tanaka T, Oshita K, Matsumoto T, Harada H. Relationship between dynamic change of copper and dioxin generation in various fly ash [J]. Chemosphere, 2008, 73 (Supplement): S78-S83.
[25]	Yive N S C K, Tiroumalechetty M. Dioxin levels in fly ash coming from the combustion of bagasse [J]. Journal of Hazardous Materials, 2008, 155 (1/2): 179-182.
[26]	Wu Shangan (吴善淦), Mu Luying (穆璐莹), Shen Yuxiang (沈玉祥), Wu Gang (吴刚), Wang Jian (王健). Application research on tail gas purifying treatment system of refuse incinerator with dry process [J]. China Environmental Protection Industry (中国环保产业), 2008, (8): 38-40.
[27]	Kanters J, Louw R. Chlorine input and output in combustion of municipal solid waste in a lab-scale mini-reactor system [J]. Chemosphere, 1994, 29 (9/10/11): 1919-1925.
[28]	Li Rundong (李润东), Nie Yongfeng (聂永丰), Li Aimin (李爱民), Wang Lei (王雷), Yan Jianhua (严建华), Cen Kefa (岑可法). Study on physical chemical characteristics of fly ash from municipal solid waste incinerator [J]. Journal of Fuel Chemistry and Technology (燃烧化学学报), 2004, (2): 175-179.

飞灰酸碱性对二噁英从头合成的影响

Effects of acidity and alkaline of fly ash on de novo synthesis of dioxins

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 28

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吴悦溪, 曾薇, 刘宏, 李健敏, 彭永臻. Feammox系统内氮素转化途径的研究[J]. 化工学报, 2020, 71(5): 2265-2272.
[2]	汤健, 乔俊飞. 基于选择性集成核学习算法的固废焚烧过程二噁英排放浓度软测量[J]. 化工学报, 2019, 70(2): 696-706.
[3]	郑文静, 李绍军, 蒋达. D-vine copulas混合模型及其在故障检测中的应用[J]. 化工学报, 2017, 68(7): 2851-2858.
[4]	李秋美, 田学民, 尚林源. 基于偏相关性分析的MPC控制器模型失配检测[J]. 化工学报, 2016, 67(3): 852-857.
[5]	李元, 章展鹏, 徐鸣远, 陈丙珍, 赵劲松. 非规整报警的相关性分析方法[J]. 化工学报, 2015, 66(8): 3153-3160.
[6]	廖钧红, 杨杰, 孟炜杰, 李晓东, 陈彤. Zn、Cd 化合物对模拟飞灰中二噁英生成的影响[J]. 化工学报, 2015, 66(7): 2643-2648.
[7]	王奇, 陈佳, 王超, 李敏, 陈彤, 陆胜勇, 李晓东, 蒋旭光, 严建华. 医疗废物焚烧炉启炉过程二噁英排放特性[J]. 化工学报, 2015, 66(1): 419-425.
[8]	付建英, 陈彤, 吴海龙, 林晓青, 陆胜勇, 李晓东. SO₂抑制二噁英从头合成的实验及其过程模拟[J]. 化工学报, 2014, 65(9): 0-0.
[9]	易军, 李太福, 张元涛, 周伟, 田应甫. 基于混合Copula模型的铝电解槽多参数相关性分析[J]. 化工学报, 2014, 65(4): 1327-1332.
[10]	郑皎1，2，池涌2，李建新1，王永川1，胡长兴1. 高含氯固体废弃物流化床气化的二噁英生成特性[J]. 化工学报, 2012, 63(3): 910-915.
[11]	谢丽莎，陈霄榕. 固体酸碱性质对丙酮缩合生成异佛尔酮反应的影响 [J]. CIESC Journal, 2010, 29(7): 1230-.
[12]	杜建科. 利用遗传神经网络预测有机物的易燃下限温度 [J]. CIESC Journal, 2010, 61(12): 3067-3071.
[13]	付丽敏，柴欣生，胡立新，占稳. 新型柠檬酸碱性镀铜工艺中镀层厚度的预测模型 [J]. CIESC Journal, 2010, 61(11): 2906-2911.
[14]	严密, 李晓东, 张晓翔, 陆胜勇, 严建华. 水对前驱物催化合成二噁英的影响 [J]. 化工学报, 2010, 61(1): 86-90.
[15]	严密, 李晓东, 张晓翔, 刘科, 严建华, 岑可法. 金属化合物催化多环芳烃合成二噁英的机理 [J]. 化工学报, 2009, 60(5): 1254-1259.