单层钢丝柔性桨强化搅拌槽中流体混沌混合行为

doi:10.11949/j.issn.0438-1157.20170674

化工学报 ›› 2017, Vol. 68 ›› Issue (12): 4592-4599.DOI: 10.11949/j.issn.0438-1157.20170674

单层钢丝柔性桨强化搅拌槽中流体混沌混合行为

刘作华¹, 许恢琴¹, 谷德银¹, 许传林¹, 谢昭明¹, 陶长元¹, 王运东²

1 重庆大学化学化工学院, 重庆 400044;
2 清华大学化学工程系, 北京 100084

收稿日期:2017-05-23 修回日期:2017-07-03 出版日期:2017-12-05 发布日期:2017-12-05
通讯作者: 刘作华
基金资助:
国家自然科学基金项目（21576033）；国家自然科学基金重点项目（21636004）；重庆市社会民生科技创新专项项目（cstc2015shmszx100024）；中央高校基本科研业务费专项项目（106112017CDJQJ228808）。

Chaotic mixing performance enhanced by single-wire flexible impeller in stirred vessel

LIU Zuohua¹, XU Huiqin¹, GU Deyin¹, XU Chuanlin¹, XIE Zhaoming¹, TAO Changyuan¹, WANG Yundong²

1 School of Chemistry and Chemical Engineering, Chongqing University, Chongqing 400044, China;
2 Department of Chemical Engineering, Tsinghua University, Beijing 100084, China

Received:2017-05-23 Revised:2017-07-03 Online:2017-12-05 Published:2017-12-05
Supported by:
supported by the National Natural Science Foundation of China (21576033), the Key Project of National Natural Science Foundation of China (21636004), the People's Livelihood and Science Technology Innovation (cstc2015shmszx100024) and the Fundamental Research Funds for the Central Universities (106112017CDJQJ228808).

摘要/Abstract

摘要：

实验运用扭矩传感器测量搅拌功率特性，Matlab软件编程计算最大Lyapunov指数（LE_max），流场可视化技术观测流体混合状态。研究了桨叶类型、桨叶离底距离、柔性钢丝长度、柔性钢丝直径对混合效率数（C_e）、LE_max的影响。结果表明：单层钢丝柔性桨通过刚-柔-流耦合作用，改变流场结构和能量耗散方式，提高了流体混沌混合程度，实现了流体的高效节能混合；当转速为120 r·min⁻¹时，与传统刚性桨相比，单层钢丝柔性桨使流体C_e减小了87.4%，LE_max增大了53.2%，与单层钢丝刚性桨相比，单层钢丝柔性桨使流体C_e减小了43.8%，LE_max增大了10.8%。另外，当搅拌转速相同时，柔性钢丝越长，越有利于流体混沌混合，但其功耗也会随之明显增加；当柔性钢丝直径为0.8 mm，桨叶离底距离为0.25T（T为搅拌槽内径）时，各个转速对应的C_e小于其他情况、LE_max大于其他情况，流体达到相对最佳混沌混合状态。

关键词: 钢丝, 柔性桨, 混合时间, 混合效率数, 最大Lyapunov指数, 混沌混合

Abstract:

Mixing power were characterized by torque sensor. The largest Lyapunov exponents were computed by Matlab software. The fluid mixing performances were observed by the fluid field's visualization technology. A comprehensive experimental study on the effects of impeller type, the distance between impeller and bottom, the length of flexible wire, and the diameter of flexible wire on the number of mixing efficiency (C_e), and the largest Lyapunov exponents (LE_max) was carried out. Results showed that, single-wire flexible impeller can regulate and control the flow field structure and the way of energy dissipation, and effectively enhance the chaotic mixing. At rotation speed 120 r·min⁻¹, compared with the traditional rigid impeller, C_e was decreased by 87.4% and LE_max was increased by 53.2% with single-wire flexible impeller, C_e was decreased by 43.8% and LE_max was increased by 10.8% compared with single-wire rigid impeller. In addition, at the same agitation speed, the longer the flexible wire, the more conducive to the chaotic mixing, but its power consumption would also increase obviously. The diameter of flexible wire was measured at 0.8 mm, while C_e was less than the others and LE_max was larger than the others, which indicated that the degree of chaotic mixing was the largest in the case. Increasing the diameter of flexible wire led to the increase of fluid motion irregularity and the degree of chaotic mixing. If the diameter of flexible wire is more than 0.8 mm, the disturbance of flexible wire was reduced, which was close to the traditional rigid impeller, resulting in the decrease of chaotic mixing characteristics. It was not conducive to fluid mixing while the distance between impeller and bottom was too high or too low, the optimal distance between impeller and bottom was at 0.25T (T was used to express the inner diameter of stirred vessel).

Key words: wire, flexible impeller, mixing time, number of mixing efficiency, largest Lyapunov exponents, chaotic mixing

中图分类号:

TQ027.2

刘作华, 许恢琴, 谷德银, 许传林, 谢昭明, 陶长元, 王运东. 单层钢丝柔性桨强化搅拌槽中流体混沌混合行为[J]. 化工学报, 2017, 68(12): 4592-4599.

LIU Zuohua, XU Huiqin, GU Deyin, XU Chuanlin, XIE Zhaoming, TAO Changyuan, WANG Yundong. Chaotic mixing performance enhanced by single-wire flexible impeller in stirred vessel[J]. CIESC Journal, 2017, 68(12): 4592-4599.

参考文献 31

[1]	PAUL E L, ATIEMO-OBENG V A, KREST S M. Handbook of Industry Mixing:Science and Practice[M]. Hoboken:John Wiley & Sons, Inc, 2004:89-143.
[2]	陈志平, 章序文, 林兴华. 搅拌与混合设备设计选用手[M]. 北京:化学工业出版社, 2004. CHEN Z P, ZHANG X W, LIN X H. Handbook of Stirring and Mixing Equipment Design Selection[M]. Beijing:Chemical Industry Press, 2004.
[3]	王凯, 虞军. 搅拌设备[M]. 北京:化学工业出版社, 2003. WANG K, YU J. Mixing Equipment[M]. Beijing:Chemical Insdury Press, 2003.
[4]	冯连芳. 搅拌设备设计的发展与建议[J]. 化工设备与管道, 2010, (5):1-4. FENG L F. Development and proposal of mixing equipment design[J]. Process Equipment & Piping, 2010, (5):1-4.
[5]	ARRATIA P E, KUKURA J, LACOMBE J, et al. Mixing of shear-thinning fluids with yields stress in stirred tanks[J]. AIChE J., 2006, 52(7):2310-2322.
[6]	MASIUK S, RAKOCZY R. Power consumption, mixing time, heat and mass transfer measurements for liquid vessels that are mixed using reciprocating multiplates agitators[J]. Chemical Engineering and Processing, 2007, 46:89-98.
[7]	刘作华, 宁伟征, 孙瑞祥, 等. 偏心空气射流双层桨搅拌反应器流场结构的分形特征[J]. 化工学报, 2011, 62(3):628-635. LIU Z H, NING W Z, SUN R X, et al. Fractal flow structure in air jet-stirred reactor with double impeller[J]. CIESC Journal, 2011, 62(3):628-635.
[8]	葛春艳. 基于PIV和CFD的搅拌桨设计和改进[D]. 杭州:浙江大学, 2014. GE C Y. Design and improvement of agitators using PIV and CFD methods[D]. Hangzhou:Zhejiang University, 2014.
[9]	葛春艳, 王嘉骏, 顾雪萍, 等. PIV和CFD在搅拌桨设计和优化中的应用[J]. 化工与医药工程, 2014, (1):29-33. GE C Y, WANG J J, GU X P, et al. Application of PIV and CFD in impeller design and optimization[J]. Chemical and Pharmaceutical Engineering, 2014, (1):29-33.
[10]	胡锡文, 林兴华, 刘海洋, 等. 8种搅拌器搅拌特性的实验研究[J]. 化工机械, 2005, 32(5):259-262. HU X W, LIN X H, LIU H Y, et al. Experimental investigations on the mixing characteristics of eight mixers[J]. Chemical Engineering & Machinery, 2005, 32(5):259-262.
[11]	AMEUR H. Energy efficiency of different impellers in stirred tank reactors[J]. Energy (Oxford), 2015, 93(2):1980-1988.
[12]	刘作华, 陈超, 刘仁龙, 等. 刚柔组合搅拌桨强化搅拌槽中流体混沌混合[J]. 化工学报, 2014, 65(1):61-70. LIU Z H, CHEN C, LIU R L, et al. Chaotic mixing enhanced by rigid-flexible impeller in stirred vessel[J]. CIESC Journal, 2014, 65(1):61-70.
[13]	刘作华, 曾启琴, 杨鲜艳, 等. 刚柔组合搅拌桨与刚性桨调控流场结构的对比[J]. 化工学报, 2014, 65(6):2078-2084. LIU Z H, ZENG Q Q, YANG X Y, et al. Flow field structure with rigid-flexible impeller and rigid impeller[J]. CIESC Journal, 2014, 65(6):2078-2084.
[14]	刘作华, 郑雄攀, 朱俊, 等. 一种刚柔组合的搅拌桨:103721606A[P]. 2014-04-16. LIU Z H, ZHENG X P, ZHU J, et al. A kind of rigid-flexible combination impeller:103721606A[P]. 2014-04-16.
[15]	刘作华, 曾启琴, 王运东, 等. 单层钢丝柔性桨强化高黏度流体混合的能效分析[J]. 化工学报, 2013, 64(10):3620-3625. LIU Z H, ZENG Q Q, WANG Y D, et al. Energy efficiency analysis for high-viscosity fluid mixing enhanced by flexible impeller[J]. CIESC Journal, 2013, 64(10):3620-3625.
[16]	刘作华, 曾启琴, 王运东, 等. 单层钢丝柔性桨强化搅拌槽中高黏度流体层流混合的研究[J]. 中国科技论文, 2012, 7(3):185-189. LIU Z H, ZENG Q Q, WANG Y D, et al. Laminar mixing enhanced by flexible impeller in high-viscosity fluid stirred tank[J]. China Science Paper, 2012, 7(3):185-189.
[17]	刘作华, 杨鲜艳, 谢昭明, 等. 单层钢丝柔性桨与自浮颗粒协同强化高黏度流体混沌混合[J]. 化工学报, 2013, 64(8):2794-2800. LIU Z H, YANG X Y, XIE Z M, et al. Chaotic mixing performance of high-viscosity fluid synergistically intensified by flexible impeller and floating particles[J]. CIESC Journal, 2013, 64(8):2794-2800.
[18]	刘作华, 孙瑞祥, 王运东, 等. 刚-柔组合搅拌桨强化流体混沌混合[J]. 化工学报, 2014, 65(9):3340-3349. LIU Z H, SUN R X, WANG Y D, et al. Chaotic mixing intensified by rigid-flexible coupling impeller[J]. CIESC Journal, 2014, 65(9):3340-3349.
[19]	LIU Z H, ZHENG X P, LIU D, et al. Enhancement of liquid-liquid mixing in a mixer-settler by a double rigid-flexible combination impeller[J]. Chemical Engineering and Processing:Process Intensification, 2014, 86:69-77.
[20]	刘作华, 许传林, 何木川, 等. 穿流式刚-柔组合搅拌桨强化混合澄清槽内油-水两相混沌混合[J]. 化工学报, 2017, 68(2):637-642. LIU Z H, XU C L, HE M C, et al. Oil-water biphase chaotic mixing enhanced by punched rigid-flexible combination impeller in mixer-settler[J]. CIESC Journal, 2017, 68(2):637-642.
[21]	杨锋苓, 张翠勋, 周慎杰. 一种自激振动型柔性叶片搅拌器:CN204768530U[P]. 2015-11-18. YANG F L, ZHANG C X, ZHOU S J. A kind of self-excited vibration of flexible blade agitator:CN204768530U[P]. 2015-11-18.
[22]	YOUNG Y L. Fluid-structure interaction analysis of flexible composite marine propellers[J]. Journal of Fluids and Structures, 2008, 24(6):799-818.
[23]	REZA A G, ABDULAZIZ A R, SHALIZA I, et al. Study of various curved-blade impeller geometries on power consumption in stirred vessel using response surface methodology[J]. Journal of the Taiwan Institute of Chemical Engineers, 2013, 44(2):192-201.
[24]	REZA A G, ABDULAZIZ A R, SHALIZA I. The effect of various designs of six-curved blade impellers on reaction rate analysis in liquid-liquid mixing vessel[J]. Measurement:Journal of the International Measurement Confederation, 2016, 91:440-450.
[25]	张雪雯. 搅拌器结构对搅拌槽内气液分散特性影响的数值模拟[D]. 北京:北京化工大学, 2010. ZHANG X W. Numerical simulation of the influence of agitator structure on the gas-liquid dispersion in a stirred tank[D]. Beijing:Beijing University of Chemical Technology, 2010.
[26]	NOMURA T, UCHIDA T, TAKAHASHI K. Enhancement of mixing by unsteady agitation of an impeller in an agitated vessel[J]. Journal of Chemical Engineering of Japan, 1997, 30(5):875-879.
[27]	赵洪亮, 张廷安, 张超, 等. 改进Intermig桨种分槽搅拌性能的数值模拟[J]. 过程工程学报, 2011, 11(1):15-19. ZHAO H L, ZHANG T A, ZHANG C, et al. Numerical simulation of mixing performance in seed precipitation tank with an improved Intermig impeller[J]. The Chinese Journal of Process Engineering, 2011, 11(1):15-19.
[28]	周勇军, 卢源, 陈明濠, 等. 改进型INTER-MIG搅拌槽内固液悬浮特性的数值模拟[J]. 过程工程学报, 2014, 14(5):744-750. ZHOU Y J, LU Y, CHEN M H, et al. Numerical simulation of solid-liquid suspension characteristics in a stirred tank with improved INTER-MIG impeller[J]. The Chinese Journal of Process Engineering, 2014, 14(5):744-750.
[29]	逄启寿, 徐金, 王海辉, 等. 搅拌桨结构参数对混合效率的影响[J]. 中国钨业, 2016, 31(4):73-77. FENG Q S, XU J, WANG H H, et al. Effects of structure parameters of stirring paddle on mixing efficiency[J]. China Tungsten Industry, 2016, 31(4):73-77.
[30]	江红祥. 高压水射流截割头破岩性能及动力学研究[D]. 徐州:中国矿业大学, 2015. JIANG H X. Study on rock fragmentation performance of high-pressure water-jets cutting head and its dynamics[D]. Xuzhou:China University of Mining and Technology, 2015.
[31]	马洪涛, 薛殿伦. 外部激励下行星换向机构的分岔及混沌[J]. 中国机械工程, 2013, 23:3129-3139. MA H T, XUE D L. Bifurcation and chaos of planetary reverse system to external excitation[J]. China Mechanical Engineering, 2013, 23:3129-3139.

单层钢丝柔性桨强化搅拌槽中流体混沌混合行为

Chaotic mixing performance enhanced by single-wire flexible impeller in stirred vessel

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 31

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘作华, 周毅林, 熊黠, 陶长元, 王运东. 逆流桨强化搅拌槽内流体混沌混合及流场结构失稳研究[J]. 化工学报, 2022, 73(1): 222-231.
[2]	刘作华,魏红军,熊黠,陶长元,王运东,程芳琴. 长短叶片复合型刚柔桨强化搅拌槽内流体混沌混合行为[J]. 化工学报, 2020, 71(11): 5080-5089.
[3]	刘作华,魏红军,熊黠,陶长元,王运东,程芳琴. 错位刚柔桨强化搅拌槽内流体混合实验及数值模拟[J]. 化工学报, 2020, 71(10): 4621-4631.
[4]	刘作华, 孙伟, 熊黠, 陶长元, 王运东, 程芳琴. 脉冲射流-刚柔组合桨强化流体混沌混合及传质性能研究[J]. 化工学报, 2020, 71(10): 4632-4641.
[5]	李兵, 杨义, 刘作华, 陶长元, 谷德银, 许传林, 王运东. 湿法磷酸固-液体系混沌混合与浸出强化行为[J]. 化工学报, 2019, 70(5): 1742-1749.
[6]	熊黠, 刘作华, 谷德银, 邱发成, 王靓, 陶长元, 王运东. 刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合[J]. 化工学报, 2019, 70(5): 1693-1701.
[7]	谷德银, 刘作华, 张姬一哲, 邱发成, 李军, 陶长元, 王运东. 搅拌槽内气液两相混沌混合及分散特性[J]. 化工学报, 2018, 69(2): 625-632.
[8]	邱发成, 刘作华, 刘仁龙, 全学军, 陈家兴, 谷德银, 李兵, 王运东. 偏心射流-刚柔组合桨搅拌器内混沌混合行为研究[J]. 化工学报, 2018, 69(2): 618-624.
[9]	唐巧, 叶思施, 王运东. 放大准则对混合澄清槽混合室中混合时间和流动特性的影响[J]. 化工学报, 2016, 67(2): 448-457.
[10]	佟莹, 朱向哲, 高鹤, 何延东. 三螺杆挤出机端面二维流场混沌混合拉格朗日拟序结构分析[J]. 化工学报, 2016, 67(10): 4378-4388.
[11]	刘仁龙, 李爽, 刘作华, 陶长元, 王运东. 穿流-柔性组合桨强化搅拌槽中流体混沌混合特性[J]. 化工学报, 2015, 66(12): 4736-4742.
[12]	刘作华, 陈超, 刘仁龙, 陶长元, 王运东. 刚柔组合搅拌桨强化搅拌槽中流体混沌混合[J]. 化工学报, 2014, 65(1): 61-70.
[13]	刘作华, 杨鲜艳, 谢昭明, 刘仁龙, 陶长元, 王运东. 柔性桨与自浮颗粒协同强化高黏度流体混沌混合[J]. 化工学报, 2013, 64(8): 2794-2800.
[14]	刘作华, 曾启琴, 王运东, 刘仁龙, 陶长元. 柔性桨强化高黏度流体混合的能效分析[J]. 化工学报, 2013, 64(10): 3620-3625.
[15]	孟辉波1，王艳芬2，禹言芳1，王伟1，王丰1，吴剑华1. 射流混合设备内混合时间的研究进展[J]. 化工进展, 2012, 31(12): 2615-2625.