补气增焓热泵机组在供热工况下的噪声特性

doi:10.11949/j.issn.0438-1157.20181188

化工学报 ›› 2018, Vol. 69 ›› Issue (S2): 109-115.DOI: 10.11949/j.issn.0438-1157.20181188

补气增焓热泵机组在供热工况下的噪声特性

邹臣堡¹, 冉小鹏¹, 翟晓强¹, 骆琼²

1 上海交通大学机械与动力工程学院, 上海 200240;
2 靖江市春意空调制冷设备有限公司, 江苏靖江 214522

收稿日期:2018-10-12 修回日期:2018-10-18 出版日期:2018-12-31 发布日期:2018-12-31
通讯作者: 翟晓强

Noise characteristics of enhanced vapor injection heat pump under heating condition

ZOU Chenbao¹, RAN Xiaopeng¹, ZHAI Xiaoqiang¹, LUO Qiong²

1 School of Mechanical Engineering, Shanghai Jiao Tong University, Shanghai 200240, China;
2 Jingjiang Chun Yi Air Conditioning Refrigeration Equipment Co., Ltd., Jingjiang 214522, Jiangsu, China

Received:2018-10-12 Revised:2018-10-18 Online:2018-12-31 Published:2018-12-31

摘要/Abstract

摘要：

以自行开发的一台补气增焓空气源热泵机组为实验对象，通过分步运行法对机组噪声源进行识别和频谱分析，研究变工况下机组供热性能及噪声变化规律，通过对噪声特性和变化规律原因的探究，为针对性地降低机组噪声提供了方向。结果表明：风机旋转噪声频率和压缩机激励频率接近时，噪声声压级会放大；风机在部分负荷工况下从高转速切换到低转速，噪声下降了6.44 dB；补气提高了补气压力和吸气压力，导致管路噪声增大，−12℃环境温度下噪声较补气阀关闭时增加了1.05 dB；主路阀开度100%时噪声声压级较开度30%时增加了2.1 dB，主路膨胀阀开度对噪声的影响大于补气膨胀阀。

Abstract:

Based on a self-developed enhanced vapor injection (EVI) air source heat pump, noise source was identified and spectrum analysis was analyzed by the fractional step operation method. The heating performance and noise variation law under variable conditions also were studied. It provides a targeted direction for reducing the noise of heat pump. The results show that the sound pressure level (SPL) of noise is enlarged when the rotating noise frequency of fan is close to the excitation frequency of compressor. When the fan switches from high speed to low speed under partial load, the SPL drops by 6.44 dB. The replenish pressure and inspiratory pressure are increased by EVI, and the SPL at -12℃ is increased by 1.05 dB compared with the gas filling valve closed. The SPL is increased by 2.1 dB when the opening of main valve is 100% compared with 30%. The influence of main valve opening on the noise is greater than that of gas filling valve.

中图分类号:

TB53

邹臣堡, 冉小鹏, 翟晓强, 骆琼. 补气增焓热泵机组在供热工况下的噪声特性[J]. 化工学报, 2018, 69(S2): 109-115.

ZOU Chenbao, RAN Xiaopeng, ZHAI Xiaoqiang, LUO Qiong. Noise characteristics of enhanced vapor injection heat pump under heating condition[J]. CIESC Journal, 2018, 69(S2): 109-115.

参考文献 14

[1]	张三明, 武茜.热泵降噪措施研究与实践[J].噪声与振动控制, 2005, 25(4):48-51.ZHANG S M, WU Q.Research and practice on noise control of heat pump[J].Noise and Vibration Control, 2005, 25(4):48-51.
[2]	马大猷.噪声与振动控制工程手册[M].北京:机械工业出版社, 2002:256.MA D Y.Noise and Vibration Control Engineering Manual[M].Beijing:China Machine Press, 2002:256.
[3]	ARDIYANSYAH S, WAN A, WAN M, et al.Optimized design of home refueling appliance with novel multi-stage symmetrical wobble-plate compressor[J].Technology and Innovation, 2008, 3:77-84.
[4]	LAXMAIAH G R, KUMAR M K.Experimental investigation of parameters effecting the noise reduction in hermitically sealed reciprocating compressor[J].International Journal of Engineering Science, 2011, 3(7):5946-5951.
[5]	RICHARD L, KANWAL B, WILLIAM R.Understanding automotive A/C compressor pressure pulsations generation through experimental and analytical methods[J].SAE Technical, 2013, 5:45-55.
[6]	韦开君, 左曙光, 吴旭东, 等.燃料电池车用离心压缩机窄带啸叫噪声实验测试与分析[J].振动与冲击, 2017, 36(7):14-20.WEI K J, ZUO S G, WU X D, et al.Measurement and analysis for whoosh noise of a centrifugal compressor in a fuel cell vehicle[J].Journal of Vibration and Shock, 2017, 36(7):14-20.
[7]	MAO H Y, WANG Y P.Influence of tip end-plate on noise of small axial fan[J].Journal of Thermal Science, 2017, 26(1):30-37.
[8]	ZHANG L, JIN Y Z, DOU H S.Numerical and experimental investigation on aerodynamic performance of small axial flow fan with hollow blade root[J].Journal of Thermal Science, 2013, 5 (5):424-432.
[9]	WANG J, HUANG L, CHENG L.A study of active tonal noise control for a small axial flow fan[J].Journal of the Acoustical Society of America, 2005, 117(2):734-743.
[10]	王正, 刘志峰, 白连社, 等.导流罩对冰箱冷凝风机噪声的影响[J].机械工程学报, 2014, 50(12):151-156.WANG Z, LIU Z F, BAI L S, et al. Effect of deflecting ring on noise generated by axial fan of condenser in refrigerator[J].Journal of Mechanical Engineering, 2014, 50(12):151-156.
[11]	唐俊, 王军, 隽智辉, 等.正弦锯齿尾缘对轴流风机尾迹及气动性能的影响[J].工程热物理学报, 2017, 38(10):2145-2150.TANG J, WANG J, JUAN Z H, et al. The influence of sinusoidal serrated trailing edge on the wake and aerodynamic performance of axial fan[J].Journal of Engineering Thermophysics, 2017, 38(10):2145-2150.
[12]	SREEJITH B, JAYARAJ K, GANESAN N, et al. Finite element analysis of fluid structure interaction in pipeline system[J].Nuclear Engineering & Design, 2004, 227(3):313-322.
[13]	LOH S K, FARIS W F, HAMDI M, et al.Vibrational characteristics of piping system in air conditioning outdoor unit[J].Science China Technological Sciences, 2011, 54(5):1154-1168.
[14]	戴青山, 朱石坚, 张振海.管路系统低噪声弹性支撑安装研究[J].舰船科学技术, 2017, 39(19):92-96.DAI Q S, ZHU S J, ZHANG Z H.Pipeline low noise elastic support installation method research[J].Ship Science and Technology, 2017, 39(19):92-96.

补气增焓热泵机组在供热工况下的噪声特性

Noise characteristics of enhanced vapor injection heat pump under heating condition

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 14

相关文章 0

编辑推荐

Metrics

本文评价