超超临界锅炉垂直水冷壁水动力特性

doi:10.3969/j.issn.0438-1157.2013.09.019

化工学报 ›› 2013, Vol. 64 ›› Issue (9): 3213-3219.DOI: 10.3969/j.issn.0438-1157.2013.09.019

超超临界锅炉垂直水冷壁水动力特性

王为术^1,2, 赵鹏飞¹, 陈刚¹, 毕勤成², 顾红芳²

1. 华北水利水电大学热能工程研究中心, 河南郑州 450011;
2. 西安交通大学动力工程多相流国家重点实验室, 陕西西安 710049

收稿日期:2013-01-31 修回日期:2013-05-19 出版日期:2013-09-05 发布日期:2013-09-05
通讯作者: 王为术(1972- ),男,教授
作者简介:王为术(1972- ),男,教授。
基金资助:
国家重点基础研究发展计划项目(2009CB219805)。

Hydrodynamic characteristics of vertical water-wall in ultra-supercritical pressure boiler

WANG Weishu^1,2, ZHAO Pengfei¹, CHEN Gang¹, BI Qincheng², GU Hongfang²

1. Thermal Engineering Research Center, North China University of Water Resources and Electric Power, Zhengzhou 450011, Henan, China;
2. National Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University, Xi'an 710049, Shaanxi, China

Received:2013-01-31 Revised:2013-05-19 Online:2013-09-05 Published:2013-09-05
Supported by:
supported by the National Basic Research Program of China(2009CB219805).

摘要/Abstract

摘要： 针对超超临界锅炉水冷壁系统水动力特性,建立了适用于复杂串并联回路系统的水动力特性计算模型,基于POWERSTATION4.0平台研制了水动力计算程序。按出口工质温度相等的原则计算节流补偿压降;以给定热负荷和节流方式进行流量分配和压降特性校核计算,用Chebyshev多项式拟合法拟合水动力特性曲线方程。并数值研究了1000 MW超超临界锅炉垂直水冷壁水动力特性,计算结果表明:U形叉管有利于垂直水冷壁节流调节,低负荷率下炉膛回路具有较强的正流量特性,而在超临界负荷具有弱的负流量特性。上炉膛回路在不同负荷率下均具有负流量特性。水冷壁水动力特性曲线呈单值性。研究结果为超超临界直流锅炉垂直水冷壁的工程设计及运行监测提供了可靠的理论依据。

关键词: 超超临界锅炉, 垂直水冷壁, 水动力特性

Abstract: In view of the hydrodynamic characteristics of water-wall in ultra-supercritical pressure boiler,a hydrodynamic model was established for complicated series-parallel circuit system.The hydrodynamic calculation procedure was developed based on the POWERSTATION4.0 platform.According to the principle of equal exit temperature of working fluid,the throttle orifice plate compensating pressure drop was numerically calculated.The verifying calculation for mass flow distribution and pressure drop characteristics was carried out at a given heat load and designed throttle orifice plate.The hydrodynamic characteristic curve was drawn by Chebyshev polynomial fitting method.The vertical water-wall hydrodynamic characteristics of 1000 MW ultra-supercritical pressure boilers were also investigated numerically.The results show that U-type bifurcate tubes are good for the throttle orifice adjustment of vertical water-wall.The lower furnace of boiler has strong positive flow characteristics at low load rate but weak negative flow characteristics in supercritical load.The upper furnace of boiler has negative flow characteristics at different load rates.The curve of water-wall hydrodynamic characteristics increases monotonically,which means that the pressure drop of water-wall only depends on the mass flow.These results provide reliable theoretical basis for engineering design and operational monitoring of ultra-supercritical pressure concurrent boiler vertical water-walls.

Key words: ultra-supercritical pressure boiler, vertical water-wall, hydrodynamic characteristics

中图分类号:

TK124

王为术, 赵鹏飞, 陈刚, 毕勤成, 顾红芳. 超超临界锅炉垂直水冷壁水动力特性[J]. 化工学报, 2013, 64(9): 3213-3219.

WANG Weishu, ZHAO Pengfei, CHEN Gang, BI Qincheng, GU Hongfang. Hydrodynamic characteristics of vertical water-wall in ultra-supercritical pressure boiler[J]. CIESC Journal, 2013, 64(9): 3213-3219.

参考文献 23

[1]	Dong Zukang(董祖康),Shen Qin(沈勤),Wang Menghao(王孟浩).JB/Z 201—83 Utility boiler hydrodynamic calculation method[S].Beijing:Machinery Industry Press of the State Council of the People's Republic of China,1983
[2]	Pioro I L,Duffey R B.Heat Transfer and Hydraulic Resistance at Supercritical Pressures in Power Engineering Applications[M].New York:ASME Press,2007
[3]	Wang Weishu(王为术).Heat Transfer and Hydro-dynamics Study of Water Wall with Internally-ribbed Tube in Supercritical(Ultra-supercritical)Boilers(超(超)临界锅炉内螺纹水冷壁管流动传热与水动力特性)[M].Beijing:China Electric Power Press,2012:137-147
[4]	Zhang Yanjun(张彦军),Yang Dong(杨冬),Yu Hui(于辉),Chen Tingkuan(陈听宽),Gao Xiang(高翔),Luo Zhongyang(骆仲泱).Research on the water wall design and hydrodynamic characteristics of a 600 MW supercritical pressure CFB boiler[J].Journal of Power Engineering(动力工程),2008,28(3):339-344
[5]	Wang Jianguo.Investigation on heat transfer and frictional pressure drop at low mass flux in the water-wall tubes of supercritical boiler[D].Xi'an:Xi'an Jiaotong University,2010
[6]	Swenson H S,Carver J R,Kakarala C R.Heat transfer to supercritical water in smooth-bore tubes[J].ASME J.Heat Transfer,1965,87(4):477-484
[7]	Ackerman J W.Pseudoboiling heat transfer to supercritical pressure water in smooth and ribbed tubes[J].J.Heat Transfer,Trans.ASME,1970,92(3):490-498
[8]	Igor L P,Hussam F K,Romney B D.Heat transfer to supercritical fluids flowing in channels—empirical correlations(survey)[J].Nuclear Engineering and Design,2004,230:69-91
[9]	Pan Jie(潘杰),Yang Dong(杨冬),Dong Zichun(董自春),Zhu Tan(朱探),Bi Qincheng(毕勤成).Experimental investigation on heat transfer characteristics of water in vertical upward tube under supercritical pressure[J].Nuclear Power Engineering(核动力工程),2011,32(1):75-80
[10]	Chisholm D.Pressure gradients due to friction during the flow of evaporating two-phase mixtures in smooth tubes and channels[J].International Journal of Heat and Mass Transfer,1973,16:347-348
[11]	Nishikawa K,Fujii T,Yoshida S.Investigation into burnout in grooved evaporator tubes[J].Journal of Japan Soc.Mech.Eng.,1972,75:700-707
[12]	Chen Tingkuan(陈听宽).Study of Two-phase Flow and Heat Transfer(两相流与传热研究)[M].Xi'an:Xi'an Jiaotong University Press,2004:63-141
[13]	Wang Weishu,Bi Qincheng,Gu Hongfang,Chen Tingkuan,Luo Yushan.An investigation on heat transfer to water flowing in vertical upward internally ribbed enhancement tube at supercritical pressure[J].Advanced Science Letters,2011,4:1-8
[14]	Wang Jianguo,Li Huixiong,Yu Shuiqing,Chen Tingkuan. Investigation on the characteristics and mechanisms of unusual heat transfer of supercritical pressure water in vertically-upward tubes[J].International Journal of Heat and Mass Transfer,2011,54(9/10):1950-1958
[15]	Pan Jie(潘杰),Yang Dong(杨冬),Dong Zichun(董自春),Zhu Tan(朱探),Bi Qincheng(毕勤成).Heat transfer characteristics of supercritical pressure water in vertical upward rifled tube[J].CIESC Journal(化工学报),2011,62(2):307-314
[16]	Zhu Xiaojing,Bi Qincheng,Yang Dong,Chen Tingkuan. An investigation on heat transfer characteristics of different pressure steam-water in vertical upward tube[J].Nuclear Engineering and Design,2009,239:381-388
[17]	Yuan Liangyi(袁良义),Li Changzheng(李长征),Wei Jiyong(魏继勇).Application of Excel in natural circulation hot water boiler hydrodynamic calculation[J].Jiangsu Boiler(江苏锅炉),2008(3):6-10
[18]	Dong Peng(董芃),Xu Yanying(徐艳英),Lan Rihua(兰日华).Loop analysis method for the numerical calculation of hydrodynamic characteristic of boiler with natural circulation[J].Journal of Harbin Institute of Technology(哈尔滨工业大学学报),2007(3):462-466
[19]	Xu Yanying(徐艳英),Dong Peng(董芃),Lan Rihua(兰日华).Principle of calculations for hydrodynamic-loop analysis method used for natural circulation hot water boilers[J].Journal of Engineering for Thermal Energy and Power(热能动力工程),2006(5):473-476
[20]	Xu Yanying(徐艳英),Dong Peng(董芃),Zhai Ming(翟明).Hydrodynamic loop analysis method for hot water boiler with natural circulation[J].Proceedings of the CSEE(中国电机工程学报),2010(5):66-70
[21]	Xie Jinfang(谢金芳).Research and application of general-purpose software for boiler hydrodynamic calculation based on the theory of pipe network calculation[D].Hangzhou:Zhejiang University,2011
[22]	Chen Tingkuan(陈听宽),Xu Jinliang(徐进良),Wu Lüchen(吴履琛),Wang Xiaowei(王晓为),Liu Baosen(刘宝森),Chen Chunda(陈春达).Study on waterwall hydrodynamics of supercritical vertical tube coils[J].Journal of Power Engineering(动力工程),1993,13(5):19-25
[23]	Wang Weishu(王为术).Heat transfer and hydro-dynamics study of waterwall with internally ribbed tube in ultra-supercritical pressure boilers[D].Xi'an:Xi'an Jiaotong University,2006

超超临界锅炉垂直水冷壁水动力特性

Hydrodynamic characteristics of vertical water-wall in ultra-supercritical pressure boiler

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 23

相关文章 1

编辑推荐

Metrics

本文评价