低温余热驱动的无泵有机朗肯循环瞬时稳态发电性能

doi:10.11949/j.issn.0438-1157.20170405

摘要/Abstract

摘要：

建立了一套低温热源驱动的小型无泵有机朗肯循环系统，研究无泵有机朗肯循环回收利用余热发电的性能。该系统中热水温度为75～95℃，冷却水温度为25℃，选择制冷剂R245fa作为系统工质，选择涡旋膨胀机将热能转换为机械能，并通过发电机进行发电。实验结果表明当热水进口温度为95℃时，最大瞬时发电功率为232 W，并可以在250 s的时间内保持稳定在230 W左右，总的发电持续时间为380 s。随着热源水温度下降，功率输出减小，但发电持续时间增加。系统稳定发电平均效率最大为3.92%，此时热源水温度为95℃，最低为3.02%，此时热源水温度为85℃。

关键词: 无泵有机朗肯循环, 焓值, 余热回收, 涡旋膨胀机, 发电效率

Abstract:

A small scale pumpless ORC (organic Rankine cycle) system which can recover waste heat from low temperature heat resource is established to investigate the performance of the cycle. The system is mainly composed of two high efficient heat exchangers, one scroll expander, one generator, four refrigerant valves and eight water valves. The flow direction of the water and refrigerant is controlled by the valves. The water heated by electric heating boiler is used to simulate the low temperature heat resource. The temperature of the hot water ranges from 75℃ to 95℃ and the temperature gradient is 5℃. The cooling water from the cooling tower is 25℃ accordingly. The refrigerant R245fa is selected as the working fluid. The results show that the largest power output is 232 W, and the stable power output is about 230 W when the inlet water temperature is 95℃. The total time of power generation last 380 s. One more thing is that the higher inlet water temperature, the less time of power generation process. For the average steady power generation, the maximum energy efficiency is 3.92% and the minimum energy efficiency is 3.02% when the inlet water temperature is 95℃ and 85℃, respectively.

Key words: pumpless ORC, enthalpy, waste heat recovery, scroll expander, electricity generation efficiency

中图分类号:

TK09

路会同, 江龙, 王丽伟, 王如竹. 低温余热驱动的无泵有机朗肯循环瞬时稳态发电性能[J]. 化工学报, 2017, 68(12): 4709-4716.

LU Huitong, JIANG Long, WANG Liwei, WANG Ruzhu. Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source[J]. CIESC Journal, 2017, 68(12): 4709-4716.

参考文献 30

[1]	YANG M H. Thermal and economic analyses of a compact waste heat recovering system for the marine diesel engine using transcritical Rankine cycle[J]. Energy Conversion and Management, 2015, 106:1082-2096.
[2]	DESIDERI A, GUSEV S, VAN DEN BROEK M, et al. Experimental comparison of organic fluids for low temperature ORC (organic Rankine cycle) systems for waste heat recovery applications[J]. Energy, 2016, 97:460-469.
[3]	WEI D H, LU X S, LU Z, et al. Performance analysis and optimization of organic Rankine cycle (ORC) for waste heat recovery[J]. Energy Conversion and Management, 2007, 48(4):1113-1119.
[4]	SCHUSTER A, KARELLAS S, KAKARAS E, et al. Energetic and economic investigation of organic Rankine cycle applications[J]. Applied Thermal Engineering, 2009, 29(8/9):1809-1817.
[5]	于浩水, 冯霄, 王彧斐. 有机朗肯循环工质筛选准则分析[J]. 计算机与应用化学, 2015, 32(11):1324-1328. YU H S, FENG X, WANG Y F. Working fluid selection criteria for organic Rankine cycle[J]. Computers and Applied Chemistry, 2015, 32(11):1324-1328.
[6]	杨凯, 张红光, 宋松松, 等. 变工况下车用柴油机排气余热有机朗肯循环回收系统[J]. 化工学报, 2015, 66(3):1097-1103. YANG K, ZHANG H G, SONG S S, et al. Waste heat organic Rankine cycle of vehicle diesel engine under variable working conditions[J]. CIESC Journal, 2015, 66(3):1097-1103.
[7]	刘强, 段远源, 宋鸿伟. 生物质直燃有机朗肯循环热电联产系统的热力性能分析[J]. 中国电机工程学报, 2013, 33(26):60-67+1. LIU Q, DUAN Y Y, SONG H W. Thermal performance analysis of a biomass-fired Organic rankine cycle[J]. Proceedings of the CSEE, 2013, 33(26):60-67+1.
[8]	郭丛, 杜小泽, 杨立军, 等. 地热源非共沸工质有机朗肯循环发电性能分析[J]. 中国电机工程学报, 2014, 34(32):5701-5708. GUO C, DU X Z, YANG L J, et al. Performance of organic Rankine cycle using zeotropic working fluids for geothermal utilization[J]. Proceedings of the CSEE, 2014, 34(32):5701-5708.
[9]	乔卫来, 陈九法, 薛琴, 等. 太阳能驱动有机朗肯循环的工质比较[J]. 能源研究与利用, 2010, (2):31-36. QIAO W L, CHEN J F, XUE Q, et al. The comparison of working fluid used in ORC system driven by solar energy[J] Energy Research and Utilization, 2010, (2):31-36.
[10]	阿云生, 马生元, 卢海涛, 等. 车用有机朗肯循环余热回收系统方案及工质选择[J]. 实验研究与探索, 2015, 34(10):18-23. A Y S, MA S Y, LU H T, et al. The selection of organic Rankine cycle system schemes and working fluids for automotive engine[J]. Research and Exploration in Laboratory, 2015, 34(10):18-23.
[11]	KIM D K, LEE J S, KIM J, et al. Parametric study and performance evaluation of an organic Rankine cycle (ORC) system using low-grade heat at temperatures below 80℃[J]. Applied Energy, 2017, 189:55-65
[12]	邓立生, 黄宏宇, 何兆红, 等. 机朗肯循环的研究进展[J]. 新能源进展, 2014, 2(3):180-189. DENG L S, HUANG H Y, HE Z H, et al. Research progress on organic Rankine cycle[J]. Advance in New and Renewable Energy, 2014, 2(3):180-189
[13]	许俊俊, 罗向龙, 王永真, 等. ORC工质选择的多级非结构性模糊决策分析[J]. 化工学报, 2015, 66(3):1051-1058. XU J J, LUO X L, WANG Y Z, et al. Optimum selection of ORC working fluid using multi-level fuzzy optimization and non-structural fuzzy decision[J]. CIESC Journal, 2015, 66(3):1051-1058.
[14]	付保荣, 林红良, 李志. 工质选择对有机朗肯循环热力学系统的影响[J]. 船电技术, 2012, 32(S1):14-17. FU B R, LIN H L, LI Z. Effect on selection of actuating mediums in organic Rankine cycle thermodynamics system[J]. Marine Electric & Electronic Engineering, 2012, 32(S1):14-17.
[15]	宋建忠, 张小松, 李舒宏, 等. 太阳能有机朗肯循环系统的实验特性[J]. 化工学报, 2014, 65(12):4958-4964. SONG J Z, ZHANG X S, LI S H, et al. Experimental characteristics of solar organic Rankine cycle system[J]. CIESC Journal, 2014, 65(12):4958-4964.
[16]	刘杰, 陈江平, 祁照岗. 低温有机朗肯循环的热力学分析[J]. 化工学报, 2010, 61(S2):9-14. LIU J, CHEN J P, QI Z G. Thermodynamic analysis of low temperature organic Rankine cycle[J]. CIESC Journal, 2010, 61(S2):9-14.
[17]	魏莉莉, 张于峰, 穆永超. 低温朗肯循环发电系统中的蒸发器设计研究[J]. 低温工程, 2015, (6):31-36. WEI L L, ZHANG Y F, MU Y C. Study of evaporator in low-temperature energy conversion system using organic Rankine cycle (ORC)[J]. Crogenics, 2015, (6):31-36.
[18]	QIU G Q, LIU H, RIFFAT S. Expanders for micro-CHP systems with organic Rankine cycle[J]. Applied Thermal Engineering, 2011, 31(16):3301-3307.
[19]	SONG P P, WEI M S, SHI L, et al. A review of scroll expander for organic Rankine cycle systems[J]. Applied Thermal Engineering, 2015, 75:54-64.
[20]	FIASCHI D, MANFRIDA G, MARASCHIELLO F. Design and performance prediction of a radial ORC turboexpanders[J]. Applied Energy, 2015, 138:517-532.
[21]	ZIVIANI D, GUSEV S, LECOMPTS S, et al. Optimizing the performance of small-scale organic Rankine cycle that utilizes a single-screw expander[J]. Applied Energy, 2017, 189:416-432.
[22]	高鹏, 江龙, 王丽伟, 等. 有机朗肯循环模拟及涡旋式膨胀机的性能研究[J]. 制冷学报, 2014, 35(1):53-57+118. GAO P, JIANG L, WANG L W, et al. The simulation of ORC and experimental study on scroll expander[J]. Journal of Refrigeration, 2014, 35(1):53-57+118.
[23]	叶佳琦, 赵力, 邓帅, 等. 小型有机朗肯循环系统中工质泵的效率[J]. 化工进展, 2016, 35(4):1027-1032. YE J Q, ZHAO L, DENG S, et al. Efficiency of working fluid pump in a small-scale organic Rankine cycle system[J]. Chemical Industry and Engineering Progress, 2016, 35(4):1027-1032.
[24]	张红光, 杨宇鑫, 孟凡骁, 等. 有机朗肯循环系统中工质泵的运行性能实验[J]. 化工学报, 2017, 68(9):3573-3579. ZHANG H G, YANG Y X, MENG F X, et al. Experiment on the running performance the working fluid pump for organic Rankine cycle system[J]. CIESC Journal, 2017, 68(9):3573-3579.
[25]	YAMADA N, WATANABE M, HOSHI A. Experiment on pumpless Rankine-type cycle with scroll expander[J]. Energy, 2013, 49:137-145.
[26]	YAMADA N, MINAMI T, MOHAMAD M N A. Fundamental experiment of pumpless Rankine-type cycle for low-temperature heat recovery[J]. Energy, 2011, 36(2):1010-1017.
[27]	LI J, PEI G, LI Y Z, et al. Analysis of a novel gravity driven organic Rankine cycle for small-scale cogeneration applications[J]. Applied Energy, 2013, 108:33-44.
[28]	李晶, 裴刚, 季杰. 利用重力增压的新型有机工质热力发电循环[J]. 工程热物理学报, 2012, 33(5):729-734. LI J, PEI G, JI J. A novel organic thermodynamic cycle on the use of gravity for pressurization[J]. Journal of Engineering Thermophysics, 2012, 33(5):729-734.
[29]	高鹏, 宋分平, 王丽伟. 一套新型冷电联供系统的性能研究[J]. 工程热物理学报, 2016, 37(1):16-20. GAO P, SONG F P, WANG L W. The performance research about the novel combined cooling and power system[J]. Journal of Engineering Thermophysics, 2016, 37(1):16-20
[30]	GAO P, WANG L W, WANG R Z. Experimental investigation on a small pumpless ORC (organic Rankine cycle) system driven by the low temperature heat source[J]. Energy, 2015, 91:324-333.