Measurement of vapor-liquid equilibrium data and azeotropic analysis for 2,4-toluene diisocyanate +entrainer

doi:10.11949/j.issn.0438-1157.20150433

Abstract

Abstract:

When conducting the removal process of free toluene diisocyanate(F-TDI)from polyurethane prepolymer by azeotropic distillation, the isobaric vapor-liquid equilibrium (VLE) data and basic thermodynamic parameters for 2,4-TDI + entrainer are missing. Isobaric VLE data for 2,4-TDI/ethyl benzoate(EBZ), 2,4-TDI/diethyl succinate (DES) and 2,4-TDI /dimethyl adipate (DMA) were measured at 0.55 kPa by using a self-made recirculation still. The binary VLE data have passed the thermodynamic consist test proposed by the area method. The parameters and regression deviations for the UNIQUAC equation were obtained by data regression with simulation system of Aspen Plus. The average deviations of vapor mole fraction were 0.0067, 0.0083 and 0.0179, and the average absolute deviations of the predicted temperature were 0.7 K, 1.2 K and 0.5 K for the three groups, respectively. Furthermore, azeotropic systems were analyzed, and the azeotropic compositions and azeotropic conditions were provided for the azeotropic distillation of F-TDI separation.

Key words: F-TDI, azeotropic distillation, vapor-liquid equilibrium

摘要：

在脱除游离甲苯二异氰酸酯(F-TDI)的共沸蒸馏研究中,缺少2,4-TDI与共沸剂的二元体系汽液平衡数据及基础热力学参数。采用自制的汽液平衡釜,测定了0.55 kPa压力下,2,4-TDI/苯甲酸乙酯、2,4-TDI/丁二酸二乙酯、2,4-TDI/己二酸二甲酯三组二元体系的汽液平衡数据,所得数据通过了热力学一致性面积检验。借助流程模拟软件Aspen Plus对实验数据进行了回归,得到3组UNIQUAC模型参数及关联偏差,气相摩尔分数平均偏差分别为0.0067、0.0083和0.0179,平衡温度平均绝对偏差分别为0.7 K、1.2 K和0.5 K。进而对共沸体系进行了共沸分析,得到了共沸组成和共沸条件,为F-TDI的共沸分离技术提供了工艺参数。

关键词: 游离TDI, 共沸精馏, 汽液平衡

CLC Number:

TQ013.1

XU Mian, WU Liangheng, ZHANG Jie. Measurement of vapor-liquid equilibrium data and azeotropic analysis for 2,4-toluene diisocyanate +entrainer[J]. CIESC Journal, 2016, 67(5): 1673-1679.

徐勉, 吴亮衡, 张杰. 2,4-TDI/共沸剂二元体系的汽液平衡数据的测定及共沸组成分析[J]. 化工学报, 2016, 67(5): 1673-1679.

References 19

[1]	刘镜愉. 甲苯二异氰酸酯的毒性及免疫学研究 [J]. 国外医学参考资料卫生学分册, 1979, 2: 91-93. LIU J Y. Toxicity and immunological studies of toluene diisocyanate [J]. Foreign Medical References Hygiene Volume, 1979, 2: 91-93.
[2]	赵杰, 贾纯荣, 朱坦.甲苯二异氰酸酯的毒性及室内相关标准 [J]. 环境与健康杂志, 2006, 23(1): 90-92. ZHAO J, JIA C R, ZHU T. Toxicity and indoor air limit of toluene diisocyanate [J]. Environ. Health, 2006, 23(1): 90-92.
[3]	Air Products and Chemicals, Inc. Preparation of urethane prepolymers having low levels of residual toluene diisocyanate: US5051152[P]. 1991-09-24.
[4]	Robin J, Blind A. Purification of isocyanate condensates by extraction with liquid or supercritical gas: US4871460[P].1989-10-03.
[5]	Farbendfabriken Bayer AG. Glycol modified isocyanurate containing polyisocyanates: US3248372[P]. 1966-04-26.
[6]	W R Grace & Co. Removal of unreacted toluene diisocyanate from urethane prepolymers: US4061662[P]. 1977-12-06
[7]	Olin Corporation Research Center. Removal of unreacted diisocyanate from polyurethane prepolymers: US4385171 [P]. 1983-05-24.
[8]	李德良, 易碧红, 张冰剑. 碳酸丙烯酯与1,2-丙二醇二元体系UNIQUAC模型参数的估算与实验修正 [J]. 高校化学工程学报, 2014, 28(2): 207-211. LI D L, YI B H, ZHANG B J. Estimation and experimental modification of UNIQUAC model parameters for the PC and PG binary system [J]. J. Chem. Eng. Chinese Univ., 2014, 28(2): 207-211.
[9]	朱连天, 阎建民, 肖文德. 乙二醇-1, 2-丁二醇二元体系汽液平衡数据的测定及关联 [J]. 化学工程, 2012, 40(7): 34-37. ZHU L T, YAN J M, XIAO W D. Determination and correlation of VLE data for ethylene glycol and 1, 2-butanediol system [J]. Chemical Engineering(China), 2012, 40(7): 34-37.
[10]	刘益军. 聚氨酯原料及助剂手册[M]. 北京: 化学工业出版社, 2012. LIU Y J. Hand Book of Raw Materials and Additives for Rolyurethanes[M].Beijing: Chemical Industry Press, 2012.
[11]	王清廉. 有机化学实验[M].北京: 高等教育出版社, 2010. WHANG Q L. Organic Chemistry Experiment[M]. Beijing: Higher Education Press, 2010.
[12]	程能林. 溶剂手册[M]. 北京: 化学工业出版社, 2007. CHEN N L. Handbook of Solvents[M]. Beijing: Chemical Industry Press, 2007
[13]	MENE P S. Binary system, ethanol ethylene glycol [J]. Indian Chem. Eng., 1978, 20: 37-41
[14]	DAUBERT T E, HUTCHISON G. Vapour pressure of 18 pure industrial chemicals [J]. AIChE Symp. Ser., 1990, 86(279): 93-114.
[15]	STEELE W V, CHIRICO R D, HOSSENLOPP I A, et al. DIPPR Data Series[M].New Jersey: Wiley, 1994: 188-215.
[16]	GUGGENHEIM E A. Mixture[M]. London: Oxford Univ. Press, 1952: 23-87.
[17]	麦志远.甲苯二异氰酸酯三聚体固化剂的制备和性能研究[D].广州: 华南理工大学, 2013. MAI Z Y. Synthesis and properties of toluene diisocyanate trimer curing agent[D].Guangzhou: South China University of Technology, 2013.
[18]	张泉福. 高效液相色谱和凝胶渗透色谱在聚氨酯工业中的应用 [J]. 聚氨酯工业, 1989, (4): 44-48. ZHANG Q F. The application of HPLC and GPC in the polyurethane industry [J]. Polyurethane Industry, 1989, (4): 44-48.
[19]	陈钟秀, 顾飞燕, 胡望明. 化工热力学[M]. 北京: 化学工业出版社, 2000. CHEN Z X, GU F Y, HU W M. Chemical Engineering Thermodynamics[M].Beijing: Chemical Industry Press, 2000.