容积负荷变化模式对嗜盐混合菌发酵乙酸合成PHB的影响

doi:10.11949/j.issn.0438-1157.20150287

化工学报 ›› 2015, Vol. 66 ›› Issue (10): 4177-4184.DOI: 10.11949/j.issn.0438-1157.20150287

容积负荷变化模式对嗜盐混合菌发酵乙酸合成PHB的影响

崔有为, 张宏宇, 冀思远, 施云鹏

北京工业大学环境与能源工程学院, 北京 100124

收稿日期:2015-03-10 修回日期:2015-05-25 出版日期:2015-10-05 发布日期:2015-10-05
通讯作者: 崔有为
基金资助:
国家自然科学基金项目(51478011,51178004);北京市自然科学基金项目(8132013);北京市属高等学校高层次人才引进与培养计划项目。

Influence of organic loading rate change modes on PHB production by halophilic sludge fermenting acetate acid

CUI Youwei, ZHANG Hongyu, JI Siyuan, SHI Yunpeng

College of Environmental and Energy Engineering, Beijing University of Technology, Beijing 100124, China

Received:2015-03-10 Revised:2015-05-25 Online:2015-10-05 Published:2015-10-05
Supported by:
supported by the National Natural Science Foundation of China (51478011, 51178004),Natural Science Foundation of Beijing (8132013) and the Importation and Development of High-Caliber Talents Project of Beijing Municipal Institutions.

摘要/Abstract

摘要：

以嗜盐混合菌发酵生产PHB具有免灭菌程序、易提取、产量高等优势而被广泛关注。本研究集中考察了嗜盐混合菌(MMCs)发酵生产PHB过程中调整容积负荷的方式对PHB生产的影响。在研究中通过比较恒定接种生物量改变底物浓度以及恒定底物浓度调整接种生物量两种调整方式下PHB发酵生产的最大细胞含量、PHB最大容积产率以及表观动力学,确定了MMCs的最佳OLR,以及两种变化方式的本质差异。研究结果表明,两种方式下随着OLR升高,细胞内最大PHB的积累量和PHB容积产率也随着增加。本研究发展的嗜盐MMCs最佳OLR 0.91 kg·(kg·d)^-1。在相同的OLR下,高的接种生物量始终具有高的碳源转化率和底物消耗速率。为此,采用高接种生物量发酵生产PHB可以提高PHB生产效率并降低PHB的成本。

关键词: 聚羟基丁酸酯(PHB), 有机容积负荷(OLR), 污泥浓度, 底物浓度, 嗜盐混合菌

Abstract:

Polyhydroxybutyrate (PHB) production by halophilic mixed consortia draws a lot of attention because of its great advantages, such as no sterilization, extraction convenience and high production. In this study, halophilic mixed microbial cultures were used to investigate the influence of adjusting modes of the organic loading rate on PHB production. Two adjusting modes were applied including adjusting sludge concentration with a consistent substrate concentration and substrate concentration with a consistent sludge concentration. The maximum PHB content in cells, maximum PHB volumetric yield and kinetics were compared to confirm the optimum OLR and the key difference in the two modes. The experimental results showed that the high OLR led to a high PHB content in cells and a high PHB volumetric yield. In this study, 0.91 kg ·(kg ·d)^-1 was proved to be the optimum OLR for halophilic MMCs. On condition of identical OLR, the high sludge concentration led to high carbon source conversion ratio and substrate consumption rate. Then, a high sludge concentration can enhance PHB productivity and depress PHB production cost.

Key words: polyhydroxybutyrate (PHB), organic loading rate (OLR), sludge concentration, influence substrate concentration, halophilic mixed microbial cultures

中图分类号:

X703

崔有为, 张宏宇, 冀思远, 施云鹏. 容积负荷变化模式对嗜盐混合菌发酵乙酸合成PHB的影响[J]. 化工学报, 2015, 66(10): 4177-4184.

CUI Youwei, ZHANG Hongyu, JI Siyuan, SHI Yunpeng. Influence of organic loading rate change modes on PHB production by halophilic sludge fermenting acetate acid[J]. CIESC Journal, 2015, 66(10): 4177-4184.

参考文献 26

[1]	Braunegg G, Lefebvre G, Genser K F. Polyhydroxyalkanoates, biopolyesters from renewable resources: physiological and engineering aspects [J]. Journal of Biotechnology, 1998, 65 (2/3): 127-161.
[2]	Zhu C J, Chiu S, Nakas J P, Nomura C T. Bioplastics from waste glycerol derived from biodiesel industry [J]. Journal of Applied Polymer Science, 2013, 130 (1): 1-13.
[3]	Numata K, Abe H, Iwata T. Biodegradability of poly(hydroxyalkanoate) materials [J]. Materials, 2009, 2 (3): 1104-1126.
[4]	Snell K D, Peoples O P. PHA bioplastic: a value-added coproduct for biomass biorefineries [J]. Biofuels Bioproducts & Biorefining-Biofpr, 2009, 3 (4): 456-467.
[5]	Suriyamongkol P, Weselake R, Narine S, Moloney M, Shah S. Biotechnological approaches for the production of polyhydroxyalkanoates in microorganisms and plants—a review [J]. Biotechnology Advances, 2007, 25 (2): 148-175.
[6]	Campanari S, eSilva A, Bertin L, Villano M, Majone M. Effect of the organic loading rate on the production of polyhydroxyalkanoates in a multi-stage process aimed at the valorization of olive oil mill wastewater [J]. International Journal of Biological Macromolecules, 2014, 71: 34-41.
[7]	Venkateswar R M, Venkata M S. Effect of substrate load and nutrients concentration on the polyhydroxyalkanoates (PHA) production using mixed consortia through wastewater treatment [J]. Bioresource Technology, 2012, 114: 573-582.
[8]	Sakai K, Miyake S, Iwama K, Inoue D, Soda S, Ike M. Polyhydroxyalkanoate (PHA) accumulation potential and PHA-accumulating microbial communities in various activated sludge processes of municipal wastewater treatment plants [J]. Journal of Applied Microbiology, 2015, 118 (1): 255-266.
[9]	Johnson K, Jiang Y, Kleerebezem R, Muyzer G, van Loosdrecht M C. Enrichment of a mixed bacterial culture with a high polyhydroxyalkanoate storage capacity [J]. Biomacromolecules, 2009, 10 (4): 670-676.
[10]	Chen Zhiqiang, Guo Zirui, Wen Qinxue, Huang Long, Bakke R, Du Maoan. A new method for polyhydroxyalkanoate (PHA) accumulating bacteria selection under physical selective pressure [J]. International Journal of Biological Macromolecules, 2015, 72: 1329-1334.
[11]	Kumar P, Mehariya S, Ray S, Mishra A, Kalia V C. Biodiesel industry waste: a potential source of bioenergy and biopolymers [J]. Indian Journal of Microbiology, 2015, 55 (1): 1-7.
[12]	Dai Jing, Gliniewicz K, Settles M L, Coats E R, McDonald A G. Influence of organic loading rate and solid retention time on polyhydroxybutyrate production from hybrid poplar hydrolysates using mixed microbial cultures [J]. Bioresource Technology, 2015, 175: 23-33.
[13]	Quillaguamán J, Guzmán H, Van-Thuoc D, Hatti-Kaul R. Synthesis and production of polyhydroxyalkanoates by halophiles: current potential and future prospects [J]. Applied Microbiology and Biotechnology, 2010, 85 (6): 1687-1696.
[14]	Pramanik A, Mitra A, Arumugam M, Bhattacharyya A, Sadhukhan S, Ray A, Haldar S, Mukhopadhyay U K, Mukherjee J. Utilization of vinasse for the production of polyhydroxybutyrate by Haloarcula marismortui [J]. Folia Microbiologica, 2012, 57 (1): 71-79.
[15]	Wong Y M, Brigham C J, Rha C, Sinskey A J, Sudesh K. Biosynthesis and characterization of polyhydroxyalkanoate containing high 3-hydroxyhexanoate monomer fraction from crude palm kernel oil by recombinant Cupriavidus necator [J]. Bioresource Technology, 2012, 121: 320-327.
[16]	Kulkarni S O, Kanekar P P, Jog J P, Patil P A, Nilegaonkar S S, Sarnaik S S, Kshirsagar P R. Characterisation of copolymer, poly (hydroxybutyrate-co-hydroxyvalerate) (PHB-co-PHV) produced by Halomonas campisalis (MCM B-1027), its biodegradability and potential application [J]. Bioresource Technology, 2011, 102 (11): 6625-6628.
[17]	Cui Y W, Ding J R, Ji S Y, Peng Y Z. Start-up of halophilic nitrogen removal via nitrite from hypersaline wastewater by estuarine sediments in sequencing batch reactor [J]. International Journal of Environmental Science and Technology, 2014, 11 (2): 281-292.
[18]	Fang Fang (方芳), Bao Xiaojing (鲍晓静), Jiang Hui (江慧), Cao Jiashun (操家顺). Influence of F/M on intracellular storage,and nitrogen and phosphorus removal in activated sludge [J]. Journal of Hohai University: Natural Sciences (河海大学学报:自然科学版), 2013, (2): 125-129.
[19]	Cui Youwei (崔有为), Ding Jieran (丁洁然), Lu Pengfei (卢鹏飞), Peng Yongzhen (彭永臻). Performance and influencing factors of halophilic activated sludge in denitrifying of nitrite [J]. CIESC Journal (化工学报), 2012, 63 (8): 2584-2591.
[20]	Johnson K, van Geest J, Kleerebezem R, van Loosdrecht M C M. Short-and long-term temperature effects on aerobic polyhydroxybutyrate producing mixed cultures [J]. Water Research, 2010, 44 (6): 1689-1700.
[21]	APHB. Standard methods for the examination of water and wastewater [S]. 1995.
[22]	Oehmen A, Keller-Lehmann B, Zeng R J, Yuan Z G, Keller E. Optimisation of poly-beta-hydroxyalkanoate analysis using gas chromatography for enhanced biological phosphorus removal systems [J]. Journal of Chromatography A, 2005, 1070 (1/2): 131-136.
[23]	Salehizadeh H, van Loosdrecht M C M. Production of polyhydroxyalkanoates by mixed culture: recent trends and biotechnological importance [J]. Biotechnology Advances, 2004, 22 (3): 261-279.
[24]	Johnson K, Kleerebezem R, van Loosdrecht M C M. Influence of ammonium on the accumulation of polyhydroxybutyrate (PHB) in aerobic open mixed cultures [J]. Journal of Biotechnology, 2010, 147 (2): 73-79.
[25]	Ciggin A S, Rossetti S, Majone M, Orhon D. Extent of intracellular storage in single and dual substrate systems under pulse feeding [J]. Environmental Science and Pollution Research, 2013, 20 (3): 1225-1238.
[26]	Dias J M L, Oehmen A, Serafim L S, Lemos P C, Reis M A M, Oliveira R. Metabolic modelling of polyhydroxyalkanoate copolymers production by mixed microbial cultures [J]. BMC Systems Biology, 2008, 2: 59.(化工学报), 2012(8): 2584-2591.
[20]	Johnson K, van Geest J, Kleerebezem R, van Loosdrecht MCM. Short- and long-term temperature effects on aerobic polyhydroxybutyrate producing mixed cultures[J]. Water Research, 2010, 44(6): 1689-1700.
[21]	APHB, Standard methods for the examination of water and wastewater[S]. 1995.
[22]	Oehmen A, Keller-Lehmann B, Zeng R J, Yuan Z G, Keller E. Optimisation of poly-beta-hydroxyalkanoate analysis using gas chromatography for enhanced biological phosphorus removal systems[J]. Journal of Chromatography A, 2005, 1070(1-2): 131-136.
[23]	Ciggin A S, Rossetti S, Majone M, Orhon D. Extent of intracellular storage in single and dual substrate systems under pulse feeding[J]. Environmental Science and Pollution Research, 2013, 20(3): 1225-1238.
[24]	Dias Joâo ML, Oehmen Adrian, Serafim Luísa S, Lemos Paulo C, Reis Maria AM, Oliveira Rui. Metabolic modelling of polyhydroxyalkanoate copolymers production by mixed microbial cultures[J]. BMC Systems Biology, 2008, 2(1): 59-62.
[25]	Salehizadeh H, Van Loosdrecht M. Production of polyhydroxyalkanoates by mixed culture: recent trends and biotechnological importance[J]. Biotechnology Advances. 2004, 22(3): 261-279.
[26]	Johnson K, Kleerebezem R, van Loosdrecht M C M. Influence of ammonium on the accumulation of polyhydroxybutyrate (PHB) in aerobic open mixed cultures[J]. Journal of Biotechnology. 2010, 147(2): 73-79.

容积负荷变化模式对嗜盐混合菌发酵乙酸合成PHB的影响

Influence of organic loading rate change modes on PHB production by halophilic sludge fermenting acetate acid

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 4

编辑推荐

Metrics

本文评价

[1]	崔有为, 张宏宇. pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响[J]. 化工学报, 2016, 67(10): 4431-4438.
[2]	姜楠1，谢楠1，齐崴1，2，3，苏荣欣1，2，3，何志敏1，2，3. 硫酸催化葡萄糖制备乙酰丙酸的过程强化[J]. 化工进展, 2014, 33(11): 2888-2893.
[3]	张兰河1，2，王璐瑶1，张万友1，王旭明3. 进水负荷与硝化液回流比对低污泥浓度A2/O工艺脱氮效果的影响[J]. 化工进展, 2012, 31(03): 693-698.
[4]	崔有为1，丁洁然1，李晶2，苏贺1，陈叶菲1. 野生型嗜盐混合菌群处理高盐生活污水的硝化性能[J]. CIESC Journal, 2011, 62(12): 3511-3517.