pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响

doi:10.11949/j.issn.0438-1157.20160085

化工学报 ›› 2016, Vol. 67 ›› Issue (10): 4431-4438.DOI: 10.11949/j.issn.0438-1157.20160085

pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响

崔有为, 张宏宇

北京工业大学环境与能源工程学院, 北京 100124

收稿日期:2016-01-19 修回日期:2016-07-28 出版日期:2016-10-05 发布日期:2016-10-05
通讯作者: 崔有为
基金资助:
国家自然科学基金项目(51478011，51178004)；北京市自然科学基金项目(8132013)；北京市属高等学校高层次人才引进与培养计划项目。

Influence of pH on PHA production by halophilic sludge fermenting mixed VFAs substrate

CUI Youwei, ZHANG Hongyu

College of Environmental and Energy Engineering, Beijing University of Technology, Beijing 100124, China

Received:2016-01-19 Revised:2016-07-28 Online:2016-10-05 Published:2016-10-05
Supported by:
supported by the National Natural Science Foundation of China (51478011, 51178004), the Natural Science Foundation of Beijing (8132013) and the Importation and Development of High-Caliber Talents Project of Beijing Municipal Institutions.

摘要/Abstract

摘要：

嗜盐混合菌发酵生产聚羟基脂肪酸酯（polyhydroxyalkanoate，PHA）具有免灭菌程序、产量高、易提取等优势而被广泛关注。集中考察了pH对嗜盐混合菌（MMCs）发酵混合挥发性有机酸（VFA）生产PHA的影响。研究结果表明，在6.5～8.2范围内pH对PHA合成没有明显影响，过高或者过低的pH都会降低PHA合成速率和VFA的吸收速率。发酵体系的pH影响了嗜盐MMC的PHA产量，但是在酸性和碱性条件下却存在不同的影响机制。碱性环境增大了VFA的解离程度，导致MMC对底物的吸收耗费大量的能量，造成VFA吸收速率的下降。这一作用在pH升高至9.2以上时表现显著。酸性环境下，分子态VFA进入细胞后改变了胞内的pH，降低了相关酶和蛋白质的活性，从而影响了底物的利用。当pH=5.2时微生物代谢及底物利用能耗量降低，导致PHA胞内降解利用率降低，刺激了PHA合成量的提高。PHA组分受pH影响不大，初始pH=5.2～10.2时羟基脂肪酸戊酯（hydroxyvalerate，HV）所占比例维持在34.9%～38.3%范围内。本研究对于进一步利用嗜盐MMC发酵含有混合VFA的废弃物生产PHA具有重要的指导意义。

关键词: 聚羟基脂肪酸酯, pH, 挥发性脂肪酸, 嗜盐混合菌

Abstract:

Polyhydroxyalkanoates (PHA) production by halophilic mixed microbial cultures (MMCs) draw a lot of attention because of great advantages, such as free sterilization, easily extraction and high production. In this study, halophilic MMC was used to investigate the effect of pH on PHA production in the mixed VFAs fermentation process. The results indicated that there was no significant influence on PHA production in the pH range of 6.5-8.2. PHA production rate and substrate utilization rate would be inhibited in lower or higher pH conditions. PHA yield was influenced by pH in the systems, but different influencing mechanism existed in acidic condition and alkaline condition. Alkaline environment led to higher dissociation degree of VFAs. Then more energy needed as substrates being absorbed, which further led to the decrease of VFAs absorption rate. This affect was obvious when pH raised to 9.2. Molecular-state VFAs changed intracellular pH in the acidic condition. Then, the lower activity of related enzymes and protein resulted in slower substrate utilization. Energy consumption of substrate utilization and microbial metabolism reduced when pH=5.2, resulting in the decrease of intracellular PHA degradation and the increase of PHA yield. The pH value had little influence on PHA component. And HV accounted for 34.9%-38.3% of PHA weight when the initial pH between 5.2 and 10.2. This study would be a guide for PHA production using mixed VFAs as carbon source by halophilic MMCs.

Key words: polyhydroxyalkanoate, pH, volatile fatty acid, halophilic mixed microbial cultures

中图分类号:

X703

崔有为, 张宏宇. pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响[J]. 化工学报, 2016, 67(10): 4431-4438.

CUI Youwei, ZHANG Hongyu. Influence of pH on PHA production by halophilic sludge fermenting mixed VFAs substrate[J]. CIESC Journal, 2016, 67(10): 4431-4438.

参考文献 21

[1]	BRAUNEGG G, LEFEBVRE G, GENSER K F. Polyhydroxyalkanoates, biopolyesters from renewable resources:physiological and engineering aspects[J]. Journal of Biotechnology, 1998, 65(2/3):127-161.
[2]	ZHU C, CHIU S, NAKAS J P, et al. Bioplastics from waste glycerol derived from biodiesel industry[J]. Journal of Applied Polymer Science, 2013, 130(1):1-13.
[3]	NUMATA K, ABE H, IWATA T. Biodegradability of poly(hydroxyalkanoate) materials[J]. Materials, 2009, 2(3):1104-1126.
[4]	CAMPANARI S, SILVA F A, BERTIN L, et al. Effect of the organic loading rate on the production of polyhydroxyalkanoates in a multi-stage process aimed at the valorization of olive oil mill wastewater[J]. International Journal of Biological Macromolecules, 2014, 71:34-41.
[5]	SAKAI K, MIYAKE S, IWAMA K, et al. Polyhydroxyalkanoate (PHA) accumulation potential and PHA-accumulating microbial communities in various activated sludge processes of municipal wastewater treatment plants[J]. Journal of Applied Microbiology, 2015, 118(1):255-266.
[6]	BECCARI M, DIONISI D, GIULIANI A, et al. Effect of different carbon sources on aerobic storage by activated sludge[J]. Water Science and Technology, 2002, 45(6):157-168.
[7]	MORALEJO-GARATE H, KLEEREBEZEM R, MOSQUERA-CORRAL A, et al. Impact of oxygen limitation on glycerol-based biopolymer production by bacterial enrichments[J]. Water Research, 2013, 47(3):1209-1217.
[8]	JOHNSON K, VAN GEEST J, KLEEREBEZEM R, et al. Short-and long-term temperature effects on aerobic polyhydroxybutyrate producing mixed cultures[J]. Water Research, 2010, 44(6):1689-1700.
[9]	WANG Y, GENG J, REN Z, et al. Effect of COD/N and COD/P ratios on the PHA transformation and dynamics of microbial community structure in a denitrifying phosphorus removal process[J]. Journal of Chemical Technology and Biotechnology, 2013, 88(7):1228-1236.
[10]	崔有为, 张宏宇, 冀思远, 等. 容积负荷变化模式对嗜盐混合菌发酵乙酸合成PHB的影响[J]. 化工学报, 2015, 66(10):4177-4184. CUI Y W, ZHANG H Y, JI S Y, et al. Influence of organic loading rate change modes on PHB production by halophilic sludge fermenting acetate acid[J]. CIESC Journal, 2015, 66(10):4177-4184.
[11]	崔有为, 冀思远, 卢鹏飞, 等. F/F对嗜盐污泥以乙酸钠为底物生产PHB能力的影响[J]. 化工学报, 2015, 66(4):1491-1497. CUI Y W, JI S Y, LU P F, et al. Influence of F/F on PHB production by halophilic activated sludge fed by sodium acetate[J]. CIESC Jorunal, 2015, 66(4):1491-1497.
[12]	周群英, 王士芬. 环境工程微生物学[M]. 3版. 北京:高等教育出版社, 2008:455. ZHOU Q Y, WANG S F. Microbiology of Environmental Engineering[M]. 3rd ed. Beijing:Higher Education Press, 2008:455.
[13]	CUI Y W, DING J R, JI S Y, et al. Start-up of halophilic nitrogen removal via nitrite from hypersaline wastewater by estuarine sediments in sequencing batch reactor[J]. International Journal of Environmental Science and Technology, 2014, 11(2):281-292.
[14]	崔有为, 丁洁然, 卢鹏飞, 等. 嗜盐污泥反硝化亚硝酸盐的性能及其影响因素[J]. 化工学报, 2012, 63(8):2584-2591. CUI Y W, DING J R, LU P F, et al. Performance and influencing factors of halophilic activated sludge in denitrifying of nitrite[J]. CIESC Journal, 2012, 63(8):2584-2591.
[15]	JOHNSON K, JIANG Y, KLEEREBEZEM R, et al. Enrichment of a mixed bacterial culture with a high polyhydroxyalkanoate storage capacity[J]. Biomacromolecules, 2009, 10(4):670-676.
[16]	JOHNSON K, KLEEREBEZEM R, VAN LOOSDRECHT M C. Influence of ammonium on the accumulation of polyhydroxybutyrate (PHB) in aerobic open mixed cultures[J]. Journal of Biotechnology, 2010, 147(2):73-79.
[17]	American Public Health Association, American Water Works Association, Water Environment Federation. Standard methods for the examination of water and wastewater[S].USA:American Public Health Association, 1995.
[18]	VILLANO M, BECCARI M, DIONISI D, et al. Effect of pH on the production of bacterial polyhydroxyalkanoates by mixed cultures enriched under periodic feeding[J]. Process Biochemistry, 2010, 45(5):714-723.
[19]	张运海. 利用混合菌群合成聚羟基烷酸酯工艺条件优化[D]. 哈尔滨:哈尔滨工业大学, 2010. ZHANG Y H. Process optimiza for polyhydroxyalkanoates production using mixed bacterial cultures[D]. Harbin:Harbin Institute of Technology, 2010.
[20]	FILIPE C D M. Development of a revised metabolic model for the growth of phosphorus-accumulating organisms[J]. Water Environment Research, 1998, 70(1):67-79.
[21]	KASHKET E R. Proton motive force in growing Streptococcus lactis and Staphylococcus aureuscells under aerobic and anaerobic conditions[J]. Journal Baecteriol., 1981, 146(1):377-389.

相关文章 15

[1]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[2]	许万, 陈振斌, 张慧娟, 牛昉昉, 火婷, 刘兴盛. 线性温敏性聚合物嵌段调控的 $R e O 4 -$ 智能离子印迹聚合物的设计制备及其吸附分离性能研究[J]. 化工学报, 2023, 74(2): 941-952.
[3]	安绍杰, 许洪峰, 李思, 许远航, 李佳锡. 利用分子机器的组装与分解构建pH敏感性谷胱甘肽过氧化物人工酶[J]. 化工学报, 2022, 73(8): 3669-3678.
[4]	李婧怡, 匡卓贤. 对项目整个生命周期PHSER方法的探究与借鉴[J]. 化工学报, 2021, 72(3): 1634-1642.
[5]	徐宇峰, 郭鸣, 王让, 肖伟, 刘元慧, 李思敏. 复合改性生物砂滤池对突发PhACs痕量污染的去除效果分析[J]. 化工学报, 2020, 71(7): 3322-3332.
[6]	赵学辉, 李晓乐, 刘洋, 胡岩, 许青, 张宏伟. KMnO₄溶液pH调控对PVDF膜物化性能和污染行为影响[J]. 化工学报, 2020, 71(5): 2401-2412.
[7]	王永良, 杨晓玲, 董永霞, 杜英超, 刘翔, 韩培伟, 叶树峰. pH调整剂对含砷酸性废水中氧化Fe（Ⅱ）共沉淀固砷行为的影响[J]. 化工学报, 2019, 70(9): 3511-3516.
[8]	巩有奎, 彭永臻. 运行方式对SBBR亚硝酸型同步脱氮及N₂O释放的影响[J]. 化工学报, 2019, 70(6): 2289-2297.
[9]	巩有奎, 任丽芳, 彭永臻. 不同DO下SBBR亚硝酸型同步脱氮及N₂O释放特性[J]. 化工学报, 2019, 70(4): 1550-1558.
[10]	王志甄, 邹志云. 基于神经网络的pH中和过程非线性预测控制[J]. 化工学报, 2019, 70(2): 678-686.
[11]	牟鹏, 顾祥柏, 朱群雄. 基于P-graph的乙烯裂解原料调度建模与优化[J]. 化工学报, 2019, 70(2): 556-563.
[12]	巩有奎, 彭永臻. 曝气强度对SBBR同步生物脱氮及N₂O释放影响[J]. 化工学报, 2019, 70(11): 4410-4419.
[13]	赵小燕, 单国荣. RAFT聚合制备PMPS-b-PNIPAM嵌段共聚物及温敏性纳米粒子[J]. 化工学报, 2019, 70(10): 4080-4088.
[14]	顾佳, 辛忠, 高文莉, 何璐铭, 赵瑞. CO耐硫甲烷化MoS₂/Si-ZrO₂催化剂的失活原因研究[J]. 化工学报, 2019, 70(10): 3941-3948.
[15]	陈政, 王莉, 周健. 双响应性嵌段聚合物的纳米孔开关效应的计算机模拟[J]. 化工学报, 2019, 70(1): 271-279.

pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响

Influence of pH on PHA production by halophilic sludge fermenting mixed VFAs substrate

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价