不同截面形状超疏水微肋阵内对流换热特性

doi:10.11949/j.issn.0438-1157.20161079

化工学报 ›› 2017, Vol. 68 ›› Issue (1): 63-71.DOI: 10.11949/j.issn.0438-1157.20161079

不同截面形状超疏水微肋阵内对流换热特性

祝叶^1,2, 管宁², 李栋¹, 赵孝保¹, 刘志刚²

1 南京师范大学能源与机械工程学院, 江苏省能源系统过程转化与减排技术工程实验室, 江苏南京 210042;
2 山东省科学院能源研究所流动与强化传热重点实验室, 山东济南 250014

收稿日期:2016-08-01 修回日期:2016-10-21 出版日期:2017-01-05 发布日期:2017-01-05
通讯作者: 李栋
基金资助:
国家自然科学基金项目（51306107）；江苏省自然科学基金青年项目（BK20150979）；山东省重点研发计划项目（2016GGX104004）。

Convection heat transfer characteristics of super-hydrophobic micro pin-fins with different cross-sectional shapes

ZHU Ye^1,2, GUAN Ning², LI Dong¹, ZHAO Xiaobao¹, LIU Zhigang²

1 Engineering Laboratory of Energy System Process Conversion and Emission Reduction Technology of Jiangsu Province, School of Energy and Mechanical Engineering, Nanjing Normal University, Nanjing 210042, Jiangsu, China;
2 Key Laboratory for Flow & Enhanced Heat, Energy Research Institute of Shandong Academy of Sciences, Jinan 250014, Shandong, China

Received:2016-08-01 Revised:2016-10-21 Online:2017-01-05 Published:2017-01-05
Contact: 10.11949/j.issn.0438-1157.20161079
Supported by:
supported by the National Natural Science Foundation of China (51306107) and the Youth Project of the Natural Science Foundation of Jiangsu Province (BK20150979).

摘要/Abstract

摘要：

通过在圆形、菱形以及椭圆形微肋阵表面固化含有微纳米颗粒涂层制备超疏水微肋阵，并对不同截面形状超疏水微肋阵内流动与对流换热特性进行实验研究，测量得到了超疏水处理前后各截面形状微肋阵内流动阻力系数f以及Nusselt数。此外，通过计算超疏水微肋阵内的综合传热强化因子ε，定量分析了超疏水处理对不同截面形状微肋阵内流动与换热特性的综合影响。研究结果表明，超疏水处理后圆形、菱形、椭圆形微肋阵内摩擦阻力系数与未处理前相比最大可降低72%、66%、70%；同时，3种截面微肋阵内Nu有所降低，且疏水前后微肋阵Nu偏差随加热功率的增加逐渐减小，高加热功率下3种微肋阵超疏水处理前后Nu偏差最大分别不超过44%、17%、47%；高加热功率下超疏水菱形微肋阵在Re<1200范围内具有良好的综合传热强化性能，ε始终高于1.17。

关键词: 微肋阵, 超疏水性, 减阻率, 对流换热, 综合传热强化因子

Abstract:

Super-hydrophobic micro pin-fins with circular, diamond and elliptical cross-sectional shapes were prepared by solidifying hydrophobic layers involved nano-particles on the flowing surfaces, and the flow resistance coefficient as well as Nusselt number in super-hydrophobic micro pin-fins was measured.The integrated effect of super-hydrophobic surface on resistance reduction and heat transfer enhancement was explored by analyzing the integrated heat transfer enhancement factor ε.The results indicated that the friction resistance coefficient was reduced at 72%, 66% and 70% in three kinds of micro pin-fins with super-hydrophobic walls and different cross-sectional shapes.Besides, although Nu in all three kinds of micro pin-fins was reduced, the value of the decrease was less than 44%, 17% and 47% under the high heating power in present research.In addition, the super-hydrophobic micro pin-fins with diamond cross-sectional shape had good comprehensive heat transfer enhancement performance under the high heating power, and the value of ε is higher than 1.17 in the range of Re<1200.

Key words: micro pin-fins, super-hydrophobic, resistance reduction ratio, convective heat transfer, integrated heat transfer enhancement factor

中图分类号:

TK124

祝叶, 管宁, 李栋, 赵孝保, 刘志刚. 不同截面形状超疏水微肋阵内对流换热特性[J]. 化工学报, 2017, 68(1): 63-71.

ZHU Ye, GUAN Ning, LI Dong, ZHAO Xiaobao, LIU Zhigang. Convection heat transfer characteristics of super-hydrophobic micro pin-fins with different cross-sectional shapes[J]. CIESC Journal, 2017, 68(1): 63-71.

参考文献 25

[1]	HITT D L, ZAKRZWSKI C M, THOMAS M A. MEMS-based satellite micropropulsion via catalyzed hydrogen peroxide decomposition[J]. Smart Materials & Structures, 2001, 10(6):1163-1175.
[2]	LIU Z, WANG Z, ZHANG C, et al. Flow resistance and heat transfer characteristics in micro-cylinders-group[J]. Heat & Mass Transfer, 2013, 49(49):733-744.
[3]	张承武, 浦龙梅, 姜桂林, 等. 不同截面形状微肋片内流动阻力特性[J]. 化工学报, 2014, 65(6):2042-2048. ZHANG C W, PU L M, JIANG G L, et al. Resistance characteristics of micro pin fins with different cross-section shapes[J]. CIESC Journal, 2014, 65(6):2042-2048.
[4]	张承武, 刘志刚, 管宁. 加热热通量对微柱群通道内强迫对流换热的影响[J]. 化工学报, 2010, 61(12):3080-3085. ZHANG C W, LIU Z G, GUAN N. Influence of heat flux on forced convective heat transfer in duct with micro-cylinder-group[J]. CIESC Journal, 2010, 61(12):3080-3085.
[5]	TULLIUS J F, TULLIUS T K, BAYAZITOGLU Y. Optimization of short micro pin fins in minichannels[J]. International Journal of Heat & Mass Transfer, 2012, 55(15/16):3921-3932.
[6]	SHAFEIE H, ABOUALI O, JAFARPUR K, et al. Numerical study of heat transfer performance of single-phase heat sinks with micro pin-fin structures[J]. Applied Thermal Engineering, 2013, 58(1/2):68-76.
[7]	QU W, SIU H A. Liquid single-phase flow in an array of micro-pin-fins(Ⅱ):Pressure drop characteristics[J]. Journal of Heat Transfer, 2008, 130(12):124501.
[8]	夏国栋, 罗光亮, 李晏君, 等. 流体横掠圆形微针肋热沉流动与传热特性[J]. 工程热物理学报, 2009, 30(4):621-624. XIA G D, LUO G L, LI Y J, et al. Flow and heat transfer characteristics across circular-shaped micro pin fin heat sinks[J]. Journal of Engineering Thermophysics, 2009, 30(4):621-624.
[9]	OU J, PEROT B, ROTHSTEIN J P. Laminar drag reduction in microchannels using ultrahydrophobic surfaces[J]. Physics of Fluids, 2004, 16(12):4635-4643.
[10]	SONG F Q, ZUO J C, WANG J D. The drag reduction performances of surfactant in micro-channel[C]//2009 International Forum on Porous Flow and Applications. Wuhan, 2009.
[11]	ZHU Y, GRANICK S. Limits of the hydrodynamic no-slip boundary condition.[J]. Physical Review Letters, 2002, 88(10):178-185.
[12]	TRETHEWAY D C, MEINHART C D. Apparent fluid slip at hydrophobic microchannel walls[J]. Physics of Fluids (1994-present), 2002, 14(14):L9-L12.
[13]	郝秀清, 王莉, 丁玉成, 等. 超疏水表面的减阻研究[J]. 润滑与密封, 2009, 34(9):25-28. HAO X Q, WANG L, DING Y C, et al. Study on the drag reduction of the super hydrophobic surface[J]. Lubrication and Seal, 2009, 34(9):25-28.
[14]	霍素斌, 于志家, 李艳峰, 等. 超疏水表面微通道内水的流动特性[J]. 化工学报, 2007, 58(11):2721-2726. HUO S B, YU Z J, LI Y F, et al. Flow characteristics of water in microchannel with super-hydrophobic surface[J]. Journal of Chemical Industry and Engineering(China), 2007, 58(11):2721-2726.
[15]	郝鹏飞, 汪幸愉, 姚朝晖, 等. 疏水微槽道内层流减阻的实验研究[J]. 实验流体力学, 2009, 23(3):7-11. HAO P F, WANG X Y, YAO Z H, et al. Experimental study on laminar drag reduction in hydrophobic microchannels[J]. Journal of Experiments in Fluid Mechanics, 2009, 23(3):7-11.
[16]	宋善鹏, 于志家, 刘兴华, 等. 超疏水表面微通道内水的传热特性[J]. 化工学报, 2008, 59(10):2465-2469. SONG S P, YU Z J, LIU X H, et al. Heat transfer characteristics of water flowing in microchannels with super-hydrophobic inner surface[J].Journal of Chemical Industry and Engineering(China), 2008, 59(10):2465-2469.
[17]	HSIEH S S, LIN C Y. Convective heat transfer in liquid microchannels with hydrophobic and hydrophilic surfaces[J]. International Journal of Heat & Mass Transfer, 2009, 52(1/2):260-270.
[18]	范新欣, 周玉红, 刘天庆. 超疏水表面有滑移时的层流换热分析[J]. 化工学报, 2010, 61(3):594-600. FAN X X, ZHOU Y H, LIU T Q. Analysis of laminar heat transfer on super-hydrophobic surface with slip velocity[J]. CIESC Journal, 2010, 61(3):594-600.
[19]	姜桂林, 张承武, 管宁, 等. 水在不同接触角微柱群内的流动特征[J]. 化工学报, 2015, 66(5):1704-1709. JIANG G L, ZHANG C W, GUAN N, et al. Flow characteristics of water in hydrophobic micro cylinders group with different contact angles[J]. CIESC Journal, 2015, 66(5):1704-1709.
[20]	姜桂林, 管宁, 张承武, 等. 不同截面疏水性微肋阵内减阻特性[J]. 化工学报, 2016, 67(4):1258-1268. JIANG G L, GUAN N, ZHANG C W, et al. Characteristics of drag reduction in different cross section of hydrophobic micro pin fins[J]. CIESC Journal, 2016, 67(4):1258-1268.
[21]	LIU Z G, GUAN N, ZHANG C W, et al. The flow resistance and heat transfer characteristics of micro pin-fins with different cross-sectional shapes[J]. Nanoscale & Microscale Thermophysical Engineering, 2015, 19(3):221-243.
[22]	夏国栋, 崔珍珍, 翟玉玲, 等. 长菱形微针肋热沉的流动与换热特性[J]. 中国石油大学学报(自然科学版), 2014, 38(2):130-134. XIA G D, CUI Z Z, ZHAI Y L, et al. Flow and heat transfer characteristics for long-diamond shaped micro pin fin[J]. Journal of China University of Petroleum (Edition of Natural Sciences), 2014, 38(2):130-134.
[23]	GUAN N, JIANG G, LIU Z, et al. The impact of contact angle on flow resistance reduction in hydrophobic micro pin fins[J]. Experimental Thermal & Fluid Science, 2016, 77:197-211.
[24]	GUAN N, LUAN T, LIU Z G, et al. Influence of heating load on heat transfer characteristics in micro-pin-fin arrays[J]. Heat and Mass Transfer, 2016, 52(2):393-405.
[25]	WEBB R L, ECKERT E R G. Application of rough surfaces to heat exchanger design[J]. International Journal of Heat & Mass Transfer, 1972, 15(9):1647-1658.流动特性[J].化工学报,2007,58(11):2721-2726.HUO S B,YU Z J,LI Y F,et al.Flow characteristics of water in microchannel with super-hydrophobic surface[J].Journal of Chemical Industry&Engineering,2007,22:208-209.
[15]	郝鹏飞,汪幸愉,姚朝晖,等.疏水微槽道内层流减阻的实验研究[J].实验流体力学,2009,23(3):7-11.HAO P F,WANG X Y,YAO Z H,et al.Experimental study on laminar drag reduction in hydrophobic microchannels[J].Journal of Experiments in Fluid Mechanics,2009.
[16]	宋善鹏,于志家,刘兴华,等.超疏水表面微通道内水的传热特性[J].化工学报,2008,59(10):2465-2469.SONG S P,YU Z J,LIU X H,et al.Heat transfer characteristics of water flowing in microchannels with super-hydrophobic inner surface[J].Huagong Xuebao/journal of Chemical Industry&Engineering,2008,59(10):2465-2469.
[17]	HSIEH S S,LIN C Y.Convective heat transfer in liquid microchannels with hydrophobic and hydrophilic surfaces[J].International Journal of Heat&Mass Transfer,2009,52(1-2):260-270.
[18]	范新欣,周玉红,刘天庆.超疏水表面有滑移时的层流换热分析[J].化工学报,2010,61(3):594-600.FAN X X,ZHOU Y H,LIU T Q.Analysis of laminar heat transfer on super-hydrophobic surface with slip velocity[J].CIESC Journal,2010:527-534.
[19]	姜桂林,张承武,管宁,等.水在不同接触角微柱群内的流动特征[J].化工学报,2015(5):1704-1709.JIANG G L,ZHANG C W,GUAN N,et al.Flow characteristics of water in hydrophobic micro cylinders group with different contact angles[J].Ciesc Journal,2015,66:1704-1709.
[20]	姜桂林,管宁,张承武,等.不同截面疏水性微肋阵内减阻特性[J].化工学报,2015(4).JIANG G L,ZHANG C W,GUAN N,et al.Flow characteristics of water in hydrophobic micro cylinders group with different contact angles[J].Ciesc Journal,2015,66:1704-1709.
[21]	LIU Z G,GUAN N,ZHANG C W,et al.The Flow Resistance and Heat Transfer Characteristics of Micro Pin-Fins with Different Cross-Sectional Shapes[J].Nanoscale&Microscale Thermophysical Engineering,2015,19(3):221-243.
[22]	夏国栋,崔珍珍,翟玉玲,等.长菱形微针肋热沉的流动与换热特性[J].中国石油大学学报:自然科学版,2014,38(2):130-134.XIA G D,CUI Z Z,ZHAI Y L,et al.Flow and heat transfer characteristics for long-diamond shaped micro pin fin[J].Zhongguo Shiyou Daxue Xuebao,2014,38(2):130-134.
[23]	GUAN N,JIANG G,LIU Z,et al.The impact of contact angle on flow resistance reduction in hydrophobic micro pin fins[J].Experimental Thermal&Fluid Science,2016,77:197-211.
[24]	GUAN N,LUAN T,LIU Z G,et al.Influence of heating load on heat transfer characteristics in micro-pin-fin arrays[J].Heat and Mass Transfer,2016,52(2):393-405.
[25]	WEBB R L,ECKERT E R G.Application of rough surfaces to heat exchanger design[J].International Journal of Heat&Mass Transfer,1972,15(9):1647-1658.

不同截面形状超疏水微肋阵内对流换热特性

Convection heat transfer characteristics of super-hydrophobic micro pin-fins with different cross-sectional shapes

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 25

相关文章 15

编辑推荐

Metrics

本文评价

[1]	刘志刚,董开明,吕明明,季璨,江亚柯. 基于微观粒子图像测速法的微肋阵通道内流场特性研究[J]. 化工学报, 2021, 72(10): 5094-5101.
[2]	裴后举, 蒋彦龙, 施红, 崔永龙, 陈常栋, 钱晓辉. 基于M-L湍流模型的浮空器强迫对流换热[J]. 化工学报, 2020, 71(S1): 136-141.
[3]	杜保周, 孔令健, 郭保仓, 李慧君, 刘志刚, 吕明明. 微肋阵通道内流动沸腾CHF特性[J]. 化工学报, 2018, 69(5): 1989-1998.
[4]	许文杰, 李敏霞, 郭强. 润滑油对超临界二氧化碳对流换热特性的影响[J]. 化工学报, 2018, 69(5): 1982-1988.
[5]	杜保周, 李慧君, 郭保仓, 孔令健, 刘志刚. 微肋阵通道流动沸腾换热与压降特性[J]. 化工学报, 2018, 69(12): 4979-4989.
[6]	姜桂林, 管宁, 张承武, 刘志刚. 不同截面疏水性微肋阵内减阻特性[J]. 化工学报, 2016, 67(4): 1258-1268.
[7]	严俊杰, 祝银海, 芦泽龙, 姜培学. 超临界压力碳氢燃料瞬态加热响应特性[J]. CIESC Journal, 2015, 66(S1): 65-70.
[8]	姜桂林, 张承武, 管宁, 邱德来, 刘志刚. 水在不同接触角微柱群内的流动特征[J]. 化工学报, 2015, 66(5): 1704-1709.
[9]	冷学礼, 田茂诚, 邱燕, 柏超. 基于广义原理的对流换热热阻计算方法及检验[J]. 化工学报, 2014, 65(S1): 292-296.
[10]	卢小平, 俞树荣, 余建平, 何爱玲, 郭丹丹. 流动换热强化的能量传递转换机制及其最小熵产原理[J]. 化工学报, 2014, 65(S1): 336-339.
[11]	吕宇玲1，丁慎圆1，何利民1，安文鹏1，刘元威2. 聚丙烯酰胺水溶液管道流动特性研究[J]. 化工进展, 2014, 33(10): 2592-2597.
[12]	孙斌，赵朝. 内螺纹管内金属氧化物-水纳米流体传热特性的数值模拟[J]. 化工进展, 2014, 33(03): 563-567.
[13]	魏巍, 陈群, 任建勋. 温差驱动型自反馈对流换热系统[J]. 化工学报, 2013, 64(6): 1934-1938.
[14]	李振兴，张立志. 空气横掠中空纤维膜管束的流动与传热性能[J]. 化工学报, 2012, 63(S1): 23-27.
[15]	刘巍，朱春玲. 分流板结构对微通道平行流蒸发器性能的影响[J]. 化工学报, 2012, 63(3): 761-766.