绕流具有光合生化反应管束的格子Boltzmann模拟

doi:10.3969/j.issn.0438-1157.2012.08.007

化工学报 ›› 2012, Vol. 63 ›› Issue (8): 2383-2391.DOI: 10.3969/j.issn.0438-1157.2012.08.007

绕流具有光合生化反应管束的格子Boltzmann模拟

杨艳霞1,2，廖强1,2，朱恂1,2，王宏1,2，丁玉栋1,2

1重庆大学低品位能源利用技术及系统教育部重点实验室，重庆 400030；2重庆大学工程热物理研究所，重庆 400030

收稿日期:2012-01-06 修回日期:2012-02-20 出版日期:2012-08-05 发布日期:2012-08-05
通讯作者: 廖强
基金资助:
国家杰出青年基金项目;国家自然科学基金项目;重庆市自然科学基金重点项目

Lattice Boltzmann simulation of substrate flow past tube bundle with photo-biochemical reaction

YANG Yanxia1,2，LIAO Qiang1,2，ZHU Xun1,2，WANG Hong1,2，DING Yudong1,2

Received:2012-01-06 Revised:2012-02-20 Online:2012-08-05 Published:2012-08-05
Contact: Qiang Liao
Supported by:
National Science Fund for Distinguished Young Scholars;National Natural Science Foundation of China;Natural Science Fundation of Chongqing

摘要/Abstract

摘要： 采用格子Boltzmann方法模拟了有机废水溶液绕流表面附着有光合生物膜管束的流动、传质及光合生化反应过程，并分析了管束排列，管间距及Reynolds数对流场、浓度场、平均阻力系数及底物的Sherwood数的影响。结果表明：溶液绕流小管间距时具有较高的Sherwood数，同时阻力系数也较高；与顺排管束相比，绕流叉排管束的平均Sherwood数增大了一倍左右，其增大幅度随Re的增大而增大，而阻力系数仅增大了约10%。一定条件下，绕流叉排管束时，出口处具有较低的底物浓度和较高的产物浓度。结果表明，很小的流场扰动可对浓度场产生较大影响，从而，叉排管束更有利于传输传质及生物降解。

关键词: 格子Boltzmann方法, 生化反应, 光合细菌, 管束

Abstract: The lattice Boltzmann method is applied to simulate the fluid flow and mass transfer accompanying biochemical reaction，which is a bio-hydrogen production system by photosynthetic bacteria in biofilm adhered on the surface of tube bundle.The effect of inlet velocity(Reynolds number)，tube spacing and tube arrangement(inline and staggered)on velocity and concentration fields，average drag coefficient，and Sherwood number of substrate are investigated.The velocity field and concentration fields of substrate and product under various conditions are depicted.Lower substrate concentration and higher product concentration are obtained at the rear of tubes，both for inline and staggered arrangement. Compared to that with inline arrangement，the substrate concentration is lower and product concentration is higher at the outlet for solution fluid flow around staggered bundle.Furthermore，the hydrodynamics and mass transfer are estimated by parameters of average drag coefficient and Sherwood number of substrate.The numerical results reveal that small tube spacing leads to high Sherwood number of substrate，but at the expense of high drag coefficient.Compared with inline arrangement，the staggered arrangement leads to an up to double increment in Sherwood number and the increment increases with Re，while drag coefficient increases only 10%.It is concluded that small fluid disturbance has a great impact on the mass transfer，and the staggered arrangement is more beneficial to mass transfer and biodegradation.

Key words: lattice Boltzmann method, biochemical reaction, photosynthetic bacteria, tube bundle

中图分类号:

TK 91

杨艳霞1,2，廖强1,2，朱恂1,2，王宏1,2，丁玉栋1,2. 绕流具有光合生化反应管束的格子Boltzmann模拟[J]. 化工学报, 2012, 63(8): 2383-2391.

YANG Yanxia1,2，LIAO Qiang1,2，ZHU Xun1,2，WANG Hong1,2，DING Yudong1,2. Lattice Boltzmann simulation of substrate flow past tube bundle with photo-biochemical reaction[J]. CIESC Journal, 2012, 63(8): 2383-2391.

参考文献 18

[1]	Goltsov VA,Veziroglu TN,Goltsova LF. Hydrogen civilization of the future--A new conception of the IAHE. Int. J. Hydrogen Energy,2006,31:153-159.
[2]	Akkerman I,Janssen M,Rocha J,Wijffels RH. Photobiological hydrogen production: photochemical efficiency and bioreactor design. Int. J. Hydrogen Energy,2002,27:1195-1208.
[3]	Chen CY,Chang JS. Enhancing phototropic hydrogen production by solid-carrier assisted fermentation and internal optical-fiber illumination. Process Biochem.,2006,41:2041-2049.
[4]	Zhang ZP,Show KY,Tay JH,Liang DT,Lee DJ. Biohydrogen production with anaerobic fluidized bed reactors--A comparison of biofilm-based and granule-based systems. Int. J. Hydrogen Energy,2008,33:1559-1564.
[5]	Tian X,Liao Q,Liu W,Wang YZ,Zhu X,Li J,Wang H. Photo-hydrogen production rate of a PVA-boric acid gel granule containing immobilized photosynthetic bacteria cells. Int. J. Hydrogen Energy,2009,34:4708-4717.
[6]	Wang YZ,Liao Q,Zhu X,Tian X,Zhang C. Characteristics of hydrogen production and substrate consumption of Rhodopseudomonas palustris CQK 01 in an immobilized-cell photobioreactor. Bioresource technol.,2010,101:4034-4041.
[7]	Zhang C,Zhu X,Liao Q,Wang YZ,Li J,Ding Y,Wang H. Performance of a groove-type photobioreactor for hydrogen production by immobilized photosynthetic bacteria. Int. J. Hydrogen Energy,2010,35:5284-5292.
[8]	Banerjee I,Modak JM,Bandopadhyay K,Das D,Maiti BR. Mathematical model for evaluation of mass transfer limitations in phenol biodegradation by immobilized Pseudomonas putida. J. Biotechnol.,2001,87:211-223.
[9]	Wang X,Ding J,Ren NQ,Liu BF,Guo WQ. CFD simulation of an expanded granular sludge bed (EGSB) reactor for biohydrogen production. Int. J. Hydrogen Energy,2009,34:9686-9695.
[10]	Chang C,Liu CH,Lin CA. Boundary conditions for lattice Boltzmann simulations with complex geometry flows. Comput. Math. Appl.,2009,58:940-949.
[11]	Sukop MC,Thorne DT. Lattice Boltzmann modeling: An introduction for geoscientists and engineers: Springer Verlag,2006.
[12]	Sullivan SP,Sani FM,Johns ML,Gladden LF. Simulation of packed bed reactors using lattice Boltzmann methods. Chem. Eng. Sci.,2005,60:3405-3418.
[13]	He X,Luo LS. A priori derivation of the lattice Boltzmann equation. Phys. Rev. E,1997,55:6333-6336.
[14]	He X,Luo LS. Theory of the lattice Boltzmann method: From the Boltzmann equation to the lattice Boltzmann equation. Phys. Rev. E,1997,56:6811.
[15]	Guo Z,Zheng C,Shi B. An extrapolation method for boundary conditions in lattice Boltzmann method. Phys. Fluids,2002,14:2007.
[16]	Yang YX,Liao Q,Zhu X,Wang H,Wu R,Lee DJ. Lattice Boltzmann simulation of substrate flow past a tube with PSB biofilm for bio-hydrogen production. Int. J. Hydrogen Energy,2011,36:14031-14040.
[17]	Liao Q,Liu DM,Ye DD,Zhu X,Lee DJ. Mathematical modeling of two-phase flow and transport in an immobilized-cell photobioreactor. Int. J. Hydrogen Energy,2011,36: 13939-13948.
[18]	Mei R,Yu D,Shyy W,Luo LS. Force evaluation in the lattice Boltzmann method involving curved geometry. Phys. Rev. E,2002,65:041203.

绕流具有光合生化反应管束的格子Boltzmann模拟

Lattice Boltzmann simulation of substrate flow past tube bundle with photo-biochemical reaction

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 14

编辑推荐

Metrics

本文评价

[1]	祁荣宾, 刘趁霞, 钟伟明, 钱枫. 一种基于梯度信息的多目标优化算法[J]. 化工学报, 2013, 64(12): 4401-4409.
[2]	谢学旺1，董舟1，朱恂2，廖强2. 光合细菌的葡萄糖跨膜传输及代谢产氢模型[J]. 化工学报, 2012, 63(7): 2229-2233.
[3]	金涌，邵婷，赵述芳，王文坦，刘喆，程易. 微通道中液滴内部混合过程的μ-LIF可视化和LBM模拟[J]. 化工学报, 2012, 63(2): 375-381.
[4]	孙帆, 杜文莉, 钱锋. 一种改进的差分进化算法及其在补料分批式生化反应器动态优化中的应用[J]. 化工学报, 2012, 63(11): 3609-3617.
[5]	环流型光纤生物膜制氢反应器的连续产氢性能. 环流型光纤生物膜制氢反应器的连续产氢性能[J]. CIESC Journal, 2011, 62(11): 3248-3255.
[6]	屈晓凡, 廖强, 朱恂, 高晓玉, 王永忠, 田鑫. 微小空间内光合细菌与气-液相界面作用的可视化实验 [J]. 化工学报, 2011, 62(1): 163-169.
[7]	谢学旺, 朱恂, 廖强, 王永忠, 王宏, 丁玉栋, 李俊, 叶丁丁. 序批式光生物反应器中光合细菌跨膜传输及产氢特性 [J]. 化工学报, 2010, 61(6): 1516-1522.
[8]	朱恂，高晓玉，屈晓凡，王永忠，田鑫，廖强. 模拟微通道光生物反应器内光合细菌的成膜及产氢特性 [J]. CIESC Journal, 2010, 61(11): 2965-2970.
[9]	李刚，张全国. 光合细菌生物制氢反应器的现状分析 [J]. CIESC Journal, 2009, 28(1): 41-.
[10]	贺益君;俞欢军;成飙;陈德钊. 多目标粒子群算法用于补料分批生化反应器动态多目标优化 [J]. CIESC Journal, 2007, 58(5): 1262-1270.
[11]	于海艳，张兴，李枝玲，刘晓娟，林谢华. 生物合成5-氨基乙酰丙酸的发酵条件 [J]. CIESC Journal, 2006, 25(10): 1217-.
[12]	廖强;朱寿礼;朱恂. 生物膜填料床内含有生化反应的多相传输模型 [J]. CIESC Journal, 2005, 56(9): 1743-1749.
[13]	岳秀萍, 李亚新, 刘美霞. 聚季铵盐对厌氧生化反应器中微生物自身固定化的促进作用 [J]. 化工学报, 2004, 55(3): 418-421.
[14]	吴金川,何志敏,余国琮. 生化反应──色谱分离耦合过程模型研究 [J]. CIESC Journal, 1996, 47(2): 192-198.