室外换热器迎面风速对空气源热泵结霜特性的影响

doi:10.3969/j.issn.0438-1157.2012.z2.006

化工学报 ›› 2012, Vol. 63 ›› Issue (S2): 32-37.DOI: 10.3969/j.issn.0438-1157.2012.z2.006

室外换热器迎面风速对空气源热泵结霜特性的影响

郭宪民, 王冬丽, 陈轶光, 汪伟华

天津商业大学天津市制冷技术重点实验室, 天津 300134

收稿日期:2012-09-21 修回日期:2012-09-28 出版日期:2012-12-28 发布日期:2012-12-28
通讯作者: 郭宪民
作者简介:郭宪民(1962-),男,博士,教授。
基金资助:
天津市自然科学基金项目(06YFJMJC05500)。

Effects of face velocity of outdoor heat exchanger on frosting characteristics of air source heat pump system

GUO Xianmin, WANG Dongli, CHEN Yiguang, WANG Weihua

Tianjin Key Laboratory of Refrigeration Technology, Tianjin University of Commerce, Tianjin 300134, China

Received:2012-09-21 Revised:2012-09-28 Online:2012-12-28 Published:2012-12-28
Supported by:
supported by the Natural Science Foundation of Tianjin(06YFJMJC05500).

摘要/Abstract

摘要： 对不同迎面风速条件下空气源热泵系统室外换热器表面霜层生长特性进行了实验研究,测量了翅片表面动态霜层厚度、换热器结霜量,显微观察了霜晶生长过程。实验结果表明,迎面风速的降低使得空气源热泵机组室外换热器表面霜层厚度加速增长,结霜周期随迎面风速的下降呈近乎线性地减小,而且相对湿度越低,结霜周期下降的速度越快;因此,减小室外换热器迎面风速将恶化空气源热泵机组结霜/除霜周期中的平均性能。对霜晶形态的显微观察发现,低迎面风速工况下霜层厚度增长速度加快的原因是由于空气源热泵蒸发器壁面温度降低造成的霜晶形态的改变,翅片表面柱状冰晶始终在高度方向快速生长,这种现象与低环境温度工况下翅片表面霜晶生长形态类似。换热器总结霜量随迎面风速的减小而下降,造成霜层平均密度降低。

关键词: 空气源热泵, 迎面风速, 霜层生长特性, 结霜实验

Abstract: The frost growth characteristics on the outdoor heat exchanger of an air source heat pump(ASHP)under different face velocity conditions were investigated experimentally.The dynamic frost thickness on the fins and the frost accumulation mass on the evaporator were measured,and the growth process of the frost layer was observed through a microscope.The experimental results indicate that the decrease in the face velocity of the outdoor heat exchanger accelerates the growth of the frost layer,the frosting duration reduces almost linearly with the decrease in the face velocity,further more,the lower the relative humidity is,the faster the frosting duration decreases.Therefore,the decrease in the face velocity of the outdoor heat exchanger will deteriorate the average performance of the ASHP unit in the frost/defrost period.The observation to the frost layer through a microscope shows that the acceleration of the frost layer growth under low face velocity condition is mainly attributed to the morphological variation of the frost crystal comparing with that under the high face velocity condition,which is resulted from the decrease in the wall temperature of the evaporator.Under the low face velocity condition,the column-shaped ice crystals grow mainly in its length in whole frosting period,which is similar with the form of the frost crystal under the low temperature and high face velocity conditions.The total frost accumulation mass reduces with the decrease in the face velocity,therefore,the average frost density is fallen down.

Key words: air source heat pump, face velocity, frost growth characteristics, frosting experiment

中图分类号:

TB657

郭宪民, 王冬丽, 陈轶光, 汪伟华. 室外换热器迎面风速对空气源热泵结霜特性的影响[J]. 化工学报, 2012, 63(S2): 32-37.

GUO Xianmin, WANG Dongli, CHEN Yiguang, WANG Weihua. Effects of face velocity of outdoor heat exchanger on frosting characteristics of air source heat pump system[J]. CIESC Journal, 2012, 63(S2): 32-37.

参考文献 12

[1]	Kondepudi S N,O’Neal D L.Frosting performance of tube heat exchangers with wavy and corrugated fins [J].J.Experimental Thermal and Fluid Science,1991,4(5):613-618
[2]	Rite R W,Crawford R R.A parametric study of the factors governing the rate of frost accumulation on domestic refrigerator-freezer finned-tube evaporator coils [J].ASHRAE Trans.,1991,97(2):438-446
[3]	Seker D,Karatas H,Egrican N.Frost formation on fin-and-tube heat exchanges(Ⅰ):Modeling of frost formation on fin-and-tube heat exchangers [J].Int.J.Refrigeration,2004,27(4):367-374
[4]	Yao Y,Jiang Y Q,Deng S M.A study on the performance of the airside heat exchanger under frosting in a air source heat pump water heater/chiller unit [J].Int.J.Heat Mass Transfer,2004,47(17):3745-3756
[5]	Senshu T,Yasuda H,Kuroda S,et al.Heat pump performance under frosting conditions(Ⅰ):Heat and mass transfer on cross-finned tube heat exchangers under frosting conditions [J].ASHRAE Trans.,1990,96:324-329
[6]	Yan W M,Li H Y,Wu Y J,et al.Performance of finned tube heat exchangers operating under frosting conditions [J].Int.J.Heat Mass Transfer,2003,46(5):871-877
[7]	Yan W M,Li H Y,Tsay Y L.Thermofluid characteristics of frosted finned-tube heat exchangers [J].Int.J.Heat Mass Transfer,2005,48(15):3073-3080
[8]	Guo X M,Wang C S,Wang W H,et al.Numerical simulation and experimental verification on dynamic performance of air source heat pump under frosting gonditions[J].Journal of Xi’an Jiaotong University,2006,40(5):544-548
[9]	Guo X M,Chen Y G,Wang W H,et al.Effect of outdoor air parameters on frosting characteristics of fin-tube evaporator for air source heat pump unit[J].Journal of Refrigeration,2006,27(6):29-33
[10]	Guo X M,Chen Y G,Wang W H,Chen C Z.Experimental study on frost growth and dynamic performance of air source heat pump system [J].Applied Thermal Engineering,2008,28(18):2267-2278
[11]	Liu C,Guo X M,Yang B.Experimental study on the defrost characteristics of an air source heat pump unit with split fin-tube heat exchanger[J].Fluid Machinery,2009,37(2):52-56
[12]	Guo X M,Wang S Y,Wang W H,et al.Effect of environmental condition on evaporator surface frost layer for air source heat pump[J].Journal of Xi’an Jiaotong University,2011,45(3):30-35

[1]	汪谦旭, 刘益才, 梁恒, 李政, 赵祥乐. 融霜下落水对换热器除霜性能的影响[J]. 化工学报, 2021, 72(S1): 356-361.
[2]	马坤茹, 李雪峰, 李思琦, 高翠娟. 新型太阳能/空气能直膨式热泵与空气源热泵供热性能对比[J]. 化工学报, 2020, 71(S1): 375-381.
[3]	. 将CO₂、R170和R41应用于跨临界空气源热泵热水器系统的性能对比研究[J]. 化工学报, 2020, 71(S1): 51-56.
[4]	邵索拉, 张欢, 由世俊, 郑万冬. 带有蓄热型直接冷凝式加热板的空气源热泵系统性能研究[J]. 化工学报, 2020, 71(8): 3480-3489.
[5]	邱君君, 张小松, 李玮豪. 无霜空气源热泵系统冬季除湿性能初步实验[J]. 化工学报, 2019, 70(4): 1605-1613.
[6]	李敏霞, 李昱翰, 马一太, 王派, 王飞波, 詹浩淼. 小型低温空气源热泵用转子和涡旋压缩机对比[J]. 化工学报, 2018, 69(S2): 379-387.
[7]	牛建会, 许树学, 刘帅领, 马国远. 带毛细管的变频压缩机空气源热泵实验研究[J]. 化工学报, 2018, 69(S2): 180-185.
[8]	陈子丹, 罗会龙, 刘锦春, 曹振国, 赵新帅, 杨武彪. 寒冷地区CO₂空气源热泵供暖运行性能分析[J]. 化工学报, 2018, 69(9): 4030-4036.
[9]	孙晋飞, 朱冬生, 尹应德, 李修真, 涂爱民. 单缸补气转子式压缩机在热泵系统中制热性能[J]. 化工学报, 2017, 68(9): 3551-3557.
[10]	靳成成, 王如竹, 翟晓强, 金哲权. 空气源热泵结合小温差风机盘管在高效舒适供热中的应用[J]. 化工学报, 2016, 67(S2): 51-57.
[11]	徐鹏飞, 翟晓强. 气候和围护结构对空气源热泵空调系统性能的影响[J]. 化工学报, 2016, 67(S2): 208-216.
[12]	段未, 马国远, 周峰. 泵驱动回路热管能量回收装置性能的影响因素[J]. 化工学报, 2016, 67(10): 4146-4152.
[13]	张双, 马国远, 张思朝, 周峰. 热虹吸管换热器的换热性能测试与分析[J]. 化工学报, 2014, 65(z2): 83-87.
[14]	江宇, 黄溢, 葛天舒, 王如竹. 新型热湿独立控制空调系统的实验研究[J]. 化工学报, 2014, 65(z2): 188-194.
[15]	张东, 李金平, 刘伟, 南军虎, 王林军. 喷气增焓空气源热泵热性能评价及预测[J]. 化工学报, 2014, 65(12): 5004-5009.

室外换热器迎面风速对空气源热泵结霜特性的影响

Effects of face velocity of outdoor heat exchanger on frosting characteristics of air source heat pump system

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 12

相关文章 15

编辑推荐

Metrics

本文评价