锌离子对自絮凝酵母乙醇耐性和絮凝颗粒大小的影响

化工学报 ›› 2008, Vol. 59 ›› Issue (10): 2582-2588.

锌离子对自絮凝酵母乙醇耐性和絮凝颗粒大小的影响

薛闯;赵心清;葛旭萌;袁文杰;白凤武

大连理工大学生物科学与工程系

出版日期:2008-10-05 发布日期:2008-10-05

Effect of zinc ion on ethanol tolerance and floc size of selfflocculating yeast

XUE Chuang; ZHAO Xinqing;GE Xumeng; YUAN Wenjie; BAI Fengwu

Online:2008-10-05 Published:2008-10-05

摘要/Abstract

摘要：

研究了6种金属离子在合成培养基中对摇瓶培养的自絮凝酵母乙醇耐性的影响，发现锌离子对高浓度乙醇冲击下的酵母细胞活性有保护作用，并进一步研究了乙醇连续发酵过程中锌的添加对自絮凝酵母乙醇耐性的影响。发酵培养基中分别添加0.01、0.05 和 0.1 g·L^-1的硫酸锌时，自絮凝酵母颗粒平均粒度减小，同时乙醇耐性和高温耐性都得到明显提高，并且发现细胞活性的提高与酵母细胞内麦角固醇和海藻糖的增加密切相关。对酵母细胞内锌的含量的分析表明，3个添加组胞内锌的积累量基本相似，比对照组均增加了6倍。相关性分析表明，酵母胞内锌含量与酵母细胞的胁迫耐性密切相关并显著影响其胁迫耐性。各添加组的乙醇产量均有提高，其中添加0.05 g·L^-1的硫酸锌时乙醇产量最高，比对照组高8.4%。以上研究结果表明，调控连续乙醇发酵过程中培养基中锌离子浓度，是提高酵母细胞乙醇耐受性、高温度耐受性和乙醇产量的有效途径。

关键词:

自絮凝酵母, 锌离子, 乙醇耐性, 温度耐性

Abstract:

The effects of metal ions on ethanol tolerance of selfflocculating yeast was studied by using a defined medium in shake flask cultureThe observed improvement of zinc ion supplementation on ethanol tolerance promoted the further examination of zinc ion effect on continuous ethanol fermentationZinc sulfate was supplemented into the fermentation medium at the concentrations of 0.01, 0.05 and 0.1 g·L^-1, respectivelyThe average floc size of the selfflocculating yeast decreased in zincaddition cultures, but both its ethanol tolerance and thermal tolerance were significantly improved, which correlated well with the increased ergosterol and trehalose contents in the yeast flocsIntracellular zinc content was found to be about six folds higher than that of control, and no significant difference was observed in the three addition levelsCorrelation analysis indicated close correlation between zinc addition and ethanol/thermal toleranceEthanol production increased in all the zincsupplemented cultures, with the most significant effect observed when 0.05 g·L^-1 zinc sulfate was suppliedThus, zinc ion supplementation was proved to be an efficient strategy for enhanced ethanol tolerance, thermal tolerance and ethanol production in continuous ethanol fermentation of the selfflocculating yeast.

Key words:

自絮凝酵母, 锌离子, 乙醇耐性, 温度耐性

薛闯, 赵心清, 葛旭萌, 袁文杰, 白凤武. 锌离子对自絮凝酵母乙醇耐性和絮凝颗粒大小的影响 [J]. 化工学报, 2008, 59(10): 2582-2588.

XUE Chuang, ZHAO Xinqing, GE Xumeng, YUAN Wenjie, BAI Fengwu. Effect of zinc ion on ethanol tolerance and floc size of selfflocculating yeast[J]. CIESC Journal, 2008, 59(10): 2582-2588.

[1]	张璐璐,谭伯川,李文坡. Cu²⁺掺杂MnO₂作为水系锌离子电池正极材料的合成与电化学性能[J]. 化工学报, 2021, 72(10): 5402-5411.
[2]	邓仕钧, 阳春华, 李勇刚, 朱红求. 锌电解全流程酸锌离子浓度在线预测模型[J]. 化工学报, 2015, 66(7): 2588-2594.
[3]	王亮, 薛闯, 白凤武. 气提法弱化超高浓度乙醇发酵过程中自絮凝酵母振荡行为[J]. 化工学报, 2013, 64(10): 3725-3731.
[4]	徐桂红，赵心清，李宁，白凤武. 锌离子提高絮凝酵母高浓度乙酸胁迫耐受性的研究[J]. 化工学报, 2012, 63(6): 1823-1829.
[5]	刘晨光, 李宁, 葛旭萌, 白凤武. 恒化培养过程中酵母絮凝性状退化行为 [J]. 化工学报, 2009, 60(8): 2031-2039.
[6]	丁萍;黄可龙;李桂银;曾雯雯;焦飞鹏 . 壳聚糖衍生物对Zn（Ⅱ）的吸附行为 [J]. CIESC Journal, 2006, 57(11): 2652-2656.
[7]	李红兵 . 海藻酸钠离子交换过程的圆二色谱 [J]. CIESC Journal, 2006, 57(10): 2497-2502.