CaS-CaSO4是否共熔的DTA和TG实验研究

doi:10.3969/j.issn.0438-1157.2013.08.023

化工学报 ›› 2013, Vol. 64 ›› Issue (8): 2860-2866.DOI: 10.3969/j.issn.0438-1157.2013.08.023

• 催化、动力学与反应器 • 上一篇下一篇

CaS-CaSO₄是否共熔的DTA和TG实验研究

樊腾飞^1,2,3, 赵丽凤^2,3, 王波^2,3, 田文栋^2,3, 程晓磊^1,2,3, 肖云汉^2,3

1. 中国科学院大学, 北京 100049;
2. 中国科学院先进能源动力重点实验室(工程热物理研究所), 北京 100190;
3. 中国科学院能源动力研究中心, 江苏连云港 222069

收稿日期:2012-12-11 修回日期:2013-02-21 出版日期:2013-08-05 发布日期:2013-08-05
通讯作者: 王波
作者简介:樊腾飞(1982- ),男,博士研究生。
基金资助:
国家自然科学基金项目(51176186);国家高技术研究发展计划项目(2008AA05A302)。

DTA & TG measurement and analysis of CaS-CaSO₄ system

FAN Tengfei^1,2,3, ZHAO Lifeng^2,3, WANG Bo^2,3, TIAN Wendong^2,3, CHENG Xiaolei^1,2,3, XIAO Yunhan^2,3

1. University of Chinese Academy of Sciences, Beijing 100049, China;
2. Key Laboratory of Advanced Energy and Power(Institute of Engineering Thermophysics), Chinese Academy of Sciences, Beijing 100190, China;
3. Research Center for Clean Energy and Power, Chinese Academy of Sciences, Lianyungang 222069, Jiangsu, China

Received:2012-12-11 Revised:2013-02-21 Online:2013-08-05 Published:2013-08-05
Supported by:
supported by the National Natural Science Foundation of China(51176186)and the High-tech Research and Development Program of China(2008AA05A302).

摘要/Abstract

摘要： CaS和CaSO₄熔点均在1400℃以上,研究发现CaS和CaSO₄混合物在827℃可能存在熔融现象。CaS与CaSO₄是否存在共熔对以CaSO₄为载氧体的反应器的操作条件优化具有重要影响。从物理化学变化及其热效应角度,利用综合热分析仪对氮气气氛下不同摩尔比例均匀混合的CaS、CaSO₄样品进行差热分析(DTA)和热重分析(TG)研究,并对实验残留物进行SEM分析。结果表明,在700~1300℃的常压惰性气氛条件下,没有发现CaS和CaSO₄组成的任意二元混合物存在共熔现象。对由不同比例组成的CaO、CaS、CaSO₄三元混合物进行类似的实验,结果表明,在700~1500℃的常压惰性气氛下,没有明显的证据证明存在三相共熔现象。

关键词: 共熔温度, CaSO₄, CaS, DTA

Abstract: In the process of direct hydrogen production from coal with CaSO₄ as oxygen carrier,CaS and CaSO₄ are used together at a high temperature.There is a dispute in literature whether an eutectic phenomenon occurs between them,although the melting points of them are above 1400℃.TG and DTA measurements of CaS,CaSO₄ mixtures with different molar ratios were performed using a atmospheric thermal analyzer under nitrogen atmosphere.The results showed that within 700℃ to 1300℃,the DTA curves of endothermic peaks within 850-1100℃ were due to the endothermic solid-solid reaction between CaS and CaSO₄.The temperatures when the first endothermic peak appeared and the temperatures when the fastest change of DTG curves happened were compared between different samples.No eutectic point was found,which meant eutectic phenomenon did not exist within 700-1300℃.Similar analyses were performed on CaO,CaS and CaSO₄ mixture samples,and no eutectic evidence was found within 700-1500℃.The conclusions above were also confirmed by the SEM analyses performed on the residue samples.

Key words: eutectic temperature, CaSO₄, CaS, DTA

中图分类号:

TK121

樊腾飞, 赵丽凤, 王波, 田文栋, 程晓磊, 肖云汉. CaS-CaSO₄是否共熔的DTA和TG实验研究[J]. 化工学报, 2013, 64(8): 2860-2866.

FAN Tengfei, ZHAO Lifeng, WANG Bo, TIAN Wendong, CHENG Xiaolei, XIAO Yunhan. DTA & TG measurement and analysis of CaS-CaSO₄ system[J]. CIESC Journal, 2013, 64(8): 2860-2866.

参考文献 16

[1]	Qin Cuijuan(秦翠娟),Shen Laihong(沈来宏),Zheng Min(郑敏),Xiao Jun(肖军).Experiments on reducing reaction for chemical looping combustion of coal with CaSO4 oxygen carrier[J].Proceedings of the CSEE(中国电机工程学报),2009, 29(17):43-50
[2]	Zheng Min(郑敏),Shen Laihong(沈来宏),Xiao Jun(肖军).Reduction of CaSO4 oxygen carrier with CO in chemical-looping combustion[J].Journal of Chemical Industry and Engineering(China)(化工学报),2008,59(11):2812-2818
[3]	Shen Laihong(沈来宏),Xiao Jun(肖军),Xiao Rui(肖睿),Zhang Hui(张辉).Chemical looping combustion of coal in interconnected fluidized beds of CaSO4 oxygen carrier[J].Proceedings of the CSEE(电机工程学报),2007,27(2):69-74
[4]	Zheng Ying(郑瑛),Wang Baowen(王保文),Song Kan(宋侃),Zheng Chuguang(郑楚光).The performance research on new oxygen carrier CaSO4 used in chemical-looping combustion[J].Journal of Engineering Thermophysics(工程热物理学报),2006,27(3):531-533
[5]	Fan Tengfei(樊腾飞),Cheng Xiaolei(程晓磊),Wang Bo(王波),Tian Wendong(田文栋),Xiao Yunhan(肖云汉).Simulation of CaO regeneration process with CaSO4 oxygen carrier[J].CIESC Journal(化工学报),2012,63(12):4055-4061
[6]	Kamphuis B,Potma A W,Prins W,Vanswaaij W P M. The reductive decomposition of calcium-sulfate(Ⅰ):Kinetics of the apparent solid-solid reaction[J].Chemical Engineering Science,1993,48(1):105-116
[7]	Davies N H,Hayhurst A N.On the formation of liquid melts of CaS and CaSO4 and their importance in the absorption of SO2 by CaO[J].Combustion and Flame,1996,106(3):359-362
[8]	Xiao Haiping(肖海平),Zhou Junhu(周俊虎),Liu Jianzhong(刘建忠),Cao Xinyu(曹欣玉),Fan Hongyu(范红宇),Cen Kefa(岑可法).Kinetics of reaction between CaS and CaSO4 under N2 atmosphere[J].Journal of Chemical Industry and Engineering(China)(化工学报),2005,56(7):1322-1326
[9]	Fuerstenau M C,Shen C M,Palmer B R.Liquidus temperature in the CaCO3-Ca(OH)2-CaO and CaCO3-CaSO4-CaS ternary systems[J].Industrial & Engineering Chemistry Process Design and Development,1981,20(3):441-445
[10]	Ren Nan(任楠),Wang Tao(王涛),Wu Yuting(吴玉庭),Ma Chongfang(马重芳).DSC measurement and specific heat analysis of mixed carbonates[J].CIESC Journal(化工学报),2011,62(S1):197-202
[11]	Freidina E B,Fray D J.Phase diagram of the system CaCl2-CaCO3[J].Thermochimica Acta,2000,351(1/2):107-108
[12]	Freidina E B,Fray D J.Study of the ternary system CaCl2-NaCl-CaO by DSC[J].Thermochimica Acta,2000,356(1/2):97-100
[13]	Coursol P,Pelton A D,Chartrand P,Zamalloa M.The CaSO4-Na2SO4-CaO phase diagram[J].Canadian Metallurgical Quarterly,2005,44(4):537-545
[14]	Xie Gang(谢刚).Theory and Application of Molten Salt(熔融盐理论与应用)[M].Beijing:Metallurgical Industry Press,1998:234
[15]	Lau K H,Cubicciotti D,Hildenbrand D L.Effusion studies of thermal-decomposition of magnesium and calcium sulfates[J].Journal of Chemical Physics,1977,66(10):4532-4539
[16]	Xiao Haiping(肖海平),Zhou Junhu(周俊虎),Cao Xinyu(曹欣玉),Fan Hongyu(范红宇),Fang Lei(方磊),Cen Kefa(岑可法).Experimental study of decomosition behavior of CaSO4 in different atmospheres[J].Power Engineering(动力工程),2004,24(6):889-892

CaS-CaSO₄是否共熔的DTA和TG实验研究

DTA & TG measurement and analysis of CaS-CaSO₄ system

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 16

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张红锐, 张田, 隆曦孜, 李先宁. 光催化与微生物燃料电池耦合对Cu-EDTA的降解特性[J]. 化工学报, 2022, 73(5): 2149-2157.
[2]	王宏杰, 高亚光, 赵子龙, 陈冠翰, 董文艺. 生物炭基催化剂制备对其催化降解Ni-EDTA性能影响[J]. 化工学报, 2018, 69(6): 2782-2789.
[3]	徐志明, 郭元杰, 韩志敏, 赵宇. 丁胞型圆管CaSO₄的污垢特性[J]. 化工学报, 2018, 69(4): 1341-1348.
[4]	王宏杰, 曹喆, 赵子龙, 董文艺. 微波-过氧化氢工艺处理含Cu-EDTA废水[J]. 化工学报, 2017, 68(12): 4756-4763.
[5]	徐志明, 韩志敏, 王景涛, 耿晓娅, 张一龙. 圆形楞涡流发生器结构对矩形通道内CaSO₄污垢沉积特性的影响[J]. 化工学报, 2015, 66(12): 4815-4822.
[6]	徐志明1，张一龙2，王冰洋1. 矩形楞涡流发生器CaSO4污垢特性[J]. 化工进展, 2014, 33(07): 1913-1918.
[7]	郑敏1，沈来宏2. CaSO4氧载体与CO反应中Boudouard反应的热力学分析及其抑制研究[J]. 化工进展, 2013, 32(12): 2846-2851.
[8]	张成明, 杜风光, 王欣, 毛忠贵, 孙沛勇, 唐蕾, 张建华. 酒精-沼气双发酵耦联工艺中丙酸对酿酒酵母酒精发酵的影响[J]. Chinese Journal of Chemical Engineering, 2012, 20(5): 942-949.
[9]	刘颖颖, 鲁厚芳, 蒋炜, 李东升, 刘世界, 梁斌. 微量酸催化麻疯树籽油制备生物柴油[J]. Chinese Journal of Chemical Engineering, 2012, 20(4): 740-746.
[10]	K.L. Lam, A.O. Oyedun, C.W. Hui. 生物质热裂解实验和模型研究[J]. CIESC Journal, 2012, 20(3): 543-550.
[11]	樊腾飞, 程晓磊, 王波, 田文栋, 肖云汉. 应用CaSO₄载氧体燃烧技术的CaO再生过程[J]. 化工学报, 2012, 63(12): 4055-4061.
[12]	徐立杰, 王淑莹, 甘冠雄, 陈祥东, 彭永臻. CAST工艺改良对系统强化除磷性能的影响 [J]. 化工学报, 2011, 62(5): 1402-1407.
[13]	孙付保, 毛忠贵, 张建华, 张宏建, 唐蕾, 张成明, 张静, 翟芳芳. Water-recycled Cassava Bioethanol Production Integrated with Two-stage UASB Treatment[J]. CIESC Journal, 2010, 18(5): 837-842.
[14]	赵月春, 易筱筠, 李明华, 刘露, 马伟娟. Biodegradation Kinetics of DDT in Soil under Different Environmental Conditions by Laccase Extract from White Rot Fungi[J]. CIESC Journal, 2010, 18(3): 486-492.
[15]	谢志宜, 陈能场, 刘承帅, 周建民, 徐胜光, 郑煜基, 李芳柏,徐燕玲. Synthesis and Characterization of Ethylenediamine Tetraacetic Acid Tetrasodium Salt Loaded in Microcapsules with Slow Release Properties[J]. CIESC Journal, 2010, 18(1): 149-155.