气流床气化炉的CPFD数值模拟

doi:10.11949/0438-1157.20190376

化工学报 ›› 2019, Vol. 70 ›› Issue (9): 3291-3299.DOI: 10.11949/0438-1157.20190376

气流床气化炉的CPFD数值模拟

梁咏诗¹(),赵香龙¹,秦强¹,郭屹¹(),程易²

1. 北京低碳清洁能源研究院，北京 102211
2. 清华大学化学工程系，北京 100084

收稿日期:2019-04-11 修回日期:2019-06-12 出版日期:2019-09-05 发布日期:2019-09-05
通讯作者: 郭屹
作者简介:梁咏诗（1987—），男，博士，liangyongshi@nicenergy.com

CPFD simulation on entrained-flow gasifier

Yongshi LIANG¹(),Xianglong ZHAO¹,Qiang QIN¹,Cliff Y GUO¹(),Yi CHENG²

1. National Institute of Clean-and-Low-Carbon Energy, Beijing 102211, China
2. Department of Chemical Engineering, Tsinghua University, Beijing 100084, China

Received:2019-04-11 Revised:2019-06-12 Online:2019-09-05 Published:2019-09-05
Contact: Cliff Y GUO

摘要/Abstract

摘要：

利用CPFD(computational particle fluid dynamics)模拟方法对三维、全尺寸的气流床气化炉进行了模拟计算，建立起了适用于CPFD模拟方法的气化模拟模型。模拟结果与实验数据相一致，说明模型基本准确且CPFD模拟方法适用于气流床气化过程的模拟。借由CPFD模拟方法给出了颗粒相在气化炉中的具体反应历程及颗粒停留时间的概率分布；结果表明，在单喷嘴顶喷的气化炉中，同时存在颗粒相的轴向流动短路及返混，短路主要发生在炉中心区域；颗粒在炉中心区域反应剧烈而边壁区域反应则很缓慢，而且从气化炉流出的第一股短路颗粒主要由充分反应了的粉煤颗粒构成。

关键词: 气流床, 气化炉, CPFD模拟, 气化反应, 颗粒停留时间

Abstract:

For the first time, the three-dimensional, full-size entrained flow gasifier was simulated by CPFD（computational particle fluid dynamics） simulation method, and a gasification simulation model suitable for CPFD simulation was established. This validated the model and CPFD simulation used in entrained-flow gasification. The detailed reaction process and the probability distribution of particle residence time were obtained through CPFD simulation. The results show that both particle short-circuit and re-circulation exist in the gasifier using single burner at top. The short-circuit flow is mainly located at the central region of the gasifier. In addition, the particle reaction rate is very fast in the central region but relatively slow near the wall region. Besides, the first amount of particles flowing out of the gasifier mainly consists of the fully-reacted particles.

Key words: entrained-flow, gasifier, CPFD simulation, gasification process, particle residence time

中图分类号:

TQ 54

梁咏诗, 赵香龙, 秦强, 郭屹, 程易. 气流床气化炉的CPFD数值模拟[J]. 化工学报, 2019, 70(9): 3291-3299.

Yongshi LIANG, Xianglong ZHAO, Qiang QIN, Cliff Y GUO, Yi CHENG. CPFD simulation on entrained-flow gasifier[J]. CIESC Journal, 2019, 70(9): 3291-3299.

参考文献 23

1	吴玉新, 张建胜, 王明敏, 等 . 简化PDF模型对Texaco气化炉的三维数值模拟[J]. 化工学报, 2007, 58(9): 2369-2374.
	Wu Y X , Zhang J S , Wang M M , et al . 3D numerical simulation of Texaco gasifier using assumed PDF model[J]. Journal of Chemical Industry and Engineering (China), 2007, 58(9): 2369-2374.
2	Wu Y , Zhang J , Smith P , et al . Three-dimensional simulation for an entrained flow coal slurry gasifier[J]. Energy & Fuels, 2010, 24(2): 1156-1163.
3	毕大鹏, 管清亮, 玄伟伟, 等 . 基于双组分PDF模型的GSP气化炉数值模拟[J]. 化工学报, 2014, 65(10): 3753-3759.
	Bi D P , Guan Q L , Xuan W W , et al . Numerical simulation of GSP gasifier based on double-mixture fractions PDF model[J]. CIESC Journal, 2014, 65(10): 3753-3759.
4	Sun Z , Dai Z , Zhou Z , et al . Numerical simulation of industrial opposed multiburner coal-water slurry entrained flow gasifier[J]. Industrial & Engineering Chemistry Research, 2012, 51(6): 2560-2569.
5	Abani N , Ghoniem F A . Large eddy simulations of coal gasification in an entrained flow gasifier[J]. Fuel, 2013, 104(2): 664-680.
6	Snider D M . An incompressible three-dimensional multiphase particle-in-cell model for dense particle flows[J]. Journal of Computational Physics, 2001, 170(2): 523-549.
7	Deen N G , Annaland M V S , Hoef M A V D , et al . Review of discrete particle modeling of fluidized beds[J]. Chemical Engineering Science, 2007, 62(1): 28-44.
8	Snider D M , Clark S M , O’Rourke P J . Eulerian-Lagrangian method for three-dimensional thermal reacting flow with application to coal gasifiers[J]. Chemical Engineering Science, 2011, 66(6): 1285-1295.
9	Yan L , Cao Y , Zhou H , et al . Investigation on biomass steam gasification in a dual fluidized bed reactor with the granular kinetic theory[J]. Bioresource Technology, 2018, 269: 384-392.
10	Kraft S , Kirnbauer F , Hofbauer H . CPFD simulations of an industrial-sized dual fluidized bed steam gasification system of biomass with 8MW fuel input[J]. Applied Energy, 2017, 190: 408-420.
11	Brown B W , Smoot L D , Smith P J , et al . Measurement and prediction of entrained-flow gasification processes[J]. AIChE Journal, 1988, 34(3): 435-446.
12	Liang Y , Zhang Y , Li T , et al . A critical validation study on CPFD model in simulating gas-solid bubbling fluidized beds[J]. Powder Technology, 2014, 263: 121-134.
13	Liang Y , Zhang Y , Lu C . CPFD simulation on wear mechanisms in disk-donut FCC strippers[J]. Powder Technology, 2015, 279: 269-281.
14	Wen C Y , Chaung T Z . Entrainment coal gasification modeling[J]. Ind. & Eng. Process Des. Dev., 1979, 18(4): 684-695.
15	Badzioch S , Hawksley P G W , Badzioch S , et al . Kinetics of thermal decomposition of pulverized coal particles[J]. Ind. & Eng. Chem. Process Des. Dev., 1970, 9(4): 684-695.
16	Monson C R , Germane G J , Blackham A U , et al . Char oxidation at elevated pressures[J]. Combustion & Flame, 1995, 100(4): 669-683.
17	Roberts D G , Harris D J . Char gasification with O₂, CO₂, and H₂O: effects of pressure on intrinsic reaction kinetics[J]. Energy Fuels, 2000, 14(2): 483-489.
18	Fang W . Study on reaction kinetic of steam-coal chars gasification with TGA[J]. Journal of China Coal Society, 2004, 29: 350-353.
19	Andersen J , Rasmussen C L , Giselsson T , et al . Global combustion mechanisms for use in CFD modeling under oxy-fuel conditions[J]. Energy & Fuels, 2009, 23(3): 1379-1389.
20	Yan L , Lim C J , Yue G , et al . Simulation of biomass-steam gasification in fluidized bed reactors: model setup, comparisons and preliminary predictions[J]. Bioresource Technology, 2016, 221: 625-635.
21	Gómez-Barea A , Leckner B . Modeling of biomass gasification in fluidized bed[J]. Progress in Energy & Combustion Science, 2010, 36(4): 444-509.
22	Umeki K , Yamamoto K , Namioka T , et al . High temperature steam-only gasification of woody biomass[J]. Applied Energy, 2010, 87(3): 791-798.
23	Smagorinsky J S . General circulation experiments with the primitive equations[J]. Monthly Weather Review, 1963, 91: 99-164.

[1]	仇鹏, 韩洋, 许建良, 王辅臣, 代正华. 用于预测气流床煤气化的EDC模型参数研究[J]. 化工学报, 2023, 74(1): 428-437.
[2]	姚源朝, 仇鹏, 许建良, 代正华, 刘海峰. 基于混合模型的气流床气化炉建模[J]. 化工学报, 2021, 72(5): 2727-2734.
[3]	刘洁妤, 龚岩, 吴晓翔, 郭庆华, 于广锁, 王辅臣. 多喷嘴对置式气化炉内颗粒挥发分火焰可视化研究[J]. 化工学报, 2021, 72(3): 1275-1282.
[4]	程晨, 薛志村, 郭庆华, 龚岩, 于广锁. 撞击气流床气化炉内雾化过程中颗粒运动特性[J]. 化工学报, 2019, 70(12): 4536-4545.
[5]	玄伟伟, 张建胜, 夏德宏. 非牛顿煤灰配渣的结晶特性[J]. 化工学报, 2016, 67(6): 2612-2617.
[6]	邢康，唐庆杰，练佳佳，张立恒. 秸秆灰对煤焦气化反应性的影响[J]. 化工进展, 2014, 33(03): 651-654.
[7]	李璐伶，诸林，范峻铭. GE水煤浆气化炉动力学建模与分析[J]. 化工进展, 2014, 33(02): 314-318.
[8]	邵迪, 代正华, 于广锁, 龚欣, 王辅臣. 固定床气化与气流床水煤浆气化集成的能量与经济分析[J]. 化工学报, 2013, 64(6): 2186-2193.
[9]	吴玉新蔡春荣张建胜岳光溪吕俊复. 二次氧量对分级气化炉气化特性的影响[J]. 化工学报, 2012, 63(2): 369-374.
[10]	刘兵，田靖. 煤质对气流床煤气化的影响研究进展[J]. 化工进展, 2012, 31(10): 2191-2196.
[11]	王艳1，2，陈文义1，2，孙姣1，2，石海波1，2，陈晓东3. 国内外生物质气化设备研究进展[J]. 化工进展, 2012, 31(08): 1656-1664.
[12]	朱有健, 王定标, 周俊杰. 固定床煤气化炉的模拟与优化[J]. 化工学报, 2011, 62(6): 1606-1611.
[13]	孙漾;张凌波;顾幸生 . Texaco水煤浆气化装置配煤模型及其优化 [J]. CIESC Journal, 2010, 61(8): 1965-1970.
[14]	刘升, 郝英立, 杜敏, 陶明春. 气流床煤气化炉壁面反应模型 [J]. 化工学报, 2010, 61(5): 1219-1225.
[15]	颜世森, 梁钦锋, 周志杰, 于广锁. 多喷嘴对置式水煤浆气化炉内火焰声学特性分析 [J]. 化工学报, 2009, 60(5): 1245-1253.

气流床气化炉的CPFD数值模拟

CPFD simulation on entrained-flow gasifier

RichHTML

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 23

相关文章 15

编辑推荐

Metrics

本文评价