Experimental investigation on refrigeration performance of R290 linear compressor

doi:10.11949/j.issn.0438-1157.20181060

CIESC Journal ›› 2018, Vol. 69 ›› Issue (S2): 480-484.DOI: 10.11949/j.issn.0438-1157.20181060

Previous Articles Next Articles

Experimental investigation on refrigeration performance of R290 linear compressor

ZOU Huiming^1,2, LI Xuan^1,2,3, TANG Mingsheng^1,2, SHAO Shuangquan^1,2, TIAN Changqing^1,2,3

1 Key Laboratory of Cryogenics, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing 100190, China;
2 Beijing Key Laboratory of Thermal Science and Technology, Technical Institute of Physics and Chemistry, Chinese Academy of Sciences, Beijing 100190, China;
3 University of Chinese Academy of Sciences, Beijing 100049, China

Received:2018-09-25 Revised:2018-10-16 Online:2018-12-31 Published:2018-12-31
Supported by:
supported by the National Key Research and Development Program of China (2016YFD0400905) and the National Natural Science Foundation of China (51576203， 51505466).

R290工质直线压缩机的性能实验研究

邹慧明^1,2, 李旋^1,2,3, 唐明生^1,2, 邵双全^1,2, 田长青^1,2,3

1 中国科学院低温工程学重点实验室(理化技术研究所), 北京 100190;
2 热力过程节能技术北京市重点实验室(中国科学院理化技术研究所), 北京 100190;
3 中国科学院大学, 北京 100049

通讯作者: 唐明生
基金资助:
国家重点研发计划项目（2016YFD0400905）；国家自然科学基金项目（51576203，51505466）。

Abstract

Abstract:

According to the cooling demand of commercial refrigerator, an R290 linear compressor is developed and the experimental investigation on its cooling performance is carried out. The experimental results show that cooling capacity and COP of the linear compressor are 604 W and 1.42 on the rating conditions. Its COP decreases with the decreasing of cooling capacity and the COP is just about 1.02 with 40% cooling capacity. As the power frequency is lower than the nature frequency of linear compressor, cooling capacity and COP decreases greatly. The analysis on power consumption indicates that it is necessary to enhance the linear motor performance and reduce the gap between the piston and cylinder to improve the efficiency of linear compressor.

摘要：

根据R290工质的商业冷柜的制冷需求，开发了直线压缩机样机，开展了国标工况下的制冷性能实验研究。实验结果显示，直线压缩机样机在供电电压145 V，频率70.2 Hz条件下，制冷量为604 W，制冷COP为1.42，部分负荷制冷COP会发生一定的衰减，负荷率越低衰减越大，40%制冷量时COP仅为1.02。降低供电频率导致其与固有频率的偏离增大时，制冷量和COP也出现了较大的衰减。功耗分析表明，为提高直线压缩机能效，需要从直线电机的性能系数和降低活塞与气缸配合间隙两方面同时进行优化。

CLC Number:

TH457

ZOU Huiming, LI Xuan, TANG Mingsheng, SHAO Shuangquan, TIAN Changqing. Experimental investigation on refrigeration performance of R290 linear compressor[J]. CIESC Journal, 2018, 69(S2): 480-484.

邹慧明, 李旋, 唐明生, 邵双全, 田长青. R290工质直线压缩机的性能实验研究[J]. 化工学报, 2018, 69(S2): 480-484.

References

[1] 刘英志, 刘业凤, 卞伟,等.R290制冷剂在商用冷柜上的应用研究[J].制冷技术, 2012,32(1):58-60.LIU Y Z, LIU Y F, BIAN W, et al.Refrigerant performance study on R290 used in commercial refrigerators[J].Chinese Journal of Refrigeration Technology, 2012, 32 (1):58-60.
[2] 钟志锋, 胡杰浩, 冯卉,等.碳氢制冷剂在小型商用冷柜上应用分析[J].制冷学报, 2015,36(2):8-13.ZHONG Z F, HU J H, FENG H, et al.The application analysis of hydrocarbons as refrigerants on small commercial freezers[J].Journal of Refrigeration, 2015, 36(2):8-13.
[3] 叶俊荣.R290制冷剂在商用冷柜中的应用[J].化工管理, 2015,(15):72-74.YE J R.Application of refrigerant R290 in commercial refrigerators[J].Chemical Enterprise Management, 2015,(15):72-74.
[4] MOHANRAJ M, JAYARAJ S, MURALEEDHARAM C, et al.Experimental investigation of R290/R600a mixture as an alternative to R134a in a domestic refrigerator[J].International Journal of Thermal Sciences, 2009, 48(5):1036-1042.
[5] COLBOURNE D, ESPERSEN L.Quantitative risk assessment of R290 in ice cream cabinets[J].International Journal of Refrigeration, 2013, 36(4):1208-1219.
[6] 钱文波,晏刚,冯永斌,等.丙烷和丙烯用于低温冷柜的性能和充灌量研究[J].西安交通大学学报, 2009,43(9):104-108.QIAN W B, YAN G, FENG Y B, et al.Performance and charge analysis of propane and propylene used in low temperature cabinet freezers[J].Journal of Xi'an Jiaotong University, 2009,43(9):104-108.
[7] 宁静红, 刘圣春, 李慧宇.自然工质R290管内凝结换热特性的数值模拟[J].化工学报, 2012, 63(4):1038-1043.NING J H, LIU S C, LI H Y.Simulation on condensation heat transfer characteristic of natural refrigerant R290 inside tube[J].CIESC Journal, 2012, 63(4):1038-1043.
[8] CHEN Q, YAN G, YU J.Performance analysis of an ejector enhanced refrigeration cycle with R290/R600a for application in domestic refrigerator/freezers[J].Applied Thermal Engineering, 2017, 120(25):581-592.
[9] CAI D, HE G, YOKOYAMA T, et al.Simulation and comparison of leakage characteristics of R290 in rolling piston type rotary compressor[J].International Journal of Refrigeration, 2015, 53:42-54.
[10] 戴源德,林秦汉,邹思凯,等.R290在水平光滑管内的沸腾换热[J].化工学报, 2017, 68(9):3420-3426.DAI Y D, LIN Q H, ZOU S K, et al.Boiling heat transfer performances of R290 in smooth horizontal tubes[J].CIESC Journal, 2017, 68(9):3420-3426.
[11] WU J, LIN J, ZHANG Z, et al.Experimental investigation of dynamic characteristics of a rotary compressor and its air conditioner using R290 during warm startup[J].Applied Thermal Engineering, 2017, 125:1469-1477.
[12] WU J H, CHEN A.A new structure and theoretical analysis on leakage and performance of an oil-free R290 rolling piston compressor[J].International Journal of Refrigeration, 2015, 49:110-118.
[13] 彭惠兰, 胡荣枝, 孙继勇,等.R290工质大规格节能型冷柜用制冷压缩机研究[J].家电科技, 2009, (9):59-60.PENG H L, HU R Z, SUN J Y, et al.Research on R290 compressor for large refrigerators[J].Journal of Appliance Science and Technology, 2009, (9):59-60.
[14] LEE H, KI S, JUNG S, et al.The innovative green technology for refrigerators development of innovative linear compressor[C]//International Compressor Engineering Conference in Purdue University.2008:Paper 1867.
[15] 邹慧明, 唐明生, 徐洪波,等.电冰箱用线性压缩机的控制系统[J].化工学报, 2014, 65(S2):175-180.ZOU H M, TANG M S, XU H B, et al.Investigation on the control system of linear compressor for refrigerator[J].CIESC Journal, 2014, 65(S2):175-180.
[16] ZOU H M, ZHANG L Q, PENG G H, et al.Experimental investigation and performance analysis of a dual-cylinder opposed linear compressor[J].Journal of Mechanical Science & Technology, 2011, 25(8):1885-1892.
[17] ZOU H M, LI C, TANG M S, et al.Online measuring method and dynamic characteristics of gas kinetic parameters of linear compressor[J].Measurement, 2018,125:545-553.

Experimental investigation on refrigeration performance of R290 linear compressor

R290工质直线压缩机的性能实验研究

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 1

Recommended Articles

Metrics

Comments