Characteristics of two-stage segregation auto-cascade refrigeration system

doi:10.3969/j.issn.0438-1157.2013.06.018

CIESC Journal ›› 2013, Vol. 64 ›› Issue (6): 2029-2035.DOI: 10.3969/j.issn.0438-1157.2013.06.018

Previous Articles Next Articles

Characteristics of two-stage segregation auto-cascade refrigeration system

RUI Shengjun^1,2, ZHANG Hua¹, ZHANG Qinggang¹, HUANG Lihao¹

1. Institute of Refrigeration Technology, University of Shanghai for Science and Technology, Shanghai 200093, China;
2. Vehicle & Motive Power Engineering College, Henan University of Science and Technology, Luoyang 471023, Henan, China

Received:2012-09-23 Revised:2012-10-09 Online:2013-06-05 Published:2013-06-05
Supported by:
supported by the National Natural Science Foundation of China(51176124),the Shanghai Outstanding Subject Leaders Project(10XD1403100)and the Shanghai Leading Academic Discipline Project(S30503).

两级分凝自复叠制冷系统特性

芮胜军^1,2, 张华¹, 张庆钢¹, 黄理浩¹

1. 上海理工大学制冷技术研究所,上海 200093;
2. 河南科技大学车辆与动力工程学院,河南洛阳 471023

通讯作者: 芮胜军(1975—),男,博士研究生,讲师。
作者简介:芮胜军(1975—),男,博士研究生,讲师。
基金资助:
国家自然科学基金项目(51176124);上海市优秀学科带头人项目(10XD1403100);上海市重点学科建设项目(S30503)。

Abstract

Abstract: A two-stage segregation auto-cascade refrigeration system was studied.The vapor-liquid equilibrium characteristics of a ternary mixed-refrigerant, composition change rules and operating characteristics of the ternary system were investigated.Refprop 8.0, general software for mixed-refrigerant property analysis with abroad applications, was used.The composition proportion of mixed-refrigerant was discussed according to the cooling capacity balance characteristics of evaporative condense and a reasonable proportion was obtained.The separation, mixing and operating characteristics of auto-cascade refrigeration system mixed-refrigerant were analyzed on the basis of spatial changes of five plane pressure-enthalpy diagrams.According to the experimental research, high-low pressure bypass and phase separator outlet vapor bypass of circulatory system could effectively improve the high discharge pressure and discharge temperature in the starting process.The throttle cooling process of each stage was analyzed, and the suction and discharge temperatures and evaporative temperature of compressor were studied.

Key words: auto-cascade refrigeration, mixed refrigerant, segregation cycle, single-stage compression

摘要： 以两级分凝自复叠制冷系统为研究对象,分析了三元混合工质空间和平面汽液平衡特性,对三元混合工质的组分变化规律及运行特性进行了理论研究。应用混合工质物性分析软件Refprop 8.0根据冷凝蒸发器冷量平衡特性讨论了混合工质组分比例,得到比较合理的配比组成65/20/15。通过5个平面压焓图的空间变化关系分析了自复叠制冷系统工质分离、混合和运行特性。根据实验研究,循环系统高低压旁通和相分离器出口气体旁通可有效改善压缩机启动初期系统压力和温度过高的问题。对系统各级节流降温过程进行了分析,并对压缩机的吸排气温度和蒸发温度进行了研究。

关键词: 自复叠制冷, 混合工质, 分凝循环, 单级压缩

CLC Number:

TB657.3

RUI Shengjun, ZHANG Hua, ZHANG Qinggang, HUANG Lihao. Characteristics of two-stage segregation auto-cascade refrigeration system[J]. CIESC Journal, 2013, 64(6): 2029-2035.

芮胜军, 张华, 张庆钢, 黄理浩. 两级分凝自复叠制冷系统特性[J]. 化工学报, 2013, 64(6): 2029-2035.

References 15

[1]	Zhang Yu(张宇), Gong Maoqiong(公茂琼), Wu Jianfeng(吴剑峰).Vapor-liquid equilibrium measurement and correlation for R23+R116 system[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2008,59(2):269-275
[2]	Dale J Missimer.Refrigerant conversion of auto- refrigerating cascade(ARC)systems[J].International Journal of Refrigeration, 1997,20(3):201-207
[3]	Lai Fen(赖芬), Wu Yuyuan(吴裕远), Ouyang Qianwu(欧阳前武), et al.Theoretical research on a new partial auto-cascade heat pump[J].Journal of Xi'an Jiaotong University(西安交通大学学报), 2012,46(3):15-20
[4]	Kim S G,Kim M S.Experiment and simulation on the performance of an auto-cascade refrigeration system using carbon dioxide as a refrigerant[J].International Journal of Refrigeration, 2002,25:1093-1101
[5]	Gurudath Nayak H, Venkatarathnam G.Performance of an auto refrigerant cascade refrigerator operating in liquid refrigerant supply(LRS)mode with different cascade heat exchangers[J].Cryogenics, 2010,50:720-727
[6]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰), Gong Zhengfeng(贡征峰), et al.Performance of cascade refrigeration with liquid refrigerant by-pass[J].Journal of Mechanical Engineering Cryogenics(机械工程学报), 2007,43(8):192-197
[7]	Du Kai,Zhang Shaoqian, Xu Weirong, et al.A study on the cycle characteristics of an auto-cascade refrigeration system[J].Experimental Thermal and Fluid Science, 2009,33:240-245
[8]	Xu Weirong(徐卫荣), Du Kai(杜垲).Thermal performance analysis of auto-cascade heat pump circular system[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2008,59(S2):230-234
[9]	Tao Kai(陶锴), Yan Gang(晏刚), Zhang Min(张敏), et al.A novel auto-cascade heat pump with intermediate pressure adjustment[J].Journal of Xi'an Jiaotong University(西安交通大学学报), 2010,44(9):43-47
[10]	Gong M Q,Wu J F,Luo E C.Performances of the mixed-gases Joule-Thomson refrigeration cycles for cooling fixed-temperature heat loads[J].Cryogenics, 2004,44:847-857
[11]	Alexandrow A A,Crigoriev B A,Ustjuzhanin E E, et al.Some modelling of cooling cycles used in individual and mixed refrigerants[J].Fluid Phase Equilibria, 2000,174:178-189
[12]	Eric W Lemmo, Reiner Tillner-Roth.A Helmholtz energy equation of state for calculating the thermodynamic properties of fluid mixtures[J].Fluid Phase Equilibria, 1999,165:1-21
[13]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰).Experimental study on starting characteristic of cascade refrigeration system[J].Cryogenics(低温工程), 2009(5):51-54
[14]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰).Experiment on concentration ratio of CO2/R290 in low-temperature circuit of cascade refrigeration[J].Journal of Refrigeration(制冷学报), 2010,31(1):35-38
[15]	Gong Maoqiong, Wu Jianfeng, Luo Ercang.Study of the single-stage mixed-gases refrigeration cycle for cooling temperature-distributed heat loads[J].International Journal of Thermal Sciences, 2004,43:31-41

Characteristics of two-stage segregation auto-cascade refrigeration system

两级分凝自复叠制冷系统特性

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 15

Related Articles 14

Recommended Articles

Metrics

Comments

[1]	Yingying TAN, Xiaoqing LIU, Lin WANG, Lisheng HUANG, Xiuzhen LI, Zhanwei WANG. Experimental study on startup dynamic characteristics of R1150/R600a auto-cascade refrigeration cycle [J]. CIESC Journal, 2023, 74(S1): 213-222.
[2]	Yukun SUN, Tao YANG, Jiangtao WU. Measurement of vapor-liquid equilibrium for R32+R1234yf+R1234ze(E) [J]. CIESC Journal, 2022, 73(3): 1063-1071.
[3]	LUO Jielin, YANG Kaiyin, ZHAO Zhen, WANG Qin, CHEN Guangming. Heating performance of recuperative heat pump using low-GWP mixed refrigerant [J]. CIESC Journal, 2021, 72(S1): 84-90.
[4]	PAN Yaochi, LIU Jinping, XU Xiongwen, FU Zhiming. Component concentration optimization analysis of cooling process and control strategy in auto-cascade refrigeration system [J]. CIESC Journal, 2017, 68(8): 3152-3160.
[5]	TAN Yingying, WANG Lin, BAI Depo, YAN Xiaona. Performance of R23/R134a auto-cascade refrigeration cycle with one-step dephlegmation and two-step dephlegmation [J]. CIESC Journal, 2016, 67(S2): 107-112.
[6]	CAO Le, LIU Jinping, XU Xiongwen, LI Rixin. Overall heat transfer coefficient of plate-fin heat exchanger during a mixed refrigerant cryogenic process in low quality [J]. CIESC Journal, 2016, 67(4): 1277-1286.
[7]	JIA Rong, LIN Wensheng. Influence of heavy hydrocarbons in mixed refrigerant on natural gas liquefaction processes [J]. CIESC Journal, 2015, 66(S2): 379-386.
[8]	WANG Hui, CHEN Fusheng, SONG Qi, REN Bin, WANG Qin, CHEN Guangming. Performance optimizations on a new small scale auto-cascade natural gas liquefier using a rectifying column [J]. CIESC Journal, 2015, 66(S2): 231-237.
[9]	PAN Hongyu, LI Yuxing, ZHU Jianlu. Sensibility analysis of feed gas in propane pre-cool mixed refrigerant liquefaction process feed gas [J]. CIESC Journal, 2015, 66(S2): 186-191.
[10]	ZHANG Qingqing, ZHANG Hua, LOU Jiangfeng, LI Jia, ZHAO Wei, WANG Xi, LIU Zhanjie. Construction and application for VLE and pressure-enthalpy diagrams of R134a/R23/R14 zeotropic mixtures [J]. CIESC Journal, 2015, 66(7): 2387-2394.
[11]	REN Bin, CHEN Fusheng, WANG Hui, SONG Qi, WANG Qin, XU Xiangguo, CHEN Guangming. Concentration optimizations on small scale auto-cascade natural gas liquefier using rectifying column [J]. CIESC Journal, 2014, 65(z2): 169-174.
[12]	XIE Na, LIU Jinping, XU Xiongwen, CAO Le. Design and optimization of refrigeration separation system for variable-temperature cooling process in ethylene cryogenic separation process [J]. CIESC Journal, 2013, 64(10): 3590-3598.
[13]	RUI Shengjun, ZHANG Hua, HUANG Lihao. Pressure characteristics of auto-cascade refrigeration system [J]. CIESC Journal, 2012, 63(S2): 176-180.
[14]	ZHAO Bairen，LI Guanghua，WANG Jianmin. Setting of superheated extent of refrigerant vapor and its influence on system design in ethylene plants [J]. , 2007, 26(7): 964-.