Effect of carrier gas flow rate and heating rate on thermal desorption of polychlorinated biphenyls in contaminated soil

doi:10.3969/j.issn.0438-1157.2014.06.041

CIESC Journal ›› 2014, Vol. 65 ›› Issue (6): 2256-2263.DOI: 10.3969/j.issn.0438-1157.2014.06.041

Previous Articles Next Articles

Effect of carrier gas flow rate and heating rate on thermal desorption of polychlorinated biphenyls in contaminated soil

BAI Sihong, CHEN Tong, QI Zhifu, LIU Jie, LU Shengyong, BO Zheng, LI Xiaodong

State Key Laboratory of Clean Energy Utilization, Institute for Thermal Power Engineering, Zhejiang University, Hangzhou 310027, Zhejiang, China

Received:2013-09-06 Revised:2013-11-21 Online:2014-06-05 Published:2014-06-05
Supported by:
supported by the National Basic Research Program of China (2011CB201500) and the National High Technology Research and Development Program of China (2009AA061304).

载气流量及升温速率对污染土壤中多氯联苯热脱附的影响

白四红, 陈彤, 祁志福, 刘洁, 陆胜勇, 薄拯, 李晓东

浙江大学热能工程研究所能源清洁利用国家重点实验室, 浙江杭州 310027

通讯作者: 陈彤
作者简介:白四红（1990- ），男，硕士研究生
基金资助:
国家重点基础研究发展计划项目（2011CB201500）；国家高技术研究发展计划项目（2009AA061304）。

Abstract

Abstract: A real soil contaminated by high concentration polychlorinated biphenyl (PCBs) was heated in a tube furnace at various carrier gas flow rate and at various heating rate to investigate their effect on thermal desorption of PCBs in contaminated soil. With the rising of carrier gas flow rate, a slight increase of PCBs removal efficiency (from 93.5% to 95.1%) and toxic equivalency quantity (TEQ) in soil were observed. With increase of the flow rate desorption amount of PCBs was obvious large when it was lower than 400 ml·min^-1, then a little chang at >400 ml·min^-1, while TEQ of PCBs showed a trend of linear increase with the rising of flow rate. The TEQ of polychlorinated dibenzo-p-dioxin/dibenzofuran (PCDD/Fs) in treated soil decreased, while in carrier gas a large increase of TEQ of PCDD/Fs especially PCDFs was observed.The removal rate of PCBs in soil showed a significant positive linear relationship with the heating rate. With the rising of heating rate, the removal efficiency of PCBs in soil increased, and the TEQ of PCBs had a little change. The desorption amount of PCBs decreased. The TEQ removal efficiency of PCDD/Fs increased. After thermal desoption there was significant formation of PCDD/Fs while there was TEQ high increase of PCDD/Fs. Generally, the effect of flow rate on the removal efficiency of PCBs in soil was less but on the desorption amount of PCBs was significant. Higher heating rate can make a better removal efficiency of PCBs and lower formation of PCDD/Fs.

Key words: thermal desorption, carrier gas flow rate, residue time, heating rate, polychlorinated biphenyls (PCBs), polychlorinated dibenzo-p-dioxin/dibenzofuran (PCDD/Fs), thermal degradation

摘要： 利用小型管式炉进行了载气流量和升温速率对多氯联苯污染土壤的热脱附过程影响的实验研究。结果表明流量的增大对多氯联苯含量和毒性当量的去除效率影响不大，载气流量小于400 ml·min^-1时，气相中的脱附量明显增大，载气流量大于400 ml·min^-1则脱附量变化较小，而多氯联苯的毒性当量则随着载气流量增大呈线性增加趋势。实验结果还表明污染土壤中多氯联苯变化速率与升温速率呈明显的正线性相关，随着升温速率增加，污染土壤中多氯联苯去除效率总体呈上升趋势，毒性当量去除效率降低。总体结果分析可以看到升温速率越大，总体效果也越好。污染土壤经热脱附处理后气固相的二英毒性当量则有不同程度提升，尤其气相内检测到了大量多氯二苯并呋喃生成。

关键词: 热脱附, 载气流量, 停留时间, 升温速率, 多氯联苯, 二英, 热降解

CLC Number:

BAI Sihong, CHEN Tong, QI Zhifu, LIU Jie, LU Shengyong, BO Zheng, LI Xiaodong. Effect of carrier gas flow rate and heating rate on thermal desorption of polychlorinated biphenyls in contaminated soil[J]. CIESC Journal, 2014, 65(6): 2256-2263.

白四红, 陈彤, 祁志福, 刘洁, 陆胜勇, 薄拯, 李晓东. 载气流量及升温速率对污染土壤中多氯联苯热脱附的影响[J]. 化工学报, 2014, 65(6): 2256-2263.

References 23

[1]	Que Mingxue(阙明学). The distribution and source apportionment of PCBs contaminated in soil [D]. Harbin: Harbin Engineering University, 2007
[2]	Cao Xianzhong(曹先仲), Shen Songmei(申松梅), Song Yanhui(宋艳辉), Lian Xiaoying(连小英). The nature and environmental impact of PCBs [J]. Sciencepaper Online(中国科技论文在线), 2008, 3(5): 375-381
[3]	Kang Zhuangwu(康壮武), Shu Shenghui(舒生辉), Zhang Zhi(张志). Research progress in chemical treatment of PCBs [J]. Guangxi Journal of Light Industry(广西轻工业), 2010(7): 23-24
[4]	Hu Fang(胡芳), Xu Zhencheng(许振成). Pollution of PCBs in environment media in China [J]. Guangdong Chemical Industry(广东化工), 2009, 39(1): 87-88
[5]	Hu Jinzhao(胡劲召), Chen Shaojin(陈少瑾), Wu Shuangtao(吴双桃), Chen Yifei(陈宜菲), Xie Ningzi(谢凝子). The contaminant of PCBs and treatment methods progress [J]. Jiangxi Chemical Industry(江西化工), 2004(4): 1-5
[6]	Meng Qingyu(孟庆昱), Chu Shaogang(储少岗), Xu Xiaobai(徐晓白). Research of the adsorption behavior of PCBs in the environment [J]. Chinese Science Bulletin(科学通报), 2000, 45(12): 1572-1583
[7]	Izadifard M, Achari G, Langford C H. The pathway of dechlorination of PCB congener by a photochemical chain process in 2-propanol: the role of medium and quenching [J]. Chemosphere, 2008, 73(8): 1328-1334
[8]	Varanasi P, Fullana A, Sidhu S. Remediation of PCB contaminated soils using iron nano-particles [J]. Chemosphere, 2007, 66(6): 1031-1038
[9]	Application guide for thermal desorption systems: Naval Facilities Engineering Service Center[R]. 1998: 3-16
[10]	Xing Ying(邢颖), Lü Yonglong(吕永龙), Shi Yajuan(史雅娟), Zhang Hong(张红), Wang Tieyu(王铁宇), He Guizhen(贺桂珍). Analysis on the research status of PCDD/Fs and PCBs in China and the strategies [J]. Environmental Protection Science(环境保护科学), 2006(5): 33-35
[11]	Zhao Yi(赵毅), Shen Yanmei(沈艳梅), Ma Xiaoying(马萧颖). Application of thermal desorption technology in remediation of soil polluted by PCBs [J]. Electric Power Environmental Protection, 2009, 25(2):57-59
[12]	Risoul V, Renauld V, Trouvé G, Gilot P. A laboratory pilot study of thermal decontamination of soils polluted by PCBs. Comparison with thermogravimetric analysis[J]. Waste Manag., 2002, 22(1): 61-72
[13]	Aresta M, Dibenedetto A, Fragale C, Giannoccaro P, Pastore C, Zammiello D, Ferragina C. Thermal desorption of polychlorobiphenyls from contaminated soils and their hydrodechlorination using Pd-and Rh-supported catalysts [J]. Chemosphere, 2008, 70(6): 1052-1058
[14]	Sato T, Todoroki T, Shimoda K, Terada A, Hosomi M. Behavior of PCDDs/PCDFs in remediation of PCBs-contaminated sediments by thermal desorption[J]. Chemosphere, 2010, 80(2): 184-189
[15]	Weber R. Relevance of PCDD/PCDF formation for the evaluation of POPs destruction technologies-review on current status and assessment gaps [J]. Chemosphere, 2007, 67(9): 109-117
[16]	Zhao L, Hou H, Shimoda K, Terada A, Hosomi M. Formation pathways of polychlorinated dibenzofurans (PCDFs) in sediments contaminated with PCBs during the thermal desorption process [J]. Chemosphere, 2012, 88(11): 1368-1374
[17]	Chen T, Li X, Yan J, Jin Y. Polychlorinated biphenyls emission from a medical waste incinerator in China [J]. J. Hazard. Mater., 2009, 172(2-3): 1339-1343
[18]	U.S. Environmental Protection Agency. Method 1613 Tetra-through Octa-Chlorinated Dioxins and Furans by Isotope Dilution HRGC/HRMS [S].1994
[19]	U.S. Environmental Protection Agency. Method 1668B Chlorinated Biphenyl Congeners in Water, Soil, Sediment, Biosolids, and Tissue by HRGC/HRMS [S]. 2008
[20]	van den Berg M, Birnbaum L S, Denison M, et al. The 2005 world health organization re-evaluation of human and mammalian toxic equivalency factors for dioxins and dioxin-like compounds [J]. Toxicol. Sci., 2006, 93(2): 223-241
[21]	Mechati F, Roth E, Renault V, et al. Pilot scale and theoretical study of thermal remediation of soils [J]. Environmental Engineering Science, 2004, 21(3):361-370
[22]	Pichon C, Risoul V, Trouvé G, Peters W A, Gilot P, Prado G. Study of evaporation of organic pollutants by thermogravimetric analysis: experiments and modelling[J]. Thermochimica Acta, 1997, 306(1): 143-151
[23]	Qiu Y, Wang T, Song C. Study on the effect of heating rate on the pyrolysis and kinetics of polyacrylonitrile film[J]. Carbon Techniques, 2005, 24(2):5-8

Effect of carrier gas flow rate and heating rate on thermal desorption of polychlorinated biphenyls in contaminated soil

载气流量及升温速率对污染土壤中多氯联苯热脱附的影响

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 23

Related Articles 9

Recommended Articles

Metrics

Comments

[1]	WANG Jun, LIU Tianlu, HUANG Qunxing, CHI Yong, MA Zengyi. Slow pyrolysis characteristics of petroleum sludge [J]. CIESC Journal, 2017, 68(3): 1138-1145.
[2]	HU Wentian, YANG Rong, XU Liang, SONG Yan, LI Jinchun. Synthesis, properties and application of reactive nitrogen-phosphorus flame retardant [J]. CIESC Journal, 2015, 66(5): 1976-1982.
[3]	XIA Tianxiang, JIANG Lin, WEI Meng, JIA Xiaoyang, ZHONG Maosheng. PAHs thermal desorption behavior of coking plant soil and its effect on soil characteristics [J]. CIESC Journal, 2014, 65(4): 1470-1480.
[4]	TIAN Xiujuan, WANG Zhongwei, YU Qing, GAO Jun. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant [J]. CIESC Journal, 2014, 65(12): 5082-5089.
[5]	WANG Qidong, SHI Tiejun, XU Guomei. Synthesis,characterization of PT-ala resin and thermal degradation kinetics of its polymer [J]. CIESC Journal, 2013, 64(10): 3851-3857.
[6]	P. L. Cloirec. Adsorption onto activated carbon fiber cloth and electrothermal desorption of volatile organic compound (VOCs): A specific review [J]. , 2012, 20(3): 461-468.
[7]	ZHANG Minhua，LI Chunhua，JIANG Haoxi. Thermal degradation mechanism of polystyrene by TG-MS [J]. , 2008, 27(4): 609-.
[8]	ZHOU Wenjun；YANG Hui；FANG Chenpeng. Thermal degradation of polycarbonate [J]. , 2007, 26(1): 23-.
[9]	ZHANG Zhiguo，YIN Hong. Research progress of thermal degradation of polyether [J]. , 2006, 25(9): 1056-.