Characteristics of breakup of liquid sheet of axisymmetric opposed jets

doi:10.3969/j.issn.0438-1157.2014.10.007

CIESC Journal ›› 2014, Vol. 65 ›› Issue (10): 3789-3797.DOI: 10.3969/j.issn.0438-1157.2014.10.007

Previous Articles Next Articles

Characteristics of breakup of liquid sheet of axisymmetric opposed jets

HUANG Guofeng, LI Weifeng, TU Gongyi, WANG Fuchen

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, Shanghai Engineering Research Center of Coal Gasification, East China University of Science and Technology, Shanghai 200237, China

Received:2014-01-24 Revised:2014-03-28 Online:2014-10-05 Published:2014-10-05
Supported by:
supported by the National Basic Research Program of China (2010CB227004).

对置液柱撞击液膜破裂特征

黄国峰, 李伟锋, 屠功毅, 王辅臣

华东理工大学煤气化及能源化工教育部重点实验室, 上海煤气化工程技术研究中心, 上海 200237

通讯作者: 李伟锋
基金资助:
国家重点基础研究发展计划项目（2010CB227004）。

Abstract

Abstract: The breakup process of liquid sheet formed by two axisymmetric opposed jets was experimentally studied with a high-speed camera. The breakup process, the generation and propagation process of surface wave of liquid sheet were analyzed. The influences of jet diameter, nozzle separation and jet Weber number on the breakup of liquid sheet were investigated. The frequency variation of surface wave and the size distribution of sheet disintegration were quantitatively analyzed. The propagation frequency of surface wave increased with increasing We, but decreased along the radial direction. The droplet shedding frequency of sheet edge increased with increasing We. At We>1000, a large number of droplet dots appeared at surface of liquid sheet, which promoted the breakup of liquid sheet. The non-dimensional drop size disintegrated from liquid sheet was mainly in the range of 0-1.

Key words: liquid impinging jets, sheet disintegration, surface wave

摘要： 采用高速摄像仪对两液柱撞击产生液膜的破裂过程进行了实验研究。分析了撞击液膜的破裂过程及表面波产生和传播过程，考察了射流直径、喷嘴间距和射流Weber数（We）对撞击液膜破裂的影响；定量分析了液膜表面波频率的变化及液膜破裂后的粒径分布情况。研究结果表明，液膜表面波传播频率随We的增大而增大，并沿液膜径向方向逐渐减小；随着射流We的增加，液膜边缘的液滴脱落频率增加；当We>1000时，液膜表面产生大量液滴团，且液滴团对液膜破裂具有促进作用；液柱撞击液膜发生破裂后90%以上的量纲1液滴粒径分布在0～1之间。

关键词: 液柱撞击, 液膜破裂, 表面波

CLC Number:

TQ021.1

HUANG Guofeng, LI Weifeng, TU Gongyi, WANG Fuchen. Characteristics of breakup of liquid sheet of axisymmetric opposed jets[J]. CIESC Journal, 2014, 65(10): 3789-3797.

黄国峰, 李伟锋, 屠功毅, 王辅臣. 对置液柱撞击液膜破裂特征[J]. 化工学报, 2014, 65(10): 3789-3797.

References 20

[1]	Elperin I T. Heat and mass transfer in opposing currents (in Russian) [J]. J.Engng.Phy., 1961, 6: 62-68
[2]	Li Weifeng (李伟锋). Applicable and fundamental studies on the flow characteristics of impinging streams [D]. Shanghai: East China University of Science and Technology, 2008
[3]	Li Qin (李勤). Experiment research on the wet flue gas desulfurization in the impinging stream absorber [D]. Changchun: Northeastern University, 2006
[4]	Hu Lishun (胡立舜), Wang Xingjun (王兴军). Study on absorption characteristics of impinging stream and its application in methanol synthesis [J]. Journal of Chemical Engineering of Chinese Universities (高校化学工程学报), 2009, 23 (3): 404-410
[5]	Wu Yuan, Li Qin, Li Fang. Desulfurization in the gas-continuous impinging stream gas-liquid reactor [J]. Chem.Eng.Sci., 2007, 62 (6): 1814-1824
[6]	Dehkordi A M. Application of a novel opposed jets contacting device in liquid-liquid extraction [J]. Chem.Eng.Process., 2002, 41 (3): 251-258
[7]	Hou Yanbing (侯妍冰), Tian Xiushan (田秀山), Zhao Hui (赵辉), Li Weifeng (李伟锋), Xu Jianliang (许建良), Liu Haifeng (刘海峰). Influence of viscoelasticity on liquid primary atomization [J]. CIESC Journal (化工学报), 2013, 64 (5): 1601-1606
[8]	Asghar Molaei Dehkordi, Chiya Savari. Determination of interfacial area and overall volumetric mass-transfer coefficient in a novel type of two impinging streams reactor by chemical method [J]. Ind.Eng.Chem.Res., 2011, 50: 6426-6435
[9]	Asghar Molaei Dehkordi. Novel type of impinging streams contactor for liquid-liquid extraction [J]. Ind.Eng.Chem.Res., 2001, 40: 681-688
[10]	Asghar Molaei Dehkordi. Liquid-liquid extraction with chemical reaction in a novel impinging-jets reactor [J]. AIChE J., 2002, 48 (10): 2230-2239
[11]	Heidmann M F, Priem R J, Humphrey J C. A study of sprays formed by two impacting jets [J]. NACA Tech.Note, 1957: 3835
[12]	Huang J C P. The break-up of axisymmetric liquid sheets [J]. J.Fluid Mech., 1970, 43: 305-319
[13]	Ri Li, Nasser Ashgriz. Characteristics of liquid sheets formed by two impinging jets [J]. Phys.Fluids, 2006, 18: 087104
[14]	Bremond N, Villermaux E. Atomization by jet impact [J]. J.Fluid Mech., 2006, 549: 273-306
[15]	Anderson William E, Ryan Harry M, Santoro Robert J. Impact wave-based model of impinging jet atomization [J]. Atomization Spray., 2006, 16: 791-805
[16]	Ri Li, Nasser Ashgriz. Edge instability and velocity of liquid sheets formed by two impinging jets [J]. Atomization Spray., 2007, 17: 71-97
[17]	Ashgriz N. Handbook of Atomization and Sprays [M]. New York: Springer, 2011: 75-95
[18]	Dombrowski N, Hooper P C. A study of the sprays formed by impinging jets in laminar and turbulent flow [J]. J.Fluid Mech., 1963, 19: 392-400
[19]	John W M, Alexander E. On the collision of laminar jets: fluid chains and fishbones [J]. J.Fluid Mech., 2004, 511: 285-310
[20]	Zhao Hui (赵辉). Study on the mechanism of coaxial air-blast atomization [D]. Shanghai: East China University of Science and Technology, 2012

Characteristics of breakup of liquid sheet of axisymmetric opposed jets

对置液柱撞击液膜破裂特征

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 20

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	HAO Yajie, LIU Jiayu, YUAN Zhulin, YANG Linjun. Movement characteristics of droplets and demisting efficiency of mist eliminator [J]. CIESC Journal, 2014, 65(12): 4669-4677.
[2]	ZHANG Jun, HE Hongzhou, HUANG Guanxing. Simulation of droplet deformation in uniform electric field with dissipative particle dynamics approach [J]. CIESC Journal, 2014, 65(10): 3872-3877.
[3]	ZHANG Li, LI Jiaqi, ZHANG Chunmei, WANG Cuihua, WU Jianhua. Fluid flow in rectangular helical channels with vortex generator [J]. CIESC Journal, 2014, 65(10): 3838-3845.
[4]	YANG Xu, LIU Yaning, YU Jian, JIANG Fuming, HAN Yongsheng, XU Guangwen, GE Wei. Numerical simulation of mixing characteristics of trace sample and bed material in micro fluidized bed reaction analyzer [J]. CIESC Journal, 2014, 65(9): 3323-3330.
[5]	GUAN Xiaoping, LI Zhaoqi, ZHAO Yuanfang, WANG Lijun, CHENG Youwei, LI Xi. Impact of gas distributor configuration on hydrodynamics in bubble column with pipe internals [J]. CIESC Journal, 2014, 65(9): 3350-3356.
[6]	CHENG Zhiliang, QUAN Xuejun, YAN Yunpeng, DAI Li. Jet flow pattern and its effects on mass transfer area and gas phase pressure drop in a water-sparged aerocyclone [J]. CIESC Journal, 2014, 65(8): 2914-2920.
[7]	GUO Kunyu, WANG Tiefeng, XING Chutian, WANG Jinfu. Hydrodynamics study and industrial applications of slurry reactors [J]. CIESC Journal, 2014, 65(7): 2454-2464.
[8]	GUAN Xiaoping, WANG Lijun, LI Zhaoqi, ZHAO Yuanfang, CHENG Youwei, LI Xi. New two-scale hydrodynamic model based on energy balance in bubble column [J]. CIESC Journal, 2014, 65(6): 2013-2020.
[9]	ZHOU Bo, XU Ruina, JIANG Peixue. Permeability measurement method of crushed tight porous medium [J]. CIESC Journal, 2014, 65(S1): 353-358.
[10]	ZHOU Guangzheng, GE Wei. Progress of smoothed particle hydrodynamics in complex flows [J]. CIESC Journal, 2014, 65(4): 1145-1161.
[11]	CHENG Zhiliang, QUAN Xuejun, DAI Li, YAN Yunpeng. Treatment of Cr (Ⅵ)-containing wastewater in a water-sparged aerocyclone [J]. CIESC Journal, 2014, 65(4): 1403-1410.
[12]	WANG Tao, ZHAN Xia, LI Jiding. Flow visualization through channels in plate-and-frame modules [J]. CIESC Journal, 2014, 65(1): 71-77.
[13]	WANG Cuihua, LIU Shengju, WU Jianhua, LI Yaxia. Characteristics of fully developed laminar flow in triangular helical duct [J]. CIESC Journal, 2014, 65(1): 100-107.
[14]	ZHAO Qinghua, QUAN Xuejun, CHENG Zhiliang, YAN Yunpeng. Wet desulfurization of flue gas and mass transfer mechanism in water-sparged aerocyclone [J]. CIESC Journal, 2013, 64(11): 3993-4000.
[15]	WANG Haiyan, LI Yuxing, CAI Xiaohua, SONG Chengyi, MENG Lan. Development and verification of unified model based on slug flow for gas-liquid two-phase flow [J]. CIESC Journal, 2013, 64(10): 3549-3557.