Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe0.95-xZrxTm0.05O3-δ(0≤x≤0.40)Membrane

›› 2010, Vol. 18 ›› Issue (3): 506-510.

• PRODUCT ENGINEERING AND CHEMICAL TECHNOLOGY • Previous Articles Next Articles

Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane

LIANG Jie¹, MAO Lingling¹, LI Li², YUAN Wenhui¹

1. School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2. College of Environmental Science and Engineering, South China University of Technology, Guangzhou 510640, China

Received:2009-08-07 Revised:2009-11-12 Online:2010-06-28 Published:2010-06-28
Supported by:
Supported by the Joint Funds of NSFC-Guangdong(U0834004);the National Natural Science Foundation of China(20976057);the Natural Science Foundation of Guangdong Province(06025657)

Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane

梁杰¹, 毛玲玲¹, 李莉², 袁文辉¹

1. School of Chemistry and Chemical Engineering, South China University of Technology, Guangzhou 510640, China;
2. College of Environmental Science and Engineering, South China University of Technology, Guangzhou 510640, China

通讯作者: YUAN Wenhui,E-mail:cewhyuan@scut.edu.cn
基金资助:
Supported by the Joint Funds of NSFC-Guangdong(U0834004);the National Natural Science Foundation of China(20976057);the Natural Science Foundation of Guangdong Province(06025657)

Abstract

Abstract: Zr-substituted,Tm-doped SrCeO₃(SrCe_0.95-xZr_xTm_0.05O_3-δ,0≤x≤0.40)were synthesized via citrate complexing method,and the membranes of SrCe_0.95-xZr_xTm_0.05O_3-δwere prepared by pressing followed by sintering. X-ray diffraction(XRD)was used to characterize the phase structure of sintered membrane.The microstructure of the sintered membranes was studied by scanning electron microscopy(SEM).Protonic and electronic conductivities were measured under different circumstance.Hydrogen permeation through the SrCe_0.75Zr_0.20Tm_0.05O_3-δmembranes was carried out using gas permeation setup.Hydrogen permeation fluxes(J_H₂) of the SrCe_0.75Zr_0.20Tm_0.05O_3-δ membrane reach up to 0.042 ml·min^-1·cm^-2 at H₂ partial pressure of 0.4×10^-1 Pa at 900℃.The hydrogen permeation fluxes(J_H₂)obtained in this paper are slightly lower than that of SrCe0.95Tm0.05O_3-δ on the same orders,and Zr doping can increase chemical stability of the SrCe_0.75Zr_0.20Tm_0.05O_3-δ membranes.

Key words: zirconium dopant, mixed conductivity, hydrogen permeation, perovskite

摘要： Zr-substituted,Tm-doped SrCeO₃(SrCe_0.95-xZr_xTm_0.05O_3-δ,0≤x≤0.40)were synthesized via citrate complexing method,and the membranes of SrCe_0.95-xZr_xTm_0.05O_3-δwere prepared by pressing followed by sintering. X-ray diffraction(XRD)was used to characterize the phase structure of sintered membrane.The microstructure of the sintered membranes was studied by scanning electron microscopy(SEM).Protonic and electronic conductivities were measured under different circumstance.Hydrogen permeation through the SrCe_0.75Zr_0.20Tm_0.05O_3-δmembranes was carried out using gas permeation setup.Hydrogen permeation fluxes(J_H₂) of the SrCe_0.75Zr_0.20Tm_0.05O_3-δ membrane reach up to 0.042 ml·min^-1·cm^-2 at H₂ partial pressure of 0.4×10^-1 Pa at 900℃.The hydrogen permeation fluxes(J_H₂)obtained in this paper are slightly lower than that of SrCe0.95Tm0.05O_3-δ on the same orders,and Zr doping can increase chemical stability of the SrCe_0.75Zr_0.20Tm_0.05O_3-δ membranes.

关键词: zirconium dopant, mixed conductivity, hydrogen permeation, perovskite

LIANG Jie, MAO Lingling, LI Li, YUAN Wenhui. Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane[J]. , 2010, 18(3): 506-510.

梁杰, 毛玲玲, 李莉, 袁文辉. Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane[J]. CIESC Journal, 2010, 18(3): 506-510.

References

1 Iwahara, H., “Technological challenges in the application of proton conducting ceramics”, Solid State Ionics, 77, 289-298(1995).
2 Matsumoto, H., Takeuchi, K., Iwahara, H., “Electromotive force of H₂-D₂ gas cell using high-temperature proton conductors”, Solid State Ionics, 125, 377-381(1999).
3 Iwahara, H., Esaka, T., Uchida, H., Yamauchi, T., Ogaki, K., “High temperature type protonic conductor based on SrCeO₃ and its application to the extraction of hydrogen gas”, Solid State Ionics, 18/19, 1003-1007(1986).
4 Yuan, W.H., Gu, Y.P., Li, L., “Synthesis and ionic conduction of cation-deficient apatite La_9.33-2x/3M_xSi₆O₂₆ Doped with Mg, Ca, Sr”, Chin. J. Chem. Eng., 16(3), 488-491(2008).
5 Marnellos, G., Sanopoulou, O., Rizou, A., Stoukides, M., “The use of proton conducting solid electrolytes for improved performance of hydroand dehydrogenation reactors”, Solid State Ionics, 97, 375-383(1997).
6 Iwahara, H., Esaka, T., Uchida, H., Maeda, N., “Proton conduction in sintered oxides and its application to steam electrolysis for hydrogen production”, Solid State Ionics, 3/4, 359-363(1981).
7 Cheng, S., Gupta, V.K., Lin, Y.S., “Synthesis and hydrogen permeation properties of asymmetric proton-conducting ceramic membranes”, Solid State Ionics, 176, 2653-2662(2005).
8 Uchida, H., Yoshikawa, H., Iwahara, H., “Formation of protons in SrCeO₃-based proton conducting oxides(I) Gas evolution and absorption in doped SrCeO₃ at high temperature”, Solid State Ionics, 34, 103-110(1989).
9 Song, S.J., Wachsman, E.D., Rhodes, J., “Hydrogen permeability of SrCe_1-xM_xO_3-δ(x=0.05, M=Eu, Sm) ”, Solid State Ionics, 167, 99-105(2004).
10 Hibino, T., Mizutani, K., Yajima, T., Iwahara, H., “Evaluation of proton conductivity in SrCeO₃, BaCeO₃, CaZrO₃ and SrZrO₃ by temperature programmed desorption method”, Solid State Ionics, 57, 303-3062(1992).
11 Yajima, T., Suzuki, H., Yogo, T., Iwahara, H., “Protonic conduction in SrZrO₃-based oxides”, Solid State Ionics, 51, 101-107(1992).
12 Sata, N., Matsuta, H., Akiyama, Y., “Fabrication of proton conducting thin films of SrZrO₃ and SrCeO₃ and their fundamental characterization”, Solid State Ionics, 97, 437-441(1997).
13 Zhu, B., Mellander, B.E., “Proton conduction in nitrate-based oxides and related ceramics at intermediate temperatures”, Solid State Ionics, 70-71, 285-290(1994).
14 Qi, X., Lin, Y.S., “Electrical conduction and hydrogen permeation through mixed proton–electron conducting strontium cerate membranes”, Solid State Ionics, 130, 149-156(2000).
15 Du, Y., Nowick, A.S., “Structural transitions and proton conduction in nonstoichiometric A3B′B″O₉ perovskite-type oxides”, J. Am. Ceram. Soc., 78, 3033-3039(1995).
16 Hibino, T., Mizutani, K., Yajima, T., Iwahara, H., “Characterization of proton in Y-doped SrZrO₃ polycrystal by IR spectroscopy”, Solid State Ionics, 58, 85(1992).
17 Taniguchi, N., Hatoh, K., Niikura, J., Gamo, T., Iwahara, H., “Proton conductive properties of gadolinium-doped barium cerates at high temperatures”, Solid State Ionics, 52-56, 998-1003(1992).
18 Shimura, T., Egusa, G., Iwahara, H., Katahira, K., Yamamoto, K., “Electrochemical properties of junction between protonic conductor and oxide ion conductor”, Solid State Ionics, 97, 477-482(1997).
19 Wei, X., Lin, Y.S., “Protonic and electronic conductivities of terbium doped strontium cerates”, Solid State Ionics, 178, 1804-1810(2008).
20 Kreuer, K.D., “On the development of proton conducting materials for technological applications”, Solid State Ionics, 97, 1-15(1997).
21 Matzke, T., Cappadonia, M., “Proton conductive perovskite solid solutions with enhanced mechanical stability”, Solid State Ionics, 86-88, 659-661(1996).
22 Cai, M.Y., Li, Z., Wang, H.H., “Preparation and hydrogen permeation properties of BaCe_0.95Nd_0.05O_3-δ membranes”, Chin. Chem. Letters, 19, 1256-1259(2008).
23 Phillips, R.J., Bonanos, N., Poulsen, F.W., Ahlgren, E.O., “Structural and electrical characterization of SrCe_1-xY_xO_ξ”, Solid State Ionics, 125, 389-395(1999).
24 Knight, K.S., Bonanos, N., “A high-resolution neutron powder diffraction study of neodymium doping in barium cerate”, Solid State Ionics, 77, 189-194(1995).
25 Kingery, W.D., Bowen, H.K., Uhlmann, D.R., Introduction to Ceramics, Wiley, New York, 866(1976).
26 Katahira, K., Kohchi, Y., Shimura, T., Iwahara, H., “Protonic conduction in Zr-substituted BaCeO₃ ”, Solid State Ionics, 138, 91-98(2000).

[1]	Xiaoxiong FAN, Lifang HAO, Chuigang FAN, Songgeng LI. Study on the catalytic denitrification performance of low-temperature NH₃-SCR over LaMnO₃/biochar catalyst [J]. CIESC Journal, 2023, 74(9): 3821-3830.
[2]	Yu FU, Xingchong LIU, Hanyu WANG, Haimin LI, Yafei NI, Wenjing ZOU, Yue LEI, Yongshan PENG. Research on F₃EACl modification layer for improving performance of perovskite solar cells [J]. CIESC Journal, 2023, 74(8): 3554-3563.
[3]	Wanchen ZHANG, Xiaoyang CHEN, Qiuqiu LYU, Qin ZHONG, Tenglong ZHU. Performance and durability of cobalt doped SrTi_0.3Fe_0.7O_3-_δ anode SOFC fueled with by-product gas from chemical industry [J]. CIESC Journal, 2022, 73(9): 4079-4086.
[4]	Chengyi AI, Jinshuo QIAO, Zhenhuan WANG, Wang SUN, Kening SUN. Investigation on PrBaFe₂O_6-_δ anode material with in-situ FeNi nanoparticle in direct carbon solid oxide fuel cell [J]. CIESC Journal, 2022, 73(8): 3708-3719.
[5]	Ke XU, Guoqiang SHI, Dongfeng XUE. Inorganic hybrid perovskite cluster materials: luminescence properties of mesoscale perovskite materials [J]. CIESC Journal, 2022, 73(6): 2748-2756.
[6]	Wenhuai LI, Wei ZHOU. Analysis of influencing factors and design strategies of high oxygen ion conductivity perovskite [J]. CIESC Journal, 2022, 73(4): 1455-1471.
[7]	Xiaoshan DONG, Jian LI, Beibei YAN, Guanyi CHEN. Research progress of perovskite catalysts in thermochemical utilization of biomass [J]. CIESC Journal, 2022, 73(2): 504-520.
[8]	Runxia CAI, Fanxing LI. Tailoring the thermodynamic properties of complex oxides for thermochemical air separation and beyond [J]. CIESC Journal, 2021, 72(12): 6122-6130.
[9]	Hao ZHOU,Qiwei WU,Fangzheng CHENG. Preparation of La_0.8Sr_0.2Mn_1-_xCu_xO₃by flame spray synthesis method and catalytic performance for CO oxidation [J]. CIESC Journal, 2021, 72(10): 5159-5171.
[10]	Xiaojia XU, Yongzhen WU, Weihong ZHU. Research progress on stability enhancement of CsPbX₃ perovskite and photovoltaic devices [J]. CIESC Journal, 2020, 71(9): 3933-3949.
[11]	Yaqian WANG, Xiao LU, Bo PENG. Control of magnetic field to luminescence characteristics in (C₄H₉NH₃)₂(CH₃NH₃)Pb₂I₇ perovskite [J]. CIESC Journal, 2020, 71(6): 2912-2917.
[12]	Keqing WANG, Jie XU, Zhixuan SHEN, Jiabin CHEN, Wei WU. Degradation of naproxen by peroxymonosulfate activated with LaCoO₃ [J]. CIESC Journal, 2020, 71(3): 1326-1334.
[13]	Xiaogang LIU, Bo WEI, Yunfei SHI, Jinru SUN, Yu TIAN, Yu ZHAO, Yaoling CHI, Hong WANG, Cuiqing LI, Yongji SONG. Simultaneous removal of NO and soot over La_1-_xLi_xMnO₃ perovskite catalysts [J]. CIESC Journal, 2020, 71(3): 1053-1059.
[14]	Yinghui SU,Hao ZHENG,Lei ZHANG,Liang ZENG. LaMn_1-_x_-_yFe_xCo_yO_3-_δ perovskite based oxygen carriers for chemical looping partial oxidation [J]. CIESC Journal, 2020, 71(11): 5265-5277.
[15]	CHEN Chao, ZHAO Lingling, WANG Jingfan. Molecular simulation of physical properties and preparation of CH₃NH₃PbI₃ [J]. CIESC Journal, 2018, 69(6): 2380-2387.

Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane

Protonic and Electronic Conductivities and Hydrogen Permeation of SrCe_0.95-xZr_xTm_0.05O_3-δ(0≤x≤0.40)Membrane

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments