富氧条件下煤粉气流的着火性能变化

doi:10.3969/j.issn.0438-1157.2013.07.039

化工学报 ›› 2013, Vol. 64 ›› Issue (7): 2596-2603.DOI: 10.3969/j.issn.0438-1157.2013.07.039

富氧条件下煤粉气流的着火性能变化

刘国伟, 董芃, 别如山

哈尔滨工业大学能源科学与工程学院, 黑龙江哈尔滨 150001

收稿日期:2012-12-27 修回日期:2013-01-30 出版日期:2013-07-05 发布日期:2013-07-05
通讯作者: 董芃
作者简介:刘国伟(1982- ),男,博士研究生。
基金资助:
黑龙江省自然科学基金重点项目(GC12A326)。

Ignition characteristics of coal powder airflow under various oxygen-enriched conditions

LIU Guowei, DONG Peng, BIE Rushan

College of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, Heilongjiang, China

Received:2012-12-27 Revised:2013-01-30 Online:2013-07-05 Published:2013-07-05
Supported by:
supported by the Natural Science Foundation of Heilongjiang Province Key Projects (GC12A326).

摘要/Abstract

摘要： 利用一维火焰炉对不同富氧条件下的煤粉气流着火燃烧特性进行了研究,得到了富氧条件下煤粉气流的着火性能变化规律。研究结果表明:随着助燃气体氧浓度的提高,各煤样的着火温度均大幅下降,其中低挥发分煤种在着火方面对富氧条件的改善更为敏感,即富氧条件的改善可减弱煤种间着火性能方面的差异性;随着氧浓度的提高,煤粉气流的着火方式明显从均相着火向非均相着火转变,其中燃用褐煤时发生着火方式转变所对应的氧浓度为50%~60%,燃用烟煤时约为40%,燃用贫煤和无烟煤时都约为30%;对于烟煤和褐煤,随着氧浓度的提高,对应的最佳煤粉浓度值先增大后减小,而对于贫煤和无烟煤,由于其在整个实验氧浓度范围内基本上都以"非均相着火"为主,因此随着氧浓度的提高,对应的最佳煤粉浓度的值基本上呈缓慢下降的趋势。

关键词: 富氧, 着火机理, 着火特性, 着火方式

Abstract: Ignition characteristics of coal powder airflow was investigated with a one dimensional furnace under various oxygen-enriched conditions,to get their changing laws.The results show that with oxygen concentration increases,ignition temperature of four kinds of coals decrease greatly and do faster for low volatile coals,and an obvious transformation is observed for ignition mode of pulverized coals,from homogeneous to heterogeneous,the oxygen concentrations corresponding to the transformation are about 40% for bitumite,50%—60% for lignite and about 30% for both lean coal and anthracite,respectively. With oxygen concentration increasing,the optimal coal powder concentrations increase first and then decrease for bituminous coal and lignite,but decrease slowly for lean coal and anthracite.

Key words: oxygen-enriched, ignition mechanism, ignition characteristics, ignition mode

中图分类号:

TK227.7

刘国伟, 董芃, 别如山. 富氧条件下煤粉气流的着火性能变化[J]. 化工学报, 2013, 64(7): 2596-2603.

LIU Guowei, DONG Peng, BIE Rushan. Ignition characteristics of coal powder airflow under various oxygen-enriched conditions[J]. CIESC Journal, 2013, 64(7): 2596-2603.

参考文献 22

[1]	Lu Chunmei(路春美),Wang Yongzheng(王永征).Theory and Technology of Coal Combustion (煤燃烧理论与技术)[M].Beijing:Earthquake Press,2001:1-2
[2]	Zhang Chaoqun(张超群),Yu Lijun(于立军),Cui Zhigang(崔志刚),Jiang Xiumin(姜秀民).Experimental research and computation analysis of combustion kinetic characteristics of micro-pulverized and common-pulverized coal[J].Journal of Chemical Industry and Engineering (China)(化工学报),2005,56(11):2189-2194
[3]	Gururajan V S.Mechanisms for the ignition of coal particles[J].Combust.Flame,1990,101(4):81-92
[4]	Essenhigh R H.Ignition of coal particles:a review[J].Combust.Flame,1989,77(7):3-30
[5]	Gupta R P.Ignition temperature of pulverized coal particles:experimental techniques and coal-related influences[J].Combust.Flame,1990,103(5):79-85
[6]	Field M A.Rate of combustion of size-graded fraction of char from low-bank coal between l200K and 2000K[J].Combust.Flame,1969,24(13):237-252
[7]	Wall T F.Combustion processes for carbon capture[J].Proc.Combust.Inst.,2007,31(1):31-47
[8]	Hjartstam S,Andersson K,Johnsson F.Combustion characteristics of lignite-fired oxy-fuel flames[J].Fuel,2009,88(11):2216-2224
[9]	Liu Hao(刘皓),Ren Ruiqi(任瑞琪),Huang Yongjun(黄永俊),Yang Luohui(杨落恢),Zhu He(祝贺),Ando Takasi,Okazaki Ken.Reduction and emission of NO in oxy-fuel system[J].CIESC Journal (化工学报),2011,62(2):495-501
[10]	Maja B T,Jacob B,Peter A J.Oxy-fuel combustion of solid fuels[J].Prog.Energy Combust.Sci.,2010,36(5):581-625
[11]	Li Haoyu(李皓宇),Yan Weiping(阎维平).Partial spectrum k-distribution model for radiative property of flue gas with soot and flyash from oxygen-enriched combustion[J].CIESC Journal (化工学报),2011,62(11):3073-3079
[12]	Kakaras E,Koumanakos A,Doukelis A.Oxy-fuel boiler design in a lignite-fired power plant[J].Fuel,2007,86(14):2144-2150
[13]	Zhang Yongchun(张永春),Zhang Jun(张军),Sheng Changdong(盛昌栋),Zhao Liang(赵亮),Xie Fang(谢芳),Chen Jie(陈洁),Liu Yangxian(刘杨先).NOx emission characteristics of pulverized coal combustion in O2/N2,O2/CO2 and O2/CO2/NO atmospheres[J].CIESC Journal (化工学报),2010,61(1):159-165
[14]	Chen Xiangyun(陈香云),Zhang Yongfeng(张永锋),Cui Jingdong(崔景东).Oxygen-enriched combustion of lignite by thermogravimetric analysis[J].Chemical Industry and Engineering Progress(化工进展),2012,31:232-235
[15]	Howard J B,Essenhigh R H.Mechanism of solid-particle combustion with simultaneous gas-phase volatiles combustion//11th Sym.Combust[C].Pittsburgh,1967:399-408
[16]	Fan Yuesheng(樊越胜),Si Pengfei(司鹏飞),Cao Zidong(曹子栋).Experimental study on ignition mechanisms of pulverized coal in oxygen-enriched atmosphere[J].J.Chin.Soc.Power Eng.(动力工程学报),2011,31(1):33-36
[17]	Miline T A,Beachey J E.The microstructure of pulverized coal air flame[J].Combust.Sci.Technol.,1977,16(3):139-142
[18]	Kimber G M,Gary M D.Rapid devolatilization of small coal particles[J].Combust.Flame,1967,11:360-366
[19]	Han Yafen(韩亚芬).Study on combustion characteristics of coal at oxygen enriched condition by thermogravimetric.Harbin:Harbin Institute of Technology,2007
[20]	Fan Yuesheng(樊越胜),Zou Zheng(邹峥),Gao Jubao(高巨宝),Cao Zidong(曹子栋).Study of oxygen content on combustion characteristics of pulverized coal[J].Proceedings of the CAEE(电机工程学报),2005,25(24):118-121
[21]	Xu Yingchao(徐迎超),Jiang Xiaoke(蒋孝科),Mao Tian(毛天).Experimental study of the flow of pulverized-coal ignition speciality on oxygen-enriched[J].Boiler Technol.(锅炉技术),2008,39(1):42-46
[22]	Yan Weiping(阎维平),Xu Tongmo(徐通模),Xu Jinyuan(许晋源).Mechanism analysis for optimal pulverized-coal concentration in ignition of primary air stream[J].J.North Chin.Inst.Electric.Power(华北电力学院学报),1995,22(2):28-32

富氧条件下煤粉气流的着火性能变化

Ignition characteristics of coal powder airflow under various oxygen-enriched conditions

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	肖覃, 曾旭, 黄健涵, 刘又年. 富氧功能化超交联树脂的合成及其对苯胺的吸附[J]. 化工学报, 2021, 72(3): 1742-1750.
[2]	朱传强, 刘殊远, 余剑, 高士秋, 许光文. 富氧富水蒸气条件下燃烧高氮燃料的NO_x排放特性[J]. 化工学报, 2019, 70(3): 1048-1055.
[3]	刘沁雯,钟文琪,邵应娟. 固体燃料流化床富氧燃烧的研究动态与进展[J]. 化工学报, 2019, 70(10): 3791-3807.
[4]	李屹, 张小松. 一种基于电渗析的空气直接富氧装置影响因素[J]. 化工学报, 2018, 69(S2): 388-393.
[5]	刘敦禹, Terry Wall, Rohan Stanger. 富氧燃烧烟气冷凝塔钠碱法脱硫过程SO₂和CO₂共吸收建模与实验研究[J]. 化工学报, 2018, 69(9): 4019-4029.
[6]	李汉卿, 王长安, 朱晨钊, 赵磊, 韩涛, 车得福. O₂/CO₂气氛对准东煤灰熔融行为和微观理化特性的影响[J]. 化工学报, 2018, 69(6): 2632-2638.
[7]	刘沁雯, 钟文琪, 刘雪娇, 刘倩, 邵应娟, Yu Aibing. 煤/生物质流态化富氧燃烧的CO₂富集特性[J]. 化工学报, 2018, 69(12): 5199-5208.
[8]	刘倩, 钟文琪, 苏伟, 贲昊玺. 基于热重-质谱联用的煤粉富氧燃烧动力学及污染物生成特性[J]. 化工学报, 2018, 69(1): 523-530.
[9]	刘慧敏, 王春波, 黄星智, 张月, 孙鑫. 富氧燃烧方式下煤中砷的挥发行为[J]. 化工学报, 2015, 66(12): 5079-5087.
[10]	金涌, 胡永琪, 胡山鹰, 王勇, 赵瑞红, 余海鹏, 李飞龙. 煤炭热力学高效和化学高价值利用新工艺[J]. 化工学报, 2014, 65(2): 381-389.
[11]	牛淼淼, 黄亚继, 金保昇, 王妍艳, 董新新. 鼓泡流化床垃圾衍生燃料富氧气化[J]. 化工学报, 2014, 65(12): 4971-4977.
[12]	刘皓, 任瑞琪, 黄永俊, 杨落恢, 祝贺, Ando Takashi, Okazaki Ken. 富氧燃烧系统中NO的还原及其排放 [J]. 化工学报, 2011, 62(2): 495-501.
[13]	李皓宇，阎维平. 富氧燃烧含灰烟气辐射特性的部分光谱k模型[J]. CIESC Journal, 2011, 62(11): 3073-3080.
[14]	王明哲，华炜. 富氧再生技术在催化裂化装置上的应用 [J]. CIESC Journal, 2007, 26(2): 262-.
[15]	张子勇;吴新华 . 三甲基硅基甲基纤维素的合成及膜的富氧性能 [J]. CIESC Journal, 2006, 57(5): 1251-1254.