密相输运床的团聚物频率和持续时间

doi:10.3969/j.issn.0438-1157.2013.05.016

化工学报 ›› 2013, Vol. 64 ›› Issue (5): 1614-1620.DOI: 10.3969/j.issn.0438-1157.2013.05.016

密相输运床的团聚物频率和持续时间

曾鑫^1,2, 阳绍军^1,2, 王圣典^1,2, 赵凯^1,2, 徐祥^1,2, 肖云汉^1,2

1. 中国科学院能源动力研究中心, 北京 100190;
2. 中国科学院先进能源动力重点实验室(工程热物理研究所), 北京 100190

收稿日期:2012-08-10 修回日期:2012-11-12 出版日期:2013-05-05 发布日期:2013-05-05
通讯作者: 曾鑫
作者简介:曾鑫(1987-),男,硕士研究生。
基金资助:
国家高技术研究发展计划项目(2006AA05A103);中国科学院知识创新重要方向性项目(KGCX2-YW-348)。

Cluster frequency and existence time in dense transport bed

ZENG Xin^1,2, YANG Shaojun^1,2, WANG Shengdian^1,2, ZHAO Kai^1,2, XU Xiang^1,2, XIAO Yunhan^1,2

1. Research Center for Clean Energy and Power, Chinese Academy of Sciences, Beijing 100190, China;
2. Key Laboratory of Advanced Energy and Power, Chinese Academy of Sciences (Institute of Engineering Thermo-physics), Beijing 100190, China

Received:2012-08-10 Revised:2012-11-12 Online:2013-05-05 Published:2013-05-05
Supported by:
supported by the High-tech Research and Development Program of China(2006AA05A103)and the Main Direction Program of Knowledge Innovation of Chinese Academy of Sciences(KGCX2-YW-348).

摘要/Abstract

摘要： 在内径0.102 m、高17 m的密相输运床冷态实验台上,以石英砂(属Geldart B类颗粒)作为循环物料,对光纤探针在表观气速8.2~11.2 m·s^-1,固体循环流率139~530 kg·m^-2·s^-1下获得的瞬态信号,采用小波分析的方法研究了团聚物频率、团聚物持续时间。结果表明:提升管边壁与底部区域更易形成大尺度团聚物,径向上团聚物频率中心高边壁低,而团聚物持续时间中心短边壁长。轴向上提升管底部团聚物频率低、持续时间长。团聚物频率随表现气速增大而增大,而团聚物持续时间随表现气速增大而缩短,提升管底部团聚物频率随固体循环流率增大而降低,团聚物持续时间随固体循环流率增大而变长。

关键词: 密相输运床, 光纤探针, 团聚物, 小波分析

Abstract: Cluster characteristics(cluster frequency and cluster existence time)were investigated with wavelet analysis in a cold dense transport bed with Geldart B particle using a fiber optic probe.The superficial gas velocities and solids circulating rate were in the range of 8.2-11.2 m穝^-1 and 139-530 kg穖^-2穝^-1, respectively.The results indicated that large scale clusters were easier to form in the near wall and bottom zone than in the center and the top zone of the riser, respectively.Cluster frequency decreased from center to wall, while cluster existence time increased from center to wall.Cluster frequency increased with increasing superficial gas velocity, while cluster existence time decreased with increasing superficial gas velocity.At the riser bottom, cluster frequency decreased with increasing solids circulating rate while cluster existence time increased with increasing solids circulating rates.

Key words: dense transport bed, fiber optic probe, cluster, wavelet analysis

中图分类号:

曾鑫, 阳绍军, 王圣典, 赵凯, 徐祥, 肖云汉. 密相输运床的团聚物频率和持续时间[J]. 化工学报, 2013, 64(5): 1614-1620.

ZENG Xin, YANG Shaojun, WANG Shengdian, ZHAO Kai, XU Xiang, XIAO Yunhan. Cluster frequency and existence time in dense transport bed[J]. CIESC Journal, 2013, 64(5): 1614-1620.

参考文献 20

[1]	Wang Shengdian(王圣典).Hydrodynamic characteristics in dense transport bed.Beijing:Institute of Engineering Thermophysics, Chinese Academy of Sciences, 2012
[2]	Shadle L J, Monazam E R, Swanson M L.Coal gasification in a transport reactor[J].Industrial & Engineering Chemistry Research, 2001, 40(13):2782-2792
[3]	Horio M, Grace J R, Avidin A A, Knowton T M. Hydrodynamics in Circulating Fluidized Beds[M].London:Blackie Academic, 1997
[4]	Li Y, Kwauk M.The dynamics of fast fluidization[J].Fluidization, 1980, 3:537-544
[5]	Chew J W, Hays R, Findlay J G, Knowlton T M, Karri S B R, Cocco R A, Hrenya C M.Cluster characteristics of Geldart group B particles in a pilot-scale CFB riser(Ⅰ):Monodisperse systems[J].Chemical Engineering Science, 2012, 68(1):72-81
[6]	Guenther C, Breault R.Wavelet analysis to characterize cluster dynamics in a circulating fluidized bed[J].Powder Technology, 2007, 173(3):163-173
[7]	Qi Xiaobo(漆小波).Gas-solid two-phase flow dynamics in circulating fluidized bed risers.Chengdu:Sichuan University, 2003
[8]	Soong C, Tuzla K, Chen J.Identification of particle clusters in circulating fluidized bed//Circulating Fluidized Bed Technology Ⅳ.New York:Pergamon Press, 1994:615-620
[9]	Tuzla K, Sharma A, Chen J, Schiewe T, Wirth K, Molerus O.Transient dynamics of solid concentration in downer fluidized bed[J].Powder Technology, 1998, 100(2):166-172
[10]	Afsahi F A, Sotudeh‐Gharebagh R, Mostoufi N.Clusters identification and characterization in a gas-solid fluidized bed by the wavelet analysis[J].The Canadian Journal of Chemical Engineering, 2009, 87(3):375-385
[11]	Yang T Y, Leu L.Multiresolution analysis on identification and dynamics of clusters in a circulating fluidized bed[J].AIChE Journal, 2009, 55(3):612-629
[12]	Manyele S, Pärssinen J, Zhu J X.Characterizing particle aggregates in a high-density and high-flux CFB riser[J].Chemical Engineering Journal, 2002, 88(1/2/3):151-161
[13]	Liu Xinhua(刘新华), Gao Shiqiu(高士秋), Li Jinghai(李静海).Characteristics of particle clusters in gas -solids circulating fluidized beds by using PDPA[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2004, 55(4):555-562
[14]	Sharma A K, Tuzla K, Matsen J, Chen J C.Parametric effects of particle size and gas velocity on cluster characteristics in fast fluidized beds[J].Powder Technology, 2000, 111(1):114-122
[15]	Wei F, Yang G Q, Jin Y, Yu Z Q.The characteristics of cluster in a high density circulating fluidized bed[J].The Canadian Journal of Chemical Engineering, 1995, 73(5):650-655
[16]	Ren J, Mao Q, Li J, Lin W.Wavelet analysis of dynamic behavior in fluidized beds[J].Chemical Engineering Science, 2001, 56(3):981-988
[17]	Yang T Y, Leu L.Study of transition velocities from bubbling to turbulent fluidization by statistic and wavelet multi-resolution analysis on absolute pressure fluctuations[J].Chemical Engineering Science, 2008, 63(7):1950-1970
[18]	Coifman R R, Donoho D L.Translation-invariant de-noising//Lecture Notes in Statistics[M]. New York:Springer Verlag, 1995:125
[19]	Wei Fei(魏飞), Lu Fangbin(陆坊斌), Jin Yong(金涌), Yu Zhiqing(俞芷青).Mass flux profiles and flow regimes in a high density circulating fluidized bed[J].Journal of Chemical Industry and Engineering(China)(化工学报), 1996, 47(3):346-351
[20]	Berruti F, Pugsley T, Godfroy L, Chaouki J, Patience G.Hydrodynamics of circulating fluidized bed risers:a review[J].The Canadian Journal of Chemical Engineering, 1995, 73(5):579-602

密相输运床的团聚物频率和持续时间

Cluster frequency and existence time in dense transport bed

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	郑志航, 马郡男, 闫子涵, 卢春喜. 提升管射流影响区内压力脉动特性研究[J]. 化工学报, 2023, 74(6): 2335-2350.
[2]	王腾, 毕勤成, 桂淼, 刘朝晖. 弹状流液弹区含气率分布的试验研究[J]. 化工学报, 2021, 72(9): 4584-4593.
[3]	朱晓, 沈来宏. 塔式鼓泡流化床内的涌渗流动特性[J]. 化工学报, 2017, 68(11): 4112-4120.
[4]	范小强, 何乐路, 黄正梁, 叶向群, 李勇, 王靖岱, 阳永荣. 填料塔液泛的声发射测量[J]. 化工学报, 2016, 67(2): 476-484.
[5]	周发戚, 陈勇, 魏志刚, 严超宇, 孙国刚, 魏耀东. 循环流化床提升管T形弯头动态压力的小波分析[J]. 化工学报, 2015, 66(5): 1697-1703.
[6]	吴迎亚, 蓝兴英, 高金森. 基于DEM模拟的气固鼓泡床内流场间歇性及颗粒相干结构的分析[J]. 化工学报, 2014, 65(7): 2724-2732.
[7]	周云龙, 杨宁. 流化床颗粒团聚物水分分布测量新技术[J]. 化工学报, 2014, 65(10): 3878-3883.
[8]	田道贵, 阎昌琪, 孙立成. 四传感器光纤探针测量气泡速度矢量模型[J]. 化工学报, 2013, 64(9): 3117-3122.
[9]	幸奠川, 阎昌琪, 孙立成, 侯大文. 倾斜对管内上升泡状流局部界面参数分布的影响[J]. 化工学报, 2013, 64(7): 2411-2417.
[10]	曾鑫阳绍军王圣典赵凯徐祥肖云汉. 密相输运床的团聚物频率和持续时间[J]. 化工学报, 2013, 64(5): 0-0.
[11]	曾鑫阳绍军王圣典赵凯徐祥肖云汉. 密相输运床的团聚物频率和持续时间[J]. 化工学报, 2013, 64(5): 0-0.
[12]	吴曦, 章冬云, 蒋淇忠, 马紫峰. 球形团聚物模型在质子交换膜燃料电池过程模拟中的应用 [J]. 化工学报, 2010, 61(10): 2694-2702.
[13]	任聪静, 王靖岱, 张晓欢, 阳永荣. 利用声发射技术测量搅拌釜的淤浆悬浮高度 [J]. 化工学报, 2008, 59(6): 1383-1389.
[14]	王嘉骏;张文峰;冯连芳;顾雪萍. 气固搅拌流化床压力脉动的小波分析 [J]. CIESC Journal, 2006, 57(12): 2854-2859.
[15]	刘欢鹏, 王淑彦, 陆慧林, 刘文铁, 沈志恒. DSMC-LES方法研究循环流化床内颗粒团聚物的流动特性 [J]. 化工学报, 2005, 56(7): 1197-1205.