大肠杆菌及其耐乙酸突变菌的连续培养和代谢流比较

化工学报 ›› 2008, Vol. 59 ›› Issue (1): 160-166.

大肠杆菌及其耐乙酸突变菌的连续培养和代谢流比较

张艳军, 张晓云, 李志敏, 叶勤

华东理工大学生物反应器工程国家重点实验室

出版日期:2008-01-05 发布日期:2008-01-05

Comparison of metabolic fluxes in Escherichia coli and its acetate-tolerant mutant in continuous culture

ZHANG Yanjun, ZHANG Xiaoyun, LI Zhimin, YE Qin

Online:2008-01-05 Published:2008-01-05

摘要/Abstract

摘要：

在氮源限制基本培养基中连续培养大肠杆菌DH5α及其乙酸耐受突变株DA19。与DH5α相比，突变株DA19降低了葡萄糖的消耗，减少了乙酸和丙酮酸的生成，提高了菌体关于葡萄糖的得率。利用物料平衡和代谢反应的化学计量关系，分析了二者在比生长速率0.13 h^-1下的稳态代谢流分布。与DH5α相比，DA19的三羧酸循环流量高，酵解途径的流量低，从而减少了乙酸等副产物的分泌，反映了能量代谢效率的明显提高。比较了二者异柠檬酸裂解酶、6-磷酸葡萄糖脱氢酶、磷酸果糖激酶、异柠檬酸脱氢酶和乙酸激酶的活性，酶活变化与代谢流结果基本一致。

关键词:

大肠杆菌, 乙酸, 代谢流, 酶活

Abstract:

Escherichia coli DH5α and its acetate-tolerant mutant DA19 were continuously cultured in nitrogen-limited defined media.Compared with DH5α, DA19 showed improved growth yield due to decreased specific glucose consumption rate and formation of less acetic acid and pyruvate at a similar dilution rate.Based on mass balance and metabolic reaction stoichiometry, the metabolic flux distribution in DH5α and DA19 at a dilution rate of 0.13 h^-1 was calculated.Compared with DH5α, DA19 had a higher flux of tricarboxylic acid cycle and a lower flux of Embden-Meyerhof-Parnas pathway so it decreased the secretion rate of by-products, such as acetate and pyruvate.This indicated that DA19 had higher efficiency in energy metabolism. The activities of isocitrate lyase, 6-phosphoglucose dehydrogenase, phosphofructokinase, isocitrate dehydrogenase and acetokinase were measured, and the difference of activities between the two strains were consistent with the difference of metabolic fluxes.

Key words:

大肠杆菌, 乙酸, 代谢流, 酶活

张艳军, 张晓云, 李志敏, 叶勤. 大肠杆菌及其耐乙酸突变菌的连续培养和代谢流比较
[J]. 化工学报, 2008, 59(1): 160-166.

ZHANG Yanjun, ZHANG Xiaoyun, LI Zhimin, YE Qin. Comparison of metabolic fluxes in Escherichia coli and its acetate-tolerant mutant in continuous culture
[J]. CIESC Journal, 2008, 59(1): 160-166.

[1]	何瑞宁, 邹昀, 石萌, 李洋, 徐晶, 童张法. 固载离子液体［HSO₃-BMIM］［HSO₄］/SiO₂的制备及其催化乙酸乙醇酯化反应的研究[J]. 化工学报, 2022, 73(9): 3880-3894.
[2]	苏畅, 冯晓博, 张立云, 陈峰, 赵小燕, 曹景沛. 四乙基氢氧化铵改性对HMOR分子筛结构及二甲醚羰基化性能的影响[J]. 化工学报, 2022, 73(2): 712-721.
[3]	冯晓博, 刘天龙, 赵小燕, 曹景沛. 合成气与二甲醚为原料直接制乙醇催化反应研究进展[J]. 化工学报, 2021, 72(8): 3958-3967.
[4]	鲁秋实, 叶光华, 周兴贵. 半间歇釜式反应器安全高效操作的数值优化策略[J]. 化工学报, 2021, 72(2): 975-983.
[5]	朱林, 韩威, 李文松, 邬长城, 李芳, 薛伟, 王延吉. [BMIm]Br离子液体辅助HZSM-5催化乙酸环己酯高选择性水解反应[J]. 化工学报, 2020, 71(4): 1609-1617.
[6]	刘燕青, 胡听听, 鲁落义, 王维, 邹昀, 童张法. PDMS/ZSM-5膜的制备及渗透汽化分离水中乙酸正丁酯和乙酸乙酯[J]. 化工学报, 2020, 71(2): 843-853.
[7]	徐浩,李洋,夏成康,何瑞宁,邹昀,童张法. 吡啶硫酸氢盐离子液体催化甘油与乙酸酯化反应动力学[J]. 化工学报, 2020, 71(11): 5178-5187.
[8]	邱松发, 许斌华, 林冠权, 周新华, 陈铧耀, 周红军. 2,4-D/CMC接枝物纳米粒子的制备与缓释性能研究[J]. 化工学报, 2019, 70(5): 2007-2015.
[9]	张志刚, 张德彪, 张亲亲, 张弢, 杨茹, 李文秀. 基于COSMO-RS方法筛选离子液体分离乙酸乙酯-乙腈共沸物[J]. 化工学报, 2019, 70(1): 146-153.
[10]	金浩, 陆佳伟, 汤吉海, 张竹修, 费兆阳, 刘清, 陈献, 崔咪芬, 乔旭. 带侧线反应精馏-渗透汽化生产乙酸乙酯集成过程模拟与分析[J]. 化工学报, 2018, 69(8): 3469-3478.
[11]	任杰, 胡望伟, 袁海宽, 慎炼. Ni₂P/SiO₂催化剂制备及其乙酸加氢制乙醇催化性能评价[J]. 化工学报, 2017, 68(8): 3082-3088.
[12]	牟春霞, 张时雨, 邹昀, 刘香君, 董颜箔, 崔学民, 童张法. 疏水SiO₂填充PDMS膜分离水中乙酸正丁酯的性能[J]. 化工学报, 2017, 68(6): 2407-2414.
[13]	徐大勇, 洪亚军, 唐海, 程维明, 宋珍霞, 占玲玲, 姚巧凤. 柠檬酸和谷氨酸N，N-二乙酸优化处理污泥重金属[J]. 化工学报, 2017, 68(6): 2535-2545.
[14]	周峰, 陈长旭, 许春建. 乙酸异戊酯+异戊醇和乙酸异戊酯+正己醇体系汽液平衡[J]. 化工学报, 2017, 68(2): 560-566.
[15]	石磊, 姚杰, 朱文良, 刘中民. 磺酸树脂催化甲缩醛一步羰化制高附加值甲氧基乙酸甲酯[J]. 化工学报, 2017, 68(10): 3739-3746.