Measurement and correlation of viscosities of binary mixtures of N,N-dimethylformamide with ethanol, propanol, ethylene glycol or 1,2-propanediol

doi:10.11949/j.issn.0438-1157.20170475

Abstract

Abstract:

The viscosities of binary mixtures consisting of ethanol, propanol, ethylene glycol or 1,2-propanediol with N,N-dimethylformamide (DMF) were determined for the whole range of compositions at 288.15-313.15 K under atmospheric pressure by using Ubbelohde viscometer. The excess molar viscosity (△η) and excess Gibbs energy of activation of viscous flow (△G^*E) were calculated from the experimental data, and correlated by Redlich-Kister equation. The viscosities of binary mixtures were correlated and predicted with four different expressions (Frenkel, Grunberg-Nissan, Katti-Chaudhari and McAllister model). It has been using the theory of Eyring method to calculate the thermodynamic functions of activation of viscous flow, such as the flow activation free energy, the activation enthalpy and entropy. The results show that both △η and △G^*E are negative over the whole mole fraction range in the temperature range studied for all of the binary mixtures, and the deviation is greater as temperature decreases. All the viscosity deviations reached the minimum values at x₁(DMF)≈0.3. The three-body McAllister semi-empirical equation was found to be the best correlation to represent the viscosities of all binary mixtures, in which the average relative errors between predicted and experimental data were minimum. The differences of intermolecular interaction between monohydric and dibasic alcohol with DMF were compared and analyzed.

Key words: N,N-dimethylformamide, viscosity, excess molar viscosity, excess Gibbs energy of activation of viscous flow, activation enthalpy, activation entropy

摘要：

在288.15~313.15 K和常压下，利用乌氏黏度计测定了N，N-二甲基甲酰胺（DMF）分别与乙醇、丙醇、乙二醇和1，2-丙二醇组成的二元系全浓度范围内的黏度，计算了过量黏度△η和过量流动活化自由能△G^*E。用Redlich-Kister方程对过量黏度进行了关联；用黏度模型如Frenkel方程，Grunberg-Nissan方程，Katti-Chaudhari方程和McAllister方程对实验黏度数据进行了关联和预测，并利用Eyring理论方法计算了流动活化自由能、活化焓和活化熵等热力学函数。结果表明，4个二元系的过量黏度和过量流动活化自由能均为负值，且都随温度降低而偏差增大。过量黏度最低值均发生在DMF摩尔分数约为0.3处。McAllister模型对黏度数据的关联结果最好，预测值与实验值的平均相对偏差最小。比较并分析了DMF与一元醇和二元醇之间分子相互作用的差异。。

关键词: N,N-二甲基甲酰胺, 黏度, 过量黏度, 过量流动活化自由能, 活化焓, 活化熵

CLC Number:

O642

LING Jinlong, WANG Junyi, HUANG Huibo, SUN Laiyu, LU Xinyue. Measurement and correlation of viscosities of binary mixtures of N,N-dimethylformamide with ethanol, propanol, ethylene glycol or 1,2-propanediol[J]. CIESC Journal, 2017, 68(11): 4043-4053.

凌锦龙, 王俊毅, 黄慧波, 孙来玉, 陆欣悦. N,N-二甲基甲酰胺+醇二元混合物的黏度测定与关联[J]. 化工学报, 2017, 68(11): 4043-4053.

References 30

[1]	LAN G J, XU Q X, SUN S Y, et al. Thermodynamic properties and spectral investigation of dilute sulfur dioxide in binary system N,N-dimethylformamide + diethylene glycol[J]. Fluid Phase Equilibria, 2015, 389:74-82.
[2]	ZAREI H, GOLROUDBARI S A, BEHROOZI M. Experimental studies on volumetric and viscometric properties of binary and ternary mixtures of N,N-dimethylacetamide, N-methylformamide and propane-1,2-diol at different temperatures[J]. Journal of Molecular Liquids, 2013, 187:260-265.
[3]	UDDIN M H, KHAN M Z H, RAHMAN M H, et al. Volumetric and viscometric properties observed for the mixtures of DMF (N,N-dimethyl formamide) and other alcohols (butanol and 1-propanol)[J]. Physics and Chemistry of Liquids, 2014, 52(2):251-261.
[4]	BHUIYAN M M H, UDDIN M H. Excess molar volumes and excess viscosities for mixtures of N,N-dimethylformamide with methanol, ethanol and 2-propanol at different temperatures[J]. Journal of Molecular Liquids, 2008, 138:139-146.
[5]	YANG C S, SUN Y, HE Y F, et al. Volumetric properties and viscosities of binary mixtures of N,N-dimethylformamide with methanol and ethanol in the temperature range (293.15 to 333.15) K[J]. J. Chem. Eng. Data, 2008, 53(1):293-297.
[6]	张蓉蓉, 窦茂斌, 袁恩先, 等. 均三甲苯/二异丁基甲醇混合溶剂黏度测定及关联[J]. 化工学报, 2015, 66(9):3377-3382. ZHANG R R, DOU M B, YUAN E X, et al. Measurement and correlation of viscosities of mixed solvents 1,3,5-trimethylbenzene and diisobutylcarbinol[J]. CIESC Journal, 2015, 66(9):3377-3382.
[7]	ALMASI M. Densities and viscosities of the mixtures (formamide +2-alkanol):experimental and theoretical approaches[J]. J. Chem. Thermodynamics, 2014, 69:101-106.
[8]	KONDAIAH M, SREEKANTH K, SRAVANA KUMAR D, et al. Densities, viscosities, and excess properties for binary mixtures of ethylene glycol with amide at 308.15 K[J]. J. Therm. Anal. Calorim., 2014, 118:475-483.
[9]	MOOSAVI M, MOTAHARI A, OMRANI A, et al. Thermodynamic study on some alkanediol solutions:measurement and modeling[J]. Thermochimica Acta, 2013, 561:1-13.
[10]	MANFREDINI M, MARCHETTI A, SIGHINOLFI S, et al. Kinematic viscosities of binary liquid mixtures of 2-butanone with 1,2-propanediol[J]. Journal of Solution Chemistry, 2002, 31(3):235-252.
[11]	NAIN A K. Densities and volumetric properties of (formamide + ethanol, or 1-propanol, or 1,2-ethanediol, or 1,2-propanediol) mixtures at temperatures between 293.15 K and 318.15 K[J]. J. Chem. Thermodynamics, 2007, 39:462-473.
[12]	ZEMANKOVA K, TRONCOSO J, ROMANI L. Excess volumes and excess heat capacities for alkanediol + water systems in the temperature interval (283.15-313.15 K)[J]. Fluid Phase Equilibria, 2013, 356:1-10.
[13]	ZIVKOVIC E M, KIJEVCANIN M L, RADOVIC I R, et al. Viscosities and refractive indices of binary systems acetone +1-propanol, acetone +1,2-propanediol and acetone +1,3-propanediol[J]. Chem. Ind. Chem. Eng. Q., 2014, 20(3):441-455.
[14]	JÓ?WIAK M, TYCZY?SKA M, BALD A. The physicochemical properties and viscosity behavior of crown ether 18C6 in the mixture of water with N,N-dimethylformamide[J]. Journal of Molecular liquids, 2017, 229:520-529.
[15]	BENNETT V, DIKIO C W, ANGAYE S S, et al. Interaction of 1-butyl-3-methylimidazolium hexafluorophate with N,N-dimethylformamide:density and viscosity measurements[J]. Journal of Molecular Liquids, 2016, 219:661-666.
[16]	HASSEIN-BEY-LAROUCI A, IGOUJILEN O, AITKACI A, et al. Dynamic and kinematic viscosities, excess volumes and excess Gibbs energies of activation flow in the ternary mixture 1-propanol +N,N-dimethylformamide + chloroform at temperatures between 293.15 K and 323.15 K[J]. Thermochimica Acta, 2014, 589:90-99.
[17]	李丹, 方文军, 刘莉, 等. N-甲基哌嗪与乙酸乙酯、乙酸丁酯二元混合体系在298.15~313.15 K的体积及黏度性质[J]. 高等学校化学学报, 2013, 34(8):1924-1928. LI D, FANG W J, LIU L, et al. Volumetric and viscous properties for binary mixtures of N-methylpiperazine with ethyl acetate or butyl acetate from 298.15 K to 313.15 K[J]. Chemical Journal of Chinese Universities, 2013, 34(8):1924-1928.
[18]	QIAO Y, YAN F Y, XIA S Q, et al. Densities and viscosities of 1-butyl-3-methylimidazolium hexafluorophosphate[bmim] [PF6] + CO2 binary system:determination and correlation[J]. Chinese Journal of Chemical Engineering, 2013, 21(11):1284-1290.
[19]	CHOUDHARY D S, LADOLE C A, ASWAR A S. Interaction of 5-chloro-2-hydroxy-3-nitroacetophenone in N,N-dimethylformamide at various temperatures:a viscometric, volumetric and ultrasonic study[J]. Proc. Natl. Acad. Sci., India, Sect. A Phys. Sci., 2015, 85(2):221-226.
[20]	KESHAPOLLA D, GARDAS R L. Study on solvation behavior of benzyl methyl ammonium carboxylate ionic liquids in N,N-dimethylformamide by physicochemical properties[J]. J. Solution Chem., 2015, 44:469-494.
[21]	ALKHALDI K H A E, AL-JIMAZ A S, ALTUWAIM M S. Densities, ultrasonic speeds and refractive indices of phenetole with N-methyl-2-pyrrolidone, N,N-dimethylformamide and tetrahydrofuran binary mixtures at different temperatures[J]. J. Chem. Thermodynamics, 2016, 103:249-256.
[22]	NAIN A K. Densities, ultrasonic speeds, viscosities and excess properties of binary mixtures of methyl methacrylate with N,N-dimethylformamide and N,N-dimethylacetamide at different temperatures[J]. J. Chem. Thermodynamics, 2013, 60:105-116.
[23]	PANDARINATH S N, SANJEEVAN J K. Excess molar volumes and deviations in viscosity of binary mixtures of N,N-dimethylformamide with aniline and benzonitrile at (298.15, 303.15, 308.15, and 313.15) K[J]. J. Chem. Eng. Data, 2003, 48:972-976.
[24]	VENKATESU P. Thermophysical contribution of N,N-dimethylformamide in the molecular interactions with other solvents[J]. Fluid Phase Equilibria, 2010, 298:173-191.
[25]	SHOKOUHI M, JALILI A H, HOSSEINI-JENAB M, et al. Thermo-physical of aqueous solutions of N,N-dimethylformamide[J]. Journal of Molecular liquids, 2013, 186:142-146.
[26]	MOHAMMAD A A, ALKHALDI K H A E, ALTUWAIM M S, et al. Viscosity and surface tension of binary systems of N,N-dimethylformamide with alkan-1-ols at different temperatures[J]. J. Chem. Thermodynamics, 2013, 56:106-113.
[27]	MOHAMMAD A A, ALKHALDI K H A E, ALTUWAIM M S, et al. Effect temperature and chain length on the viscosity and surface tension of binary systems of N, N-dimethylformamide with 1-octanol, 1-nonanol and 1-decanol[J]. J. Chem. Thermodynamics, 2014, 74:7-15.
[28]	NAIN A K. Ultrasonic and viscometric studies of molecular interaction in binary mixtures of formamide with ethanol, 1-propanol, 1,2-ethanediol and 1,2-propanediol at different temperatures[J]. Journal of Molecular Liquids, 2008, 140:108-116.
[29]	DAS D, SALHI H, DALLEL M, et al. Viscosity Arrhenius activation energy and derived partial molar properties in isobutyric acid+water binary mixtures near and far away from the critical temperature, 302.15 to 313.15K[J]. J. Solution Chem., 2015, 44:54-66.
[30]	SANZ L F, GONZALEZ J A, FUENTE I G D L, et al. Thermodynamics of mixtures with strong negative deviation Raoult's law (XIV):Density, permittivity, refractive index and viscosity data for the methanol + cyclohexylamine mixture at (293.15-303.15)K[J]. Thermochimica Acta, 2016, 631:18-27.