Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant

doi:10.3969/j.issn.0438-1157.2014.12.059

CIESC Journal ›› 2014, Vol. 65 ›› Issue (12): 5082-5089.DOI: 10.3969/j.issn.0438-1157.2014.12.059

Previous Articles Next Articles

Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant

TIAN Xiujuan¹, WANG Zhongwei¹, YU Qing¹, GAO Jun²

1. School of Materials Science and Engineering, Shandong University of Science and Technology, Qingdao 266590, Shandong, China;
2. School of Chemical and Environmental Engineering, Shandong University of Science and Technology, Qingdao 266590, Shandong, China

Received:2014-04-30 Revised:2014-07-18 Online:2014-12-05 Published:2014-12-05
Supported by:
supported by the National Natural Science Foundation of China(21103099).

含磷阻燃剂阻燃环氧树脂热降解动力学

田秀娟¹, 王忠卫¹, 于青¹, 高军²

1. 山东科技大学材料科学与工程学院, 山东青岛 266590;
2. 山东科技大学化学与环境工程学院, 山东青岛 266590

通讯作者: 王忠卫
基金资助:
国家自然科学基金项目(21103099).

Abstract

Abstract: Phosphorus-containing epoxy resin was prepared from 2-diphenylphosphonothioic-1,4-diphenol (DPO-HQ, as flame retardant). The thermal stabilities of neat epoxy resin (EP) and flame retardant modified epoxy resin (FR-EP) were studied with thermogravimetric analysis (TGA) at different heating rates. Kinetics model and model-free kinetics (MFK) were established based on TGA data. The serviceability values of model kinetics and model-free kinetics to epoxy resin and flame retardant modified epoxy resin were compared and analyzed. The initial degradation temperature of flame retardant modified epoxy resin slightly decreased with introduction of flame retardant, but the yield of char residue increased. The model kinetics of EP and FR-EP determined by using the Flynn-Wall-Ozawa method and the Coats-Redfern method were not applicable to epoxy resin system. MFK was more suitable to describe and predict the degradation behavior of epoxy resin and flame retardant modified epoxy resin.

Key words: epoxy resins, flame retardant, thermal degradation, model-free-kinetics, thermal stabilities

摘要： 以2-二苯基膦酰基-1,4-苯二酚(DPO-HQ)为阻燃剂制备了阻燃环氧树脂,利用动态热重分析法(TGA)研究了纯环氧树脂(EP)和阻燃环氧树脂(FR-EP)在不同升温速率下的热稳定性,建立了EP和FR-EP体系的动力学模型和非模型动力学(MFK),并对比分析了模型动力学和非模型动力学对于描述EP体系和FR-EP体系的适用性.结果表明:阻燃剂的引入降低了环氧树脂初始降解温度,但增加了残炭率.由Flynn-Wall-Ozawa方法和Coats-Redfern方法建立的模型动力学表征EP和FR-EP体系高温降解过程中误差较大,而非模型动力学能更准确地预测和描述EP和FR-EP体系的高温降解行为.

关键词: 环氧树脂, 阻燃剂, 热降解, 非模型动力学, 热稳定性

CLC Number:

O631

TIAN Xiujuan, WANG Zhongwei, YU Qing, GAO Jun. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant[J]. CIESC Journal, 2014, 65(12): 5082-5089.

田秀娟, 王忠卫, 于青, 高军. 含磷阻燃剂阻燃环氧树脂热降解动力学[J]. 化工学报, 2014, 65(12): 5082-5089.

References 22

[1]	Giannakopoulos G, Masania K, Taylor A C. Toughening of epoxy using core-shell particles [J]. J. Mater. Sci., 2011, 46(2): 327-338
[2]	Lu Lingang(卢林刚), Li Ling(李铃), Shu Zhongjun(舒仲俊), Dong Xilin(董希琳), Gao Weiying(高维英), Yu Baogang(于宝刚). Preparation and property of halogen-free phosphorous flame retardant epoxy resin [J]. Polym. Mater. Sci. Eng.(高分子材料科学与工程), 2010, 26(5): 158-161
[3]	Ching H L, Sheng L C, Tsai P W. High-Tg transparent poly(ether sulfone)s based on phosphinated bisphenols [J]. Chem. Phys., 2011, 212: 455-464
[4]	Yuan Q X, Xu Y Z, Jia L. Synthesis of novel phosphorus-containing epoxy hardeners and thermal stability and flame-retardant properties of cured products [J]. J. Appl. Polym. Sci., 2012, 125: 1219-1225
[5]	Wu Qingyu(伍清浴). Synthesis and Application Study on Several Reactive Flame Retardant of Diphenylphosphine Oxide Derivatives [D]. Shandong: Shandong University of Science and Technology, 2013
[6]	Huang Nianhua(黄年华), Zhang Qiang(张强), Li Zhihua(李治华), Xiong Qi(熊奇). Flame retardant and thermal degradation kinetics of novel copolyester containing phosphorus linked pendant groups [J]. Chem. J. Chinese University(高等学校化学学报), 2007, 28(11): 2219-2224
[7]	Wang Q F, Shi W F. Kinetics study of thermal decomposition of epoxy resins containing flame retardant components [J]. Polym. Degra. Stab., 2006, 91: 1747-1754
[8]	Li Q, Guan C X, Zhang A Q, Chen D H, Qing Z B. Thermal stabilities and the thermal degradation kinetics of polyimides [J]. Polym. Degra. Stab., 2004, 84: 369-373
[9]	Wang Dandan(王丹丹), Wang Peng(王鹏). Thermal degradation kinetics of poly(benzobisoxazole imide) [J]. Acta Polymerica Sinica(高分子学报), 2013(2): 154-158
[10]	Wu B, Wang Y Z, Wang X L, Yang K K, Jin Y D, Zhao H. Kinetics of thermal oxidative degradation of phosphorus-containing flame retardant copolyesters [J]. Polym. Degra. Stab., 2002, 76: 401-409
[11]	Lu Liming(陆立明). Thermal Analysis in Practice(热分析应用基础)[M]. Shanghai: Donghua University Press, 2010: 89-92
[12]	Li Heng(李恒), Wang Dehai(王德海), Qian Xiaqing(钱夏青). Curing kinetics of epoxy resin by non-isothermal DSC method [J]. Journal of Solid Rocket Technology(固体火箭技术), 2013, 36(2): 266-284
[13]	Gan Li(甘丽), Sun Zhijie(孙志杰), Gu Yizhuo(顾轶卓). Epoxy resin curing reaction studied by dynamic and isothermal model free kinetics [J]. Acta Polymerica Sinica(高分子学报), 2010(8): 1016- 1022
[14]	Flynm J H. The "temperature integral"—its use and abuse [J]. Thermochim Acta, 1997, 300: 83-92
[15]	Coats A W, Redern J P. Kinetic parameters from the thermogravimetric data [J]. Nature (Lond), 1964, 201: 68-69
[16]	Liu Xiaodong(刘晓东),Cheng Yu(程珏),Lin Xin(林欣),Zhang Junying(张军营). Curing kinetics of epoxy resins/amine system and epoxy/episulfide resin/amine system [J]. CIESC Journal(化工学报), 2013, 64(11): 4046-4052
[17]	Liaw D J. Synthesis of polyphosphates by the polyaddition of bisphenol-S diglycidyl ether and aryl phosphorodichloridates [J]. J. Polym. Sci., Part A: Polym. Chem., 1997, 35:2365-2375
[18]	Wang L S, Wang X L, Yan G L. Synthesis, characterization and flame retardance behaviour of poly(ethylene terephthalate) copolymer containing triaryl phosphine oxide [J]. Polym. Degr. Stab., 2000, 69(1): 127-130
[19]	Balabanovich A I, Levchik G F, Levchiky S V, Engelmann J. Fire retardant synergism between cyclic diphosphonate ester and melamine in poly(butylene terephthalate) [J]. J. Fire Sci., 2003, 1(20): 71-83
[20]	Olive Fischer, Doris Pospiech, Andreas Korwitz, Karin Share, Liane Häußler, Peter Fridel, Dieter Fischer, Christina Harnisch, Yana Bykov, Manfred Döring. Synthesis and properties of phosphorus polyesters with systematically altered phosphorus environment [J]. Polym. Degr. Stab., 2011, 96: 2198-2208
[21]	Zhu H M, Yan J H, Jiang X G, Lai Y E, Cen K F. Study on pyrolysis of typical medical waste materials by using TG-FTIR analysis [J]. J. Hazard. Mater., 2008, 153: 670-676
[22]	Tang Yuanwang(唐远旺). Evolved Gas Analysis (逸出气体分析)[M].Shanghai: Donghua University Press, 2009: 12-22

Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant

含磷阻燃剂阻燃环氧树脂热降解动力学

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 22

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Shuai WANG, Fukai YANG, Xinyu XU. Preparation and characterization of flame retardant bio-based polyols polyurethane foam [J]. CIESC Journal, 2023, 74(3): 1399-1408.
[2]	JI Rongbin, CHEN Ting, PENG Chaohua, XIA Long, CHEN Guorong, LUO Wei'ang, ZENG Birong, XU Yiting, YUAN Conghui, DAI Lizong. Flame retardant epoxy resin composites modified with organophosphorus and boron hybrid molecules [J]. CIESC Journal, 2021, 72(7): 3856-3868.
[3]	Rui ZHAI,Zhao YANG,Yong ZHANG,Zijian LYU,Yubo CHEN. Study on combustion and flame retardant mechanism of combustible working fluid ammonia [J]. CIESC Journal, 2021, 72(10): 5424-5429.
[4]	LIAN Hanqing, ZHENG Yuying, QIU Hongfeng. Preparation and performance characteristic of MAPP flame-retardant EVA foamed composites [J]. CIESC Journal, 2016, 67(7): 3055-3062.
[5]	HU Wentian, YANG Rong, XU Liang, SONG Yan, LI Jinchun. Synthesis, properties and application of reactive nitrogen-phosphorus flame retardant [J]. CIESC Journal, 2015, 66(5): 1976-1982.
[6]	CHEN Zhijie, ZHENG Yuying, QIU Hongfeng. Preparation, flame retardant and mechanical properties of TPS/EVA foam composites [J]. CIESC Journal, 2015, 66(3): 1221-1227.
[7]	BAI Sihong, CHEN Tong, QI Zhifu, LIU Jie, LU Shengyong, BO Zheng, LI Xiaodong. Effect of carrier gas flow rate and heating rate on thermal desorption of polychlorinated biphenyls in contaminated soil [J]. CIESC Journal, 2014, 65(6): 2256-2263.
[8]	JIANG Wei，YAO Shanshan. Preparation and flame retardancy of a novel phosphorous-containing flame retardant [J]. Chemical Industry and Engineering Progree, 2014, 33(08): 2140-2143.
[9]	QIAN Wei1，3，LI Xiangzhou1，2，WU Zhiping1，FANG Congcong4，YIN Kai1，JIA Kejing1. Preparation of tea saponin based intumescent flame retardant and its application in coatings [J]. Chemical Industry and Engineering Progree, 2014, 33(01): 198-203.
[10]	WANG Qidong, SHI Tiejun, XU Guomei. Synthesis,characterization of PT-ala resin and thermal degradation kinetics of its polymer [J]. CIESC Journal, 2013, 64(10): 3851-3857.
[11]	LI Qingying，XIA Zhengbin，FAN Fangqiang，CHEN Junchi. Research progress in reactive phosphorus-containing flame retardant [J]. Chemical Industry and Engineering Progree, 2012, 31(08): 1751-1755.
[12]	WANG Guangheng，YANG Shuilan，NIU Hongmei，LIU Guoyang. Study on the properties of environmental friendly flame retardant high resilience polyurethane foam [J]. Chemical Industry and Engineering Progree, 2012, 31(05): 1076-1081.
[13]	SU Haixiao1，3，HOU Xufeng2，ZHONG Liu 1，LIU Zhiguo1，3. Synthesis，characterization and thermal stability of resorcinol bis[di(pentaerythritol phosphate)] phosphate [J]. , 2011, 30(5): 1054-.
[14]	OU Yuxiang. Developments of organic phosphorus flame retardant industry in China [J]. , 2011, 30(1): 210-.
[15]	ZHANG Xiaoguang1，MENG Xianyan1，YE Ling2，TANG Jianhua1，LI Zhongming2. Properties of rigid polyurethane foams added with ammonium polyphosphate treated by coupling agent [J]. , 2010, 29(6): 1107-.