硝基苯电还原制备对氨基苯酚工艺过程

doi:10.3969/j.issn.0438-1157.2013.02.033

化工学报 ›› 2013, Vol. 64 ›› Issue (2): 656-662.DOI: 10.3969/j.issn.0438-1157.2013.02.033

硝基苯电还原制备对氨基苯酚工艺过程

钮东方, 郎超, 张新胜

华东理工大学化学工程联合国家重点实验室,上海200237

收稿日期:2012-08-07 修回日期:2012-09-02 出版日期:2013-02-05 发布日期:2013-02-05
通讯作者: 张新胜
作者简介:钮东方(1982—),男,讲师。

Preparation of p-aminophenol from electrochemical reduction of nitrobenzene

NIU Dongfang, LANG Chao, ZHANG Xinsheng

State Key Laboratory of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China

Received:2012-08-07 Revised:2012-09-02 Online:2013-02-05 Published:2013-02-05

摘要/Abstract

摘要： 采用固定床电解槽还原硝基苯制备对氨基苯酚,并对其工艺条件进行了优化。以铜网组成固定床电解槽阴极,镀铱钛网(DSA)作为阳极,在电流密度为1000 A·m^-2,阴极电解槽内流速为4.28 cm·s^-1,铜网厚度为10 mm,温度为85℃条件下,硝基苯还原的电流效率接近100%,对氨基苯酚的选择性可达到83%。电解液可循环套用5次,硫酸和氨水的消耗量降至原来的25%,硫酸铵和废水的排放量也减少了75%。采用扩散渗析法回收废弃电解液中的硫酸,以APS为阴离子交换膜,模拟液的流量为0.01 ml·min^-1、温度为20℃时,酸回收率达到61%,且对氨基苯酚和苯胺的透过率分别仅为1.4%和1.6%。

关键词: 硝基苯, 对氨基苯酚, 电化学还原, 电解液循环, 酸回收

Abstract: The packed bed cell was used in the preparation of p-aminophenol from the electrochemical reduction of nitrobenzene.The effects of current density, flow rate of catholyte, reactor thickness and temperature on electrolysis were studied.The results showed that under the conditions of 10 mm thickness of copper mesh as cathode, DSA as anode, current density 1000 A·m^-2, flow rate of catholyte 4.28 cm·s^-1 and temperature 85℃, current efficiency for nitrobenzene reduction was almost 100%, and selectivity of p-aminophenol could reach 83%.The catholyte could be reused five times for electrolysis, which resulted in that the lowered consumptions of sulfuric acid and ammonia approximately to 25% of the original value, and reduced discharge amounts of ammonia sulfate and effluent by 75%.Diffusion dialysis was used to recycle sulfuric acid from the spent catholyte.The results showed that under the conditions of APS as anion exchange membrane, flow rate of simulated solution 0.01 ml·min^-1 and temperature 20℃, recovery of sulfuric acid was up to 61%, and transmissivities for p-aminophenol and aniline were only 1.4% and 1.6%, respectively.

Key words: nitrobenzene, p-aminophenol, electrochemical reduction, electrolyte circulation, sulfuric acid recovery

中图分类号:

TQ151.5

钮东方, 郎超, 张新胜. 硝基苯电还原制备对氨基苯酚工艺过程[J]. 化工学报, 2013, 64(2): 656-662.

NIU Dongfang, LANG Chao, ZHANG Xinsheng. Preparation of p-aminophenol from electrochemical reduction of nitrobenzene[J]. CIESC Journal, 2013, 64(2): 656-662.

参考文献 16

[1]	Li Siyi(李思意), Liu Youzhi(刘有智), Zhang Qiaoling(张巧玲),Bai Mei(白梅).Review on preparation methods of p-aminophenol[J].Fine and Specialty Chemicals(精细与专用化学品), 2011, 19(12):52-54
[2]	Cui Yongmei(崔咏梅), Yuan Da(袁达), Wang Yanji(王延吉), Zhao Xinqiang(赵新强).Hydrogenation of nitrobenzene to p-aminophenol using acidic ionic liquid as catalyst[J].CIESC Journal(化工学报), 2009, 60(2):345-350
[3]	Wang Shufang, He Beibei, Wang Yanji, Zhao Xinqiang.MgAPO-5-supported Pt-Pd-based novel catalyst for the hydrogenation of nitrobenzene to p-aminophenol[J].Catalysis Communications, 2012, 24:109-113
[4]	Deshpande A, Figueras F, Kantam M L, Ratnam K J, Reddy R S, Sekhar N S.Environmentally friendly hydrogenation of nitrobenzene to p-aminophenol using heterogeneous catalysts[J].Journal of Catalysis, 2010, 275(2):250-256
[5]	Liu Lixiu(刘丽秀), Qian Jianhua(钱建华), Zhang Mingwei(张明伟).The study on the synthesis of p-aminophenol[J].Journal of Beijing Institute of Petro-chemical Technology(北京石油化工学院学报), 2007, 15(3):5-7
[6]	Zhao Guoping(赵国平), Chen Guohui(陈国辉).Nitrobenzene being reduced to p-aminophenol through indirect electrolysis[J].Guangdong Chemical Industry(广东化工), 2008, 35(1):34-37
[7]	Polat K, Aksu M L, Pekel A T.Electroreduction of nitrobenzene to p-aminophenol using voltammetric and semipilotscale preparative electrolysis techniques[J].Journal of Applied Electrochemistry, 2002, 32:217-223
[8]	Smeltzer J C, Fedkiw P S.Reduction of nitrobenzene in a paralle-plate reactor(Ⅰ):Differential conversion using periodic cell-voltage control[J].Journal of the Electrochemical Society, 1992, 139(5):1358-1366
[9]	Fedkiw P S, Chao J C.Selectivity modification in electroorganic reactions by periodic current control:electroreduction of nitrobenzene[J].American Institute of Chemical Engineers, 1985, 31(9):1578-1580
[10]	Ma Chun'an(马淳安), Chu Youqun(褚有群), Tong Shaoping(童少平), Mao Xinbiao(毛信表), Li Meichao(李美超), Zhu Yinghong(朱英红).Green electrochemical synthesis of p-aminophenol and industrialization[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2004, 55(12):1971-1975
[11]	Sun Y P, Xu W L, Scott K.A study of the electrochemical reduction of nitrobenzene to p-aminophenol in a packed bed electrode reactor[J].Electrochimic Acta, 1993, 38(13):1753-1759
[12]	Abbar A H, Sulaymon A H, Jalhoom M G.Scale-up of a fixed bed electrochemical reactor consisting of parallel screen electrode used for p-aminophenol production[J].Electrochimica Acta, 2007, 53:1671-1679
[13]	Li Baoshan(李保山), Niu Yushu(牛玉舒), Zhai Yuchun(翟玉春), Quan Mingxiu(全明秀), Hu Zhuangqi(胡庄麒).Nitrobenzene being reduced to paraaminophenol through electrolysis on foamed nickel cathodes[J].Journal of Petrochemical Universities(石油化工高等学校学报), 2000, 13(2):1-5
[14]	Ding Ping(丁平), Zhu Xiaomeng(朱晓蒙), Yang Xiaoqin(杨晓琴), Zhu Zhongnan(朱中南), Yuan Weikang(袁渭康).Preparation of p-aminophenol by the electrochemical reduction of nitrobenzene in a packed bed reactor[J].Journal of East China University of Science and Technology(华东理工大学学报), 1994, 20(4):439-443
[15]	Sun Yanping(孙彦平), Xu Wenlin(许文林), Yuan Weikang(袁渭康).Study on electrochemical fixed bed reactor:electrochemical reduction of nitrobenzene to produce p-aminophenol[J].Journal of Chemical Industry and Engineering(China)(化工学报), 1993, 44(4):389-394
[16]	Ma Chun'an(马淳安), Zhang Wenkui(张文魁), Huang Hui(黄辉), Gan Yongping(甘永平).Study on electrochemical reduction properties of nitrobenzene[J].Electrochemistry(电化学), 1999, 5(4):395-400

硝基苯电还原制备对氨基苯酚工艺过程

Preparation of p-aminophenol from electrochemical reduction of nitrobenzene

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 16

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[2]	李超凡, 温玉娟, 曹楠, 孙东, 宋晓明, 杨悦锁. 耐低温对硝基苯酚降解菌的降解动力学研究[J]. 化工学报, 2021, 72(3): 1692-1701.
[3]	樊鹏, 陈杰, 关小红, 乔俊莲. 过硫酸盐强化零价铁还原去除硝基苯的实验研究[J]. 化工学报, 2018, 69(5): 2175-2182.
[4]	余丽胜, 焦纬洲, 刘有智, 李苏霖, 李傲雯, 张敏. 超声强化铁碳微电解-Fenton法降解硝基苯废水[J]. 化工学报, 2017, 68(1): 297-304.
[5]	袁培新, 郑晨昱, 崔宏达, 万莹, 姚传广, 宋宏鑫, 邓盛元. 电沉积石墨烯的非共价功能化用于SPR核酸传感的协同增敏[J]. 化工学报, 2016, 67(S2): 245-254.
[6]	毛信表, 何峰强, 张寅旭, 陈松, 刘莹, 马淳安. 二元离子液体OMImBF₄/HMImPF₆中硝基苯的电化学还原[J]. 化工学报, 2016, 67(5): 1998-2004.
[7]	王晓娟, 毛信表, 李国华, 马淳安. WC/TiO₂纳米复合材料晶相形成机理及电催化性能[J]. 化工学报, 2016, 67(11): 4873-4877.
[8]	赵旭东, 张玉田, 黄宏亮, 刘大欢, 仲崇立. Zn₃-MOF用于硝基苯的高效荧光识别[J]. 化工学报, 2015, 66(8): 3248-3254.
[9]	张茜, 温玉娟, 杨悦锁, 杜新强, 郭辉. 土壤含水层处理系统去除对硝基酚[J]. 化工学报, 2015, 66(4): 1440-1448.
[10]	俸志荣, 焦纬洲, 刘有智, 许承骋, 郭亮, 余丽胜. 铁碳微电解处理含硝基苯废水[J]. 化工学报, 2015, 66(3): 1150-1155.
[11]	吕乐, 杨座国, 赵颖. 4-硝基苯胂酸合成反应的热力学计算机模拟[J]. 化工学报, 2014, 65(9): 3317-3322.
[12]	吕乐, 杨座国, 赵颖. 4-硝基苯胂酸合成反应的热力学计算机模拟[J]. 化工学报, 2014, 65(9): 0-0.
[13]	钮东方, 王海洋, 俞秋雁, 张新胜. 5-硝基苯并咪唑酮在铜网电极上还原制备5-氨基苯并咪唑酮[J]. 化工学报, 2014, 65(1): 292-297.
[14]	阮继锋, 孙金华, 郭耸, 平平. 硝酸对硝基苯热稳定性的影响机理[J]. 化工学报, 2013, 64(5): 1526-1531.
[15]	毕强，薛娟琴，于丽花，汪丛，于芳蕾，张桀. 基于Ti/SnO2阳极的电化学法降解对硝基苯酚[J]. 化工进展, 2013, 32(12): 3015-3020.