Steam flow resistance across horizontal tube bundle under vacuum condition

doi:10.3969/j.issn.0438-1157.2013.03.014

CIESC Journal ›› 2013, Vol. 64 ›› Issue (3): 886-890.DOI: 10.3969/j.issn.0438-1157.2013.03.014

Previous Articles Next Articles

Steam flow resistance across horizontal tube bundle under vacuum condition

SHEN Shengqiang, LIU Hua, FENG Yin, CHEN Shi, GONG Luyuan, LIU Rui, CHEN Xue

Key Laboratory for Sea Water Desalination of Liaoning Province, Dalian University of Technology, Dalian 116024, Liaoning, China

Received:2012-06-05 Revised:2012-11-16 Online:2013-03-05 Published:2013-03-05
Supported by:
supported by the Specialized Research Fund for the Doctoral Program of High Education(20110041110032)and the Natural Science Foundation of Liaoning Province(20102031).

真空条件下蒸汽横掠水平降膜管束的流动阻力

沈胜强, 刘华, 冯寅, 陈石, 龚路远, 刘瑞, 陈学

大连理工大学辽宁省海水淡化重点实验室,辽宁大连 116024

通讯作者: 沈胜强(1961—),男,博士,教授。
作者简介:沈胜强(1961—),男,博士,教授。
基金资助:
高等学校博士学科点专项科研基金项目(20110041110032);辽宁省自然科学基金项目(20102031)。

Abstract

Abstract: An experiment investigation of steam flow resistance across horizontal falling film tube bundle was carried out.Experiments were performed to simulate the flow process in a large horizontal falling film evaporator of MED desalination plant under the pressure from 12 kPa to 31 kPa and at the corresponding saturated steam temperature from 50℃ to 70℃ respectively.The results indicated that pressure drop of steam flowing across tube bundle with falling film was far greater than that through a plain tube bundle.Pressure drop coefficient not only was affected by vapor Reynolds number but also changed significantly with spray Reynolds number.From the experimental results a flow resistance correlation for steam flowing across horizontal tube bundle with falling film was proposed.

Key words: flow resistance, falling film, horizontal tube bundle

摘要： 建立了蒸汽横掠带有液体降膜流动的水平管束流动阻力实验台,对影响流动阻力的因素与规律进行了实验研究。实验在绝对压力为12～31 kPa的真空条件下进行,对应的水蒸气饱和温度为50～70℃,模拟了大型海水淡化装置中水平管降膜蒸发器的流动过程。实验结果显示,蒸汽掠过带有降膜流动的水平管束的压降远大于蒸汽横掠水平管束的流动阻力,流动阻力系数不仅与蒸汽流动Reynolds数有关,还与液体在水平管上降膜流动的Reynolds数有很大关联。提出了正三角形排列管束的蒸汽横掠降膜流动管束的阻力关系式。

关键词: 流动阻力, 降膜流动, 水平管管束

CLC Number:

TK219
TK312

SHEN Shengqiang, LIU Hua, FENG Yin, CHEN Shi, GONG Luyuan, LIU Rui, CHEN Xue. Steam flow resistance across horizontal tube bundle under vacuum condition[J]. CIESC Journal, 2013, 64(3): 886-890.

沈胜强, 刘华, 冯寅, 陈石, 龚路远, 刘瑞, 陈学. 真空条件下蒸汽横掠水平降膜管束的流动阻力[J]. 化工学报, 2013, 64(3): 886-890.

References 10

[1]	Ribatski G,Jacobi A M.Falling-film evaporation on horizontal tubes—a critical review[J].International Journal of Refrigeration,2005,28:635-653
[2]	Mu Xingsen(牟兴森),Yang Yong(杨勇),Shen Shengqiang(沈胜强).Experimental research of horizontal tube falling film evaporation in desalination[J].Journal of Thermal Science and Technology(热科学与技术),2011,10(4):291-296
[3]	Shen Shengqiang(沈胜强),Liang Gangtao(梁刚涛),Gong Luyuan(龚路远).Space distribution of heat transfer performance in horizontal tube falling film evaporator[J].CIESC Journal(化工学报),2011,62(12):3381-3385
[4]	Fujii T,Uehara H,Hirata K,Oda K.Heat transfer and flow resistance in condensation of low pressure steam flowing through tube bank[J].Int.J.Heat Mass Transfer,1972,15:247-260
[5]	Chisholm D.Pressure gradients due to friction during the flow of evaporating two-phase mixtures in smooth tubes and channels[J].Int. J. Heat Mass Transfer,1972,16:347-358
[6]	Ma Weimin(马卫民),Chen Xuejun(陈学俊),Zhang Mingyuan(张鸣远).An investigation on drag characteristics of two-phase flow across horizontal tube bundles[J].Power Engineering(动力工程),1994,14(3):25-30
[7]	Ma Weimin(马卫民),Zhang Mingyuan(张鸣远),Chen Xuejun(陈学俊).An investigation on drag characteristic of air-water two-phase flow across the vertical tube bundle in a shell and tube heat exchanger[J].Chinese Journal of Applied Mechanics(应用力学学报),1994,11(4):51-56
[8]	Salam B,McNeil D A,Burnside B M.Pressure drop measurements in a low pressure steam condenser with a horizontal bundle of staggered tubes[J].Applied Thermal Engineering,2004,24:1365-1379
[9]	Dowlati R,Kawaji M,Chan A M C.Two-phase cross flow and boiling heat transfer in horizontal tube bundles[J].J.Heat Transfer,1996,118(1):124-131
[10]	Engineering Sciences Data Unit. Crossflow pressure loss over banks of plain tubes in square and triangular arrays including effects of flow direction.London:ESDU,1979

[1]	Shumin ZHENG, Pengcheng GUO, Jianguo YAN, Shuai WANG, Wenbo LI, Qi ZHOU. Experimental and predictive study on pressure drop of subcooled flow boiling in a mini-channel [J]. CIESC Journal, 2023, 74(4): 1549-1560.
[2]	Wei LU, Ran MIAO, Zhigen WU, Changchun WU, Wei XIE. Experimental study on flow and heat transfer of non-Newtonian fluid in a corrugated double-tube heat exchanger [J]. CIESC Journal, 2022, 73(7): 2924-2932.
[3]	ZHANG Yi, ZHANG Guanmin, LIU Lei, LIANG Kai, QU Xiaohang, TIAN Maocheng. Gas-liquid falling film flow characteristics on surface of multi-row plane finned-tube heat exchanger: a 3D numerical study [J]. CIESC Journal, 2021, 72(S1): 278-294.
[4]	ZHANG Yashuang, LI Hong, CONG Haifeng, HAN Hongming, LI Xingang, GAO Xin. Numerical simulation of microwave-enhanced spiral liquid-bridge falling film evaporator [J]. CIESC Journal, 2021, 72(S1): 227-235.
[5]	Dan LIU, Yi CHENG, Mingyue HU, Qianyun SHENG, Hao ZHOU. Study on performance of serrated spiral finned tube banks under wet flue gas condition [J]. CIESC Journal, 2020, 71(2): 575-583.
[6]	Shanlin LIU, Xingsen MU, Shengqiang SHEN, Bin LIANG, Tianjie BAO, Bing NI. Experimental study on droplet flow pattern of horizontal tube falling film flow with low Reynolds number [J]. CIESC Journal, 2019, 70(12): 4565-4574.
[7]	YAN Hongzhi, HU Bin, WANG Ruzhu. Modeling and optimization of water-to-water falling film evaporator [J]. CIESC Journal, 2018, 69(S2): 68-75.
[8]	ZHONG Yingjie, HUANG Qi, DENG Kai, ZHAO Chuangyao, SU Yihua. Analysis of flow characteristics in triangular grooved channel by pulsating flow at low Reynolds number [J]. CIESC Journal, 2018, 69(9): 3806-3813.
[9]	ZHU Zhiqiang, YAN Changqi, WANG Jianjun, TIAN Chunping. Flow resistance characteristics in rod bundle channel under natural circulation condition [J]. CIESC Journal, 2018, 69(4): 1398-1404.
[10]	HUANG Qi, SI Chao, ZHAO Chuangyao, ZHONG Yingjie. Influence of channel height on resistance characteristics in triangular grooved channel by pulsating flow [J]. CIESC Journal, 2018, 69(12): 4990-5000.
[11]	JIANG Chun, CHEN Zhenqian. Numerical simulation of fluid flow and heat transfer characteristics of falling film evaporation outside horizontal tubes [J]. CIESC Journal, 2018, 69(10): 4224-4230.
[12]	LÜ Yang, DONG Yong, TIAN Luning, HAN Zhenan, SHEN Kai, CUI Lin, ZHANG Liqiang, LI Yuzhong. Dehumidification performance of wet flue gas in coal-fired power plant [J]. CIESC Journal, 2017, 68(9): 3558-3564.
[13]	LI Meijun, LU Yuan, ZHANG Shijie, XIAO Yunhan. Numerical study of local heat and mass transfer characteristics of falling films over horizontal tubes [J]. CIESC Journal, 2017, 68(4): 1364-1372.
[14]	TIAN Chunping, YAN Changqi, WANG Jianjun, XIONG Kun. Effect of inclination on flow resistance characteristic in narrow rectangular channel [J]. CIESC Journal, 2016, 67(9): 3633-3639.
[15]	ZUO Jian, XIE Yongfang, WANG Xiaoli, XIE Sen, YANG Chunhua. Liquid level optimal-setting for tube falling film evaporator based on exergy [J]. CIESC Journal, 2016, 67(3): 891-896.

Steam flow resistance across horizontal tube bundle under vacuum condition

真空条件下蒸汽横掠水平降膜管束的流动阻力

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 10

Related Articles 15

Recommended Articles

Metrics

Comments