Numerical study of solids behavior in fluidized bed with multi-immersed tubes

doi:10.3969/j.issn.0438-1157.2013.08.012

CIESC Journal ›› 2013, Vol. 64 ›› Issue (8): 2788-2793.DOI: 10.3969/j.issn.0438-1157.2013.08.012

Previous Articles Next Articles

Numerical study of solids behavior in fluidized bed with multi-immersed tubes

YANG Chunzhen¹, DUAN Yufeng², SUN Rongfeng¹, FAN Xiaoxu¹

1. Key Laboratory for Biomass Gasification Technology of Shandong Province, Energy Research Institute of Shandong Academy of Sciences, Jinan 250014, Shandong, China;
2. Key Laboratory of Energy Thermal Conversion and Control, Ministry of Education, School of Energy and Environment, Southeast University, Nanjing 210096, Jiangsu, China

Received:2012-12-28 Revised:2013-03-21 Online:2013-08-05 Published:2013-08-05
Supported by:
supported by the Natural Science Foundation of Shandong Province(ZR2011EL042).

埋管流化床颗粒流动行为的数值模拟

杨春振¹, 段钰锋², 孙荣峰¹, 范晓旭¹

1. 山东省科学院能源研究所山东省生物质气化技术重点实验室, 山东济南 250014;
2. 东南大学能源与环境学院, 能源热转换及其过程测控教育部重点实验室, 江苏南京 210096

通讯作者: 杨春振(1984- ),男,博士。
作者简介:杨春振(1984- ),男,博士。
基金资助:
山东省自然科学基金项目(ZR2011EL042)。

Abstract

Abstract: The domain coverage method(DCM)was proposed to couple orthogonal structured DEM mesh with irregular Fluent mesh.DCM increased calculation efficiency by decreasing particle searching capacity for each Fluent cell.Particles were positioned in irregular Fluent cells with the vector method.The CFD-DEM platform was built based on DCM.And then solids behavior was studied in a fluidized bed 250 mm in bed width and 800mm in bed height with multi-immersed tubes.Simulation results showed that the proposed CFD-DEM model based on DCM could simulate gas-solids flow behavior in a fluidized bed with complex geometries.Particles moving upward collides with windward side of the fluidized bed and the other side formed a region with low solids fraction. Particles moving downward had an opposite effect on solids behavior comparing with particles moving upward.Solids behavior could be expressed into four regions:solids flow moving upward,solids flow moving downward,solids flow moving circularly and no solids region.

Key words: fluidized bed, domain coverage method, irregular mesh, immersed tube

摘要： 提出区域覆盖法,实现了正交结构化网格(DEM网格)与非规则网格(Fluent网格)的快速耦合,通过减少颗粒搜索量的方法,提高计算效率;采用向量法高效、精确定位颗粒在非规则网格内的位置,进而形成基于非规则网格的CFD-DEM数值模拟平台。在宽和高分别为250 mm和800 mm的二维多埋管流化床内对颗粒流动行为进行了数值模拟研究。结果表明:基于区域覆盖法建立的CFD-DEM模型能够模拟具有复杂几何结构流化床内的气固流动行为;多埋管流化床内的颗粒上升流磨损埋管的迎风面,在背风面形成颗粒浓度较低的区域;而颗粒下降流对埋管的影响与上升流的影响相反;多埋管流化床内的颗粒行为可划分为颗粒上升流、颗粒下降流、颗粒循环流和无颗粒区。

关键词: 流化床, 区域覆盖法, 非规则网格, 埋管

CLC Number:

YANG Chunzhen, DUAN Yufeng, SUN Rongfeng, FAN Xiaoxu. Numerical study of solids behavior in fluidized bed with multi-immersed tubes[J]. CIESC Journal, 2013, 64(8): 2788-2793.

杨春振, 段钰锋, 孙荣峰, 范晓旭. 埋管流化床颗粒流动行为的数值模拟[J]. 化工学报, 2013, 64(8): 2788-2793.

References 15

[1]	Tsuji Y,Tanaka T,Ishida T.Lagrangian numerical simulation of plug flow of cohesionless particles in a horizontal pipe[J].Powder Technology,1992,71(3):239-250
[2]	He Y,Zhan W,Zhao Y,Lu H,Schlaberg I.Prediction on immersed tubes erosion using two-fluid model in a bubbling fluidized bed[J].Chemical Engineering Science,2009,64(13):3072-3082
[3]	Zhao Y,Cheng Y,Wu C,Ding Y,Jin Y.Eulerian-Lagrangian simulation of distinct clustering phenomena and RTDs in riser and downer[J].Particuology,2009,129(1):46-52
[4]	Zhang M H,Chu K W,Wei F,Yu A B.A CFD-DEM study of the cluster behavior in riser and downer reactors[J].Powder Technology,2008,184(2):151-165
[5]	Cloete S,Amini S,Johansen S T.On the effect of cluster resolution in riser flows on momentum and reaction kinetic interaction[J].Powder Technology,2011,210(1):6-17
[6]	Yang C,Duan Y,Hu H.DEM-based models for solids exchange in a pant leg fluidized bed//Cleaner Combustion and Sustainable World[M].Qi H,Zhao B,Eds.Berlin:Springer Heidelberg,2013:641-649
[7]	Rong D,Mikami T,Horio M.Particle and bubble movements around tubes immersed in fluidized beds-a numerical study[J].Chemical Engineering Science,1999,54(23):5737-5754
[8]	Zhao Y,Jiang M,Cheng Y.Particle-scale simulation of the flow and heat transfer behaviors in fluidized bed with immersed tube[J].Frontiers of Chemical Engineering in China,2008,2(3):341-345
[9]	Zhao Yongzhi(赵永志),Cheng Yi(程易).Particle-scale simulation of fluidized bed with immersed tubes[J].Chemical Engineering(China)(化学工程),2007,35(11):21-24
[10]	Wu C L,Berrouk A S,Nandakumar K.Three-dimensional discrete particle model for gas-solid fluidized beds on unstructured mesh[J].Chemical Engineering Journal,2009,152(2/3):514-529
[11]	Wu C L,Zhan J M,Li Y S,Lam K S,Berrouk A S.Accurate void fraction calculation for three-dimensional discrete particle model on unstructured mesh[J].Chemical Engineering Science,2009,64(6):1260-1266
[12]	Su J,Gu Z,Xu X Y.Discrete element simulation of particle flow in arbitrarily complex geometries[J].Chemical Engineering Science,2011,66(23):6069-6088
[13]	Rong Liangwan(容亮湾),Zhan Jiemin(詹杰民).Investigation on the microscopic structure of bubble in dense particle system[J].Acta Physica Sinica(物理学报),2010,59(8):5572-5580
[14]	Liu Daoyin(刘道银).Experimental and numerical investigations on solids mixing in fluided beds.Nanjing:Southeast University,2011
[15]	Yusuf R,Halvorsen B,Melaaen M C.Eulerian-Eulerian simulation of heat transfer between a gas-solid fluidized bed and an immersed tube-bank with horizontal tubes[J].Chemical Engineering Science,2011,66(8):1550-1564

Numerical study of solids behavior in fluidized bed with multi-immersed tubes

埋管流化床颗粒流动行为的数值模拟

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 15

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Zhenghao YANG, Zhen HE, Yulong CHANG, Ziheng JIN, Xia JIANG. Research progress in downer fluidized bed reactor for biomass fast pyrolysis [J]. CIESC Journal, 2023, 74(6): 2249-2263.
[2]	Juhui CHEN, Qian ZHANG, Lingfeng SHU, Dan LI, Xin XU, Xiaogang LIU, Chenxi ZHAO, Xifeng CAO. Study on flow characteristics of nanoparticles in a rotating fluidized bed based on DEM method [J]. CIESC Journal, 2023, 74(6): 2374-2381.
[3]	Yuanyuan ZHANG, Jiangyuan QU, Xinxin SU, Jing YANG, Kai ZHANG. Gas-liquid mass transfer and reaction characteristics of SNCR denitration in CFB coal-fired unit [J]. CIESC Journal, 2023, 74(6): 2404-2415.
[4]	Zihan YUAN, Shuyan WANG, Baoli SHAO, Lei XIE, Xi CHEN, Yimei MA. Investigation on flow characteristics of wet particles with power-law liquid-solid drag models in fluidized bed [J]. CIESC Journal, 2023, 74(5): 2000-2012.
[5]	Kaiyue WANG, Yongli MA, Chen LI, Mingyan LIU. Gas-liquid mass transfer coefficients in the gas-liquid-solid micro-fluidized beds [J]. CIESC Journal, 2022, 73(8): 3529-3540.
[6]	Lianfeng ZHU, Chao WANG, Mengjuan ZHANG, Fangzheng LIU, Xin JIA, Ping AN, Guangwen XU, Zhennan HAN. Fluidized bed two-stage gasification of coal with steam/O₂ for production of low-tar syngas [J]. CIESC Journal, 2022, 73(8): 3720-3730.
[7]	Gang WANG, Zhihao XIA, Xiyan LI, Hong ZHANG, Zhennan HAN, Xingfei SONG, Guangwen XU. Effect of atmosphere on active performance of light-burned magnesium oxides from calcined magnesite in fluidized bed [J]. CIESC Journal, 2022, 73(8): 3699-3707.
[8]	Xinhua LIU, Zhennan HAN, Jian HAN, Bin LIANG, Nan ZHANG, Shanwei HU, Dingrong BAI, Guangwen XU. Principle and technology of low-NO _x decoupling combustion based on restructuring reactions [J]. CIESC Journal, 2022, 73(8): 3355-3368.
[9]	Dongwang ZHANG, Hairui YANG, Tuo ZHOU, Zhong HUANG, Shiyuan LI, Man ZHANG. Cold-state experimental study on ash deposition of convection heating surface of biomass boiler [J]. CIESC Journal, 2022, 73(8): 3731-3738.
[10]	Li NIU, Mengxi LIU, Haibei WANG. Hydrodynamic of mesoscale flow structure in dense phase fluidized bed [J]. CIESC Journal, 2022, 73(6): 2622-2635.
[11]	Tienan LI, Bidan ZHAO, Peng ZHAO, Yongmin ZHANG, Junwu WANG. CFD-DEM simulation of the force acting on immersed baffles during the start-up stage of a gas-solid fluidized bed [J]. CIESC Journal, 2022, 73(6): 2649-2661.
[12]	Yongli MA, Mingyan LIU, Zongding HU. Development of flow mesoscale modeling of the gas-liquid-solid fluidized beds [J]. CIESC Journal, 2022, 73(6): 2438-2451.
[13]	Jinsong XU, Min LIN, Xiaoping CHEN, Jiliang MA, Pengfei GENG, Xuebing BAO, Daoyin LIU, Cai LIANG. Experimental study on regeneration characteristics of stainless steel pickling waste mixed acid by fluidized bed roaster [J]. CIESC Journal, 2022, 73(5): 2242-2250.
[14]	Haolong BAI, Liangliang FU, Guangwen XU, Dingrong BAI. Characteristics of gaseous nitrogen release in coal fluidized bed combustion under different atmospheres [J]. CIESC Journal, 2022, 73(2): 876-886.
[15]	Yongshuai LI, Yi ZHENG, Lan LI, Xinshuang LI, Xinyi ZHAO, Hui PAN, Hao LING. Influence of lift model on gas-liquid-solid flow field in polyethylene fluidized bed reactor [J]. CIESC Journal, 2022, 73(12): 5355-5366.