In-situ gasification characteristics of a petroleum coke with CO2 at high temperature

doi:10.11949/j.issn.0438-1157.20161264

CIESC Journal ›› 2017, Vol. 68 ›› Issue (4): 1622-1628.DOI: 10.11949/j.issn.0438-1157.20161264

Previous Articles Next Articles

In-situ gasification characteristics of a petroleum coke with CO₂ at high temperature

LIU Ming^1,2, SHEN Zhongjie^1,2, HAN Dong^1,2, LIANG Qinfeng^1,2, XU Jianliang^1,2, LIU Haifeng^1,2

1 Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China;
2 Shanghai Engineering Research Center of Coal Gasification, Shanghai 200237, China

Received:2016-09-08 Revised:2016-11-12 Online:2017-04-05 Published:2017-04-05
Supported by:
supported by the National Natural Science Foundation of China (21376082) and the Foundation of Shanghai Science and Technology Committee(14dz1200100).

一种石油焦与CO₂高温气化原位反应特性

柳明^1,2, 沈中杰^1,2, 韩冬^1,2, 梁钦锋^1,2, 许建良^1,2, 刘海峰^1,2

1 华东理工大学煤气化及能源化工教育部重点实验室, 上海 200237;
2 上海市煤气化工程技术研究中心, 上海 200237

通讯作者: 刘海峰
基金资助:
国家自然科学基金项目(21376082)；上海市科学技术委员会科委资助项目(14dz1200100)。

Abstract

Abstract:

In-situ heating stage microscope was applied to analyze the influence of temperature and particle size to the gasification characteristics of petroleum coke. The differences of reaction characteristics between bituminous char and petroleum coke were also analyzed. It was found that the particle shrank during the gasification process, and the surface structure of petroleum coke was changed. The reaction rate decreased with reaction time at the lower temperature (below 1300℃), while first increased and then decreased at 1300℃. Besides, under the same conversion rate, reaction time increased with the temperature and the decrease of particle size. The gasification reaction rate performed different characteristics at 1300℃, owing to the change of particle structure. The comparison of the gasification reaction between bituminous char and petroleum coke showed that the average gasification reaction rate of petroleum coke was 1/6 of bituminous char.

Key words: in-situ analysis, petroleum coke, high-temperature gasification, shrinking particle

摘要：

采用高温热台显微镜原位研究了气化温度和颗粒粒度对石油焦气化反应的影响，并对比了神府烟煤和石油焦的反应特性。研究发现，石油焦在气化过程中颗粒收缩，表面结构发生变化，反应速率的改变由低温下逐渐减小，到高温下1300℃时先增大后减小。相同转化率下，反应时间随温度的升高而减少，随颗粒粒度的减小而减少。对比神府煤焦和石油焦的气化反应发现，石油焦反应活性低，为神府烟煤焦平均气化反应速率的1/6。

关键词: 原位研究, 石油焦, 高温气化, 颗粒收缩

CLC Number:

TQ546.2

LIU Ming, SHEN Zhongjie, HAN Dong, LIANG Qinfeng, XU Jianliang, LIU Haifeng. In-situ gasification characteristics of a petroleum coke with CO₂ at high temperature[J]. CIESC Journal, 2017, 68(4): 1622-1628.

柳明, 沈中杰, 韩冬, 梁钦锋, 许建良, 刘海峰. 一种石油焦与CO₂高温气化原位反应特性[J]. 化工学报, 2017, 68(4): 1622-1628.

References 23

[1]	ZHANG Y M, YAO M Q, GAO S Q, et al. Reactivity and kinetics for steam gasification of petroleum coke blended with black liquor in a micro fluidized bed[J]. Applied Energy, 2015, 160(1):820-828.
[2]	DING L, ZHOU Z J, HUO W, et al. Comparison of steam-gasification characteristics of coal char and petroleum coke char in drop tube furnace[J]. Chinese Journal of Chemical Engineering, 2015, 23(7):1214-1224.
[3]	LI Y, YANG H P, HU J H, et al. Effect of catalysts on the reactivity and structure evolution of char in petroleum coke steam gasification[J]. Fuel, 2014, 117(1):1174-1180.
[4]	REVANKAR V S, GOKARN A N, DORAISWAMY L K. Studies in catalytic steam gasification of petroleum coke with special reference to the effect of particle size[J]. Industrial and Engineering Chemistry Research, 1987, 26(5):1018-1025.
[5]	李庆峰, 房倚天, 张建民, 等. 石油焦水蒸气气化反应特性[J]. 燃料化学学报, 2003, 31(3):204-209.LI Q F, FANG Y T, ZHANG J M, et al. Gasification characteristics of petroleum coke and steam[J]. J. Fuel Chem. Technol., 2003, 31(3):204-209.
[6]	李庆峰, 房倚天, 张建民, 等. 石油焦的气化反应特性[J]. 燃烧科学与技术, 2004, 10(3):254-259.LI Q F, FANG Y T, ZHANG J M, et al. Gasification characteristics of petroleum coke[J]. Journal of Combustion Science and Technology, 2004, 10(3):254-259.
[7]	MALEKSHAHIAN M, VISSCHER A D, HILL J M. A non-equimolar mass transfer model for carbon dioxide gasification studies by thermogravimetric analysis[J]. Fuel Processing Technology, 2014, 124(124):1-10.
[8]	YAMASHITA T, FUJⅡ Y, MOROZUMI Y, et al. Modeling of gasification and fragmentation behavior of char particles having complicated structures[J]. Combust. Flame, 2006, 146(1):85-94.
[9]	KIM Y T, SEO D K, HWANG J. Study of the effect of coal type and particle size on char-CO2 gasification via gas analysis[J]. Energy Fuels, 2011, 25(11):5044-5054.
[10]	BO F, BHATIA S K. Percolative fragmentation of char particles during gasification[J]. Energy & Fuels, 2000, 14(2):297-307.
[11]	盖希坤, 卢艺, 邢闯, 等. 石油焦水蒸气催化气化反应特性[J]. 石油学报(石油加工), 2015, 31(4):891-896.GAI X K, LU Y, XING C, et al. Characteristics of petroleum coke catalytic gasification with steam[J]. Acta Petrolei Sinica(Petroleum Processing Section), 2015, 31(4):891-896.
[12]	杨海平, 王贤华, 张世红, 等. 石油焦水蒸气催化气化及焦拉曼结构特性[J]. 工程热物理学报, 2013, (12):2392-2395.YANG H P, WANG X H, ZHANG S H, et al. The reactivity properties in petroleum coke steam catalytic gasification[J]. J. Eng. Therm., 2013, (12):2392-2395.
[13]	胡启静, 周志杰, 刘鑫, 等. 氯化铁对高硫石油焦-CO2气化的催化作用[J]. 石油学报(石油加工), 2012, 28(3):463-469.HU Q J, ZHOU Z J, LIU X, et al. Catalytic activity of ferric chloride for high-sulfur petroleum coke-carbon dioxide gasification[J]. Acta Petrolei Sinica(Petroleum Processing Section), 2012, 28(3):463-469.
[14]	WU S Y, HUANG S, WU Y Q, et al. A semi-empirical kinetic model for simulating the steam gasification of petroleum coke catalyzed by K2CO3[J]. Energy Sources, Part A:Recovery, Utilization, and Environmental Effects, 2014, 36(11):1151-1157.
[15]	LIEW S C, HILL J M. Impacts of vanadium and coke deposits on the CO2 gasification of nickel catalysts supported on activated carbon from petroleum coke[J]. Applied Catalysis A:General, 2015, 504(5):420-428.
[16]	SHEN Z J, LIANG Q F, XU J L, et al. In situ experimental study on the combustion characteristics of captured chars on the molten slag surface[J]. Combustion and Flame, 2016, 166:333-342.
[17]	SHEN Z J, LIANG Q F, XU J L, et al. In-situ experimental study of CO2 gasification of char particles on molten slag surface[J]. Fuel, 2015, 160(19):560-567.
[18]	DING L, WEI J T, DAI Z H, et al. Study on rapid pyrolysis and in-situ char gasification characteristics of coal and petroleum coke[J]. International Journal of Hydrogen Energy, 2016, 41(38):16823-16834.
[19]	唐黎华, 陈冬霞, 朱学栋, 等. 石油焦高温气化反应性[J]. 燃料化学学报, 2005, 33(6):687-691.TANG L H, CHEN D X, ZHU X D, et al. Gasification characteristics of petroleum coke at high temperature[J]. J. Fuel Chem. Technol., 2005, 33(6):687-691.
[20]	TAKARADA T, TAMAI Y, TOMITA A. Reactivities of 34 coals under steam gasification[J]. Fuel, 1985, 64(10):1438-1442.
[21]	刘鑫, 张保申, 周志杰, 等. 高温热处理对石油焦结构及气化活性的影响[J]. 石油学报(石油加工), 2011, 27(1):138-143.LIU X, ZHANG B S, ZHOU Z J, et al. Structure changes and gasification activity of petroleum coke after heat treatment[J]. Acta Petrolei Sinica(Petroleum Processing Section), 2011, 27(1):138-143.
[22]	HIGMAN C, TAM S. Advances in coal gasification, hydrogenation, and gas treating for the production of chemicals and fuels[J]. Chemical Reviews, 2013, 114(3):1673-1708.
[23]	GOMEZ A, MAHINPEY N. A new model to estimate CO2, coal gasification kinetics based only on parent coal characterization properties[J]. Applied Energy, 2015, 137(1):126-133.

In-situ gasification characteristics of a petroleum coke with CO₂ at high temperature

一种石油焦与CO₂高温气化原位反应特性

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 23

Related Articles 7

Recommended Articles

Metrics

Comments

[1]	ZHOU Ye, XIAO Huixia, WANG Yifei, YU Guangsuo. Study on improving slurryability of lignite based on coal blending and surface modification [J]. CIESC Journal, 2021, 72(4): 2233-2240.
[2]	Lulu WANG, Tao SONG, Jiang ZHANG, Yuanyuan DUAN, Laihong SHEN. Simulation of chemical looping gasification of high-sulfur petroleum coke for syngas production coupled with recycling sulfur in 10 MW_th system [J]. CIESC Journal, 2019, 70(6): 2279-2288.
[3]	CUI Jian, DUAN Lunbo, ZHAO Changsui. Emission characteristics of sulfurous pollutant from circulating fluidized bed boilers co-firing petroleum coke and coal [J]. CIESC Journal, 2018, 69(5): 2158-2165.
[4]	LU Yao, DIAO Yongfa, CHEN Chen, LI Xiaoquan, CHEN Shanshan. Oxidation mechanism of Hg⁰ in flue gas on brominated petroleum coke [J]. CIESC Journal, 2018, 69(10): 4394-4401.
[5]	WANG Chenping, DUAN Yufeng, SHE Min, ZHU Chun, YANG Zhizhong. Mercury adsorption characteristics of petroleum coke activated by SO₂ [J]. CIESC Journal, 2017, 68(12): 4764-4773.
[6]	XIAO Ruirui1，YANG Wei1，YU Guangsuo2. Catalytic gasification kinetics of biomass semi-char [J]. Chemical Industry and Engineering Progree, 2013, 32(02): 460-465.
[7]	FANG Jianhui，YAO Boyuan，HAN Fushun. Preparation of the activated carbon with high specific surface area from petroleum coke by KOH activation [J]. , 2011, 30(10): 2258-.