考虑氢气实际气体效应和阻塞流效应的螺旋槽干气密封动态特性分析

doi:10.11949/j.issn.0438-1157.20170704

摘要/Abstract

摘要：

以Chen等提出的氢气实际气体状态方程描述氢气的实际气体行为，以气体出口速度达到音速作为产生阻塞效应的条件，确定出口压力边界条件，采用小扰动法分析了干气密封操作参数对螺旋槽干气密封动态特性的影响规律，并与理想气体、强制出口压力边界模型中的动态特性系数进行了对比。结果表明：研究高压螺旋槽干气密封的动态特性时应当考虑实际气体效应和阻塞流效应。两种效应使氢气螺旋槽干气密封的直接动态气膜刚度减小，使直接动态气膜阻尼增大。随着压缩数、进口压力的增大，两种效应对动态气膜刚度的影响逐渐增强。以频率比为变量时，两种效应主要影响气膜刚度，对气膜阻尼的影响作用较小。针对所研究的工况，与理想气体和强制压力出口边界条件相比，考虑实际气体效应和阻塞流效应，以压缩数为变量时，动态气膜阻尼（C_zz、C_αα、C_αβ）的平均偏差分别为2.28%、1.93%、2.79%；以进口压力为变量时，3种气膜阻尼的平均偏差分别达到4.08%、2.07%、1.82%。

关键词: 螺旋槽干气密封, 动态特性, 实际气体, 阻塞流, 数值分析

Abstract:

The exit pressure boundary was determined by Chen's real gas equation of hydrogen and choked flow condition of gas exit speed reaching to the sound speed. Then, dynamic characteristics of spiral groove dry gas seal (S-DGS) at various operating parameters was analyzed by perturbation method, and compared to those of ideal gas and coercive exit pressure boundary models. The results show that real gas and choked flow effects should be taken into account for studying dynamic characteristics of S-DGS at high pressure. Both effects reduced direct stiffness coefficients of hydrogen S-DGS but increased direct damping coefficients. The influence of these two effects on dynamic gas film stiffness gradually enhanced with the increase of squeeze number and inlet pressure. In addition, when frequency ratio was varied, these two effects had a significant influence on gas film dynamic stiffness but minimal influence on gas film dynamic damping. Compared to models of ideal gas and coercive pressure boundary condition at the studied operating circumstance, these two effects caused three gas film dynamic damping coefficients (C_zz, C_αα, C_αβ) by mean standard deviations of 2.28%, 1.93%, 2.79% when squeeze number is variable and 4.08%, 2.07%, 1.82% when inlet pressure is variable.

Key words: spiral groove dry gas seal, dynamic characteristics, real gas, choked flow, numerical analysis

中图分类号:

S277.9
TH136

许恒杰, 宋鹏云, 毛文元, 邓强国. 考虑氢气实际气体效应和阻塞流效应的螺旋槽干气密封动态特性分析[J]. 化工学报, 2017, 68(12): 4675-4684.

XU Hengjie, SONG Pengyun, MAO Wenyuan, DENG Qiangguo. Dynamic characteristics of spiral groove dry gas seals with consideration of hydrogen real gas and choked flow effects[J]. CIESC Journal, 2017, 68(12): 4675-4684.

参考文献 30

[1]	程海峰, 王为民, 王艳东, 等. TM02D型串联式干气密封在重整循环氢气压缩机上的应用[J]. 润滑与密封, 2010, 35(12):119-122. CHENG H F, WANG W M, WANG Y D, et al. Application of TM02D-tandeming dry gas seal on reforming circulation hydrogen compressor[J].Lubrication Engineering, 2010, 35(12):119-122.
[2]	THOMAS S, BRUNETIERE N, TOUMERIE B. Numerical modeling of high pressure gas face seals[J]. Journal of Tribology, 2006, 128(2):241-242.
[3]	产文, 宋鹏云, 毛文元, 等. 螺旋槽干气密封端面气膜温度场的数值分析[J]. 排灌机械工程学报, 2015, 33(5):422-428. CHAN W, SONG P Y, MAO W Y, et al. Numerical analysis of temperature field of gas film in spiral groove dry gas seal[J]. Journal of Drainage and Irrigation Machinery Engineering, 2015, 33(5):422-428.
[4]	宋鹏云, 产文, 毛文元, 等. 实际气体效应对螺旋槽干气密封性能影响的数值分析[J]. 排灌机械工程学报, 2015, 33(10):874-881. SONG P Y, CHAN W, MAO W Y, et al. Numerical analysis on effect of real gas on spiral groove dry gas seal performance[J]. Journal of Drainage and Irrigation Machinery Engineering, 2015, 33(10):874-881.
[5]	王衍, 孙见君, 陶凯, 等. T型槽干气密封数值分析及槽型优化[J]. 摩擦学学报, 2014, 34(4):420-427. WANG Y, SUN J J, TAO K, et al. Numerical analysis of T-groove dry gas seal and groove optimization[J]. Tribology, 2014, 34(4):420-427.
[6]	ZUK J, LUDWIG L P, JOHNSON R L. Compressible flow across shaft face seals[C]//Fifth International Conference on Fluid Sealing. Coventry. England:BHRA, 1971:Paper H6.
[7]	ARGHIR M, DEFAYE C, FRENE J. The Lomakin effect in annular gas seals under choked flow conditions[J]. Journal of Engineering for Gas Turbines & Power, 2007, 129(4):1028-1034.
[8]	THOMAS S, BRUNETIERE N, TOUMERIE B. Thermoelastohydrodynamic behavior of mechanical gas face seals operating at high pressure[J]. Journal of Tribology, 2007, 129(4):841-850.
[9]	马春红, 白少先, 彭旭东, 等. 螺旋槽端面微间隙高速气流润滑密封特性[J]. 摩擦学学报, 2015, 35(6):699-706. MA C H, BAI S X, PENG X D, et al. Properties of high speed airflow lubrication in micro-clearance of spiral-groove face seals[J]. Tribology, 2015, 35(6):699-706.
[10]	THATTE A, ZHENG X. Hydrodynamics and sonic flow transition in dry gas seals[C]//Proceedings of the ASME Turbo Expo. Fairfield, United States:American Society of Mechanical Engineers, 2014.
[11]	江锦波. 高速干气密封端面型槽仿生设计与实验研究[D]. 杭州:浙江工业大学, 2016. JIANG J B. Theoretical and experimental study of the bionic design of grooved surface of a high speed dry gas seal[D]. Hangzhou:Zhejiang University of Technology, 2016.
[12]	MILLER B A, GREEN I. Semi-analytical dynamic analysis of spiral-grooved mechanical gas face seals[J]. Journal of Tribology, 2003, 125(2):403-413.
[13]	宋鹏云, 胡晓鹏, 许恒杰, 等. 实际气体对T槽干气密封动态特性的影响[J]. 化工学报, 2014, 65(4):1344-1352. SONG P Y, HU X P, XU H J, et al. Effect of real gas on dynamic T-groove dry gas seal[J]. CIESC Journal, 2014, 65(4):1344-1352.
[14]	WANG W, LIU Y, JIANG P. Numerical investigation on influence of real gas properties on nonlinear behavior of labyrinth seal-rotor system[J]. Applied Mathematics & Computation, 2015, 263:12-24.
[15]	刘雨川. 端面气膜密封特性研究[D]. 北京:北京航天航空大学, 2000. LIU Y C. Study on the characteristics of gas film face seal[D]. Beijing:Beihang University, 2000.
[16]	CHEN H, ZHENG J, XU P, et al. Study on real-gas equations of high pressure hydrogen[J]. International Journal of Hydrogen Energy, 2010, 35(7):3100-3104.
[17]	苏长荪. 高等工程热力学[M]. 北京:高等教育出版社, 1987:361-362. SU C S. Advanced Thermodynamics[M]. Beijing:Higher Education Press, 1987:361-362.
[18]	刘晖. 实际气体温度绝热指数和容积绝热指数的计算[J]. 石油化工高等学校学报, 2000, 13(4):42-45. LIU H. Calculation of the isentropic temperature change exponent and isentropic volume change exponent of real gas[J]. Journal of Petrochemical Universities, 2000, 13(4):42-45.
[19]	邓成香, 宋鹏云, 马爱琳. 干气密封的实际气体焦耳-汤姆逊效应分析[J]. 化工学报, 2016, 67(9):3833-3842. DENG C X, SONG P Y, MA A L. Analysis of Joule-Thomson effect of real gas system sealed by dry gas[J]. CIESC Journal, 2016, 67(9):3833-3842.
[20]	许恒杰, 宋鹏云. 三自由度微扰下的静压干气密封动态特性分析[J]. 排灌机械工程学报, 2017, 35(1):56-64. XU H J, SONG P Y. Analysis on dynamic characteristics of aerostatic dry gas seals with three degrees of freedom perturbation[J]. Journal of Drainage and Irrigation Machinery Engineering, 2017, 35(1):56-64.
[21]	LIU Y, SHEN X, XU W. Numerical analysis of dynamic coefficients for gas film face seals[J]. Journal of Tribology, 2002, 124(4):743-754.
[22]	刘雨川, 徐万孚, 王之栎, 等. 端面气膜密封动力特性系数的计算[J]. 清华大学学报(自然科学版), 2002, 42(2):185-189. LIU Y C, XU W F, WANG Z L, et al. Dynamic coefficients for gas film face seal[J]. J. Tsinghua Univ. (Sci. & Technol.), 2002, 42(2):185-189.
[23]	黄平, 许兰贵, 孟永钢, 等.求解磁头/磁盘超薄气膜润滑性能的有效有限差分算法[J]. 机械工程学报, 2007, 43(3):43-49. HUANG P, XU L G, MENG Y G, et al. Effective finite difference method to calculate lubricating performances of ultra-thin gas film of magnetic head/disk[J]. Chinese Journal of Mechanical Engineering, 2007, 43(3):43-49.
[24]	LEBECK A O. Principles and Design of Mechanical Face Seals[M]. John Wiley & Sons, Inc., 1991:371.
[25]	RUAN B. Numerical modeling of dynamic sealing behaviors of spiral groove gas face seals[J]. Journal of Tribology, 2002, 124(1):186-195.
[26]	RUAN B. A semi-analytical solution to the dynamic tracking of non-contacting gas face seals[J]. Journal of Tribology, 2002, 124(1):196-202.
[27]	陈源, 彭旭东, 李纪云, 等. 螺旋槽结构参数对干气密封动态特性的影响研究[J]. 摩擦学学报, 2016, 36(4):397-405. CHEN Y, PENG X D, LI J Y, et al. The influence of structure parameters of spiral groove on dynamic characteristics of dry gas seal[J]. Tribology, 2016, 36(4):397-405.
[28]	刘向锋, 徐辰, 黄伟峰. 基于半解析法的极端工况干气密封动态特性研究与参数设计[J]. 清华大学学报(自然科学版), 2014, 54(2):223-228. LIU X F, XU C, HUANG W F. Analysis and parametric design of the dynamics of a dry gas seal for extreme operating conditions using a semi-analytical method[J]. J. Tsinghua Univ. (Sci. & Technol.), 2014, 54(2):223-228.
[29]	ZIRKELBACK N. Parametric study of spiral groove gas face seals[J].Tribology Transactions, 2000, 43(2):337-343.
[30]	晏鑫, 蒋玉娥, 李军, 等. 迷宫密封转子动力学特性的数值模拟[J]. 热能动力工程, 2009, 24(5):566-570. YAN X, JIANG Y E, LI J, et al. Numerical calculation of dynamic coefficients for gas film cylinder seal[J]. Journal of Engineering for Thermal Energy and Power, 2009, 24(5):566-570.