华南地区低有机质污泥碱性厌氧产酸(VFAs)性能机理与菌群分析

doi:10.11949/j.issn.0438-1157.20151230

化工学报 ›› 2016, Vol. 67 ›› Issue (4): 1565-1571.DOI: 10.11949/j.issn.0438-1157.20151230

华南地区低有机质污泥碱性厌氧产酸(VFAs)性能机理与菌群分析

姚创¹, 刘晖², 罗晓栋¹, 岳建雄¹, 李诗瑶¹, 陈大志¹

1. 广东省工程技术研究所, 广东省水环境污染控制重点实验室, 广东广州 510440;
2. 仲恺农业工程学院环境科学与工程学院, 广东广州 510225

收稿日期:2015-07-31 修回日期:2015-10-06 出版日期:2016-04-05 发布日期:2016-04-05
通讯作者: 陈大志
基金资助:
广州市科技计划项目科学研究专项(一般项目)(201510010283)。

Mechanism and microbial community analysis of anaerobic acid production (VFAs) by low carbon sludge in South China at alkaline condition

YAO Chuang¹, LIU Hui², LUO Xiaodong¹, YUE Jianxiong¹, LI Shiyao¹, CHEN Dazhi¹

1. Guangdong Research Institute of Engineering and Technology, Guangdong Provincial Key Laboratory of Water Environment Pollution Control, Guangzhou 510440, Guangdong, China;
2. School of Environmental Science and Engineering, Zhongkai University of Agriculture and Engineering, Guangzhou 510225, Guangdong, China

Received:2015-07-31 Revised:2015-10-06 Online:2016-04-05 Published:2016-04-05
Supported by:
supported by the Special Scientific Research of Guangzhou Science and Technology Plan Projects (Common Project) (201510010283).

摘要/Abstract

摘要：

目前,我国利用剩余污泥产挥发性脂肪酸(VFAs)的碳源化研究主要集中在对华东和北方地区污水厂污泥的利用,而采用华南地区污水厂剩余污泥进行产酸的研究较少,且对其开展实际现场产酸特性的研究更是少见报道。采用半连续式厌氧产酸反应器,对广东省肇庆市鼎湖区污水处理厂剩余污泥产挥发性脂肪酸的系统特性进行了试验研究。研究结果表明,系统在碱性条件下(pH 10.0)具有良好的水解产酸性能。VFAs对应的COD(VFAs-COD)占SCOD的比重较大,平均占比73.89%,高于现有同类研究结果2%~15%。同时仅伴随着少量的多糖和蛋白质积累(对应的COD占SCOD的比重为5%~15%)。乙酸为主要的VFAs组成成分,平均占比51.43%,系统优势菌几乎全部为产酸菌,包括Acetoanaerobium sp.、Clostridiales bacterium Z-810、Proteinivorax tanatarense strain Z-910、Tissierella sp.,其中Acetoanaerobium sp.、Clostridiales bacterium Z-810在同类研究中暂无报道。系统产酸过程中可实现33.5%的污泥减量率。

关键词: 剩余污泥, 碱性产酸, 溶解性有机物, 挥发性脂肪酸, 污泥减量, 菌群

Abstract:

Nowadays, the researches of VFAs production by excess sludge focused mainly on the utilization of the excess sludge from wastewater treatment plant (WWTP) in east and north areas of China, and few on the sludge in south China. Meanwhile, the related on-site experimental research for VFAs production property by sludge from WWTP in south China was rarely reported. Research on VFAs production by excess sludge was conducted at alkaline condition by semi-continuous anaerobic reactor, which was located at Dinghu wastewater treatment plant in Zhaoqing, Guangdong Province. The results showed that great hydrolysis and acidification properties of the system could be achieved at alkaline condition (pH 10.0). The percentage of VFAs-COD/SCOD was 73.89% in average, which was about 2%—15% higher than that of existing similar researches. Meanwhile, only small amount of polysaccharide and protein were accumulated (5%—15% of SCOD). Acetic acid was the main component of VFAs with the proportion of 51.43%. And the dominant microbial species in the system were all nearly acid production microorganisms including Acetoanaerobium sp., Clostridiales bacterium Z-810, Proteinivorax tanatarense strain Z-910 and Tissierella sp., among which Acetoanaerobium sp. and Clostridiales bacterium Z-810 were not reported in other similar researches. The excess sludge reduction rate of 33.5% could be achieved.

Key words: excess sludge, alkaline fermentation, SCOD, VFA, sludge reduction, microbial community

中图分类号:

X703

姚创, 刘晖, 罗晓栋, 岳建雄, 李诗瑶, 陈大志. 华南地区低有机质污泥碱性厌氧产酸(VFAs)性能机理与菌群分析[J]. 化工学报, 2016, 67(4): 1565-1571.

YAO Chuang, LIU Hui, LUO Xiaodong, YUE Jianxiong, LI Shiyao, CHEN Dazhi. Mechanism and microbial community analysis of anaerobic acid production (VFAs) by low carbon sludge in South China at alkaline condition[J]. CIESC Journal, 2016, 67(4): 1565-1571.

参考文献 30

[1]	TONG J, CHEN Y G. Recovery of nitrogen and phosphorus from alkaline fermentation liquid of waste activated sludge and application of the fermentation liquid to promote biological municipal wastewater treatment[J]. Water Research, 2009, 43 (12): 2969-2976.
[2]	苗志加, 薛桂松, 翁冬晨, 等. 不同碳源对EBPR系统厌氧计量学参数的影响[J]. 化工学报, 2012, 63 (12): 4034-4041. MIAO Z J, XUE G S, WENG D C, et al. Influence of different carbon sources on anaerobic stoichiometry parameters of EBPR system[J]. CIESC Journal, 2012, 63 (12): 4034-4041.
[3]	LONGO S, KATSOU E, MALAMIS S, et al. Recovery of volatile fatty acids from fermentation of sewage sludge in municipal wastewater treatment plants[J]. Bioresource Technology, 2015, 175: 436-444.
[4]	YUAN H Y, CHEN Y G, ZHANG H, et al. Improved bioproduction of short-chain fatty acids (SCFAs) from excess sludge under alkaline conditions[J]. Environmental Science & Technology, 2006, 40 (6): 2025-2029.
[5]	LI X, CHEN H, HU L F, et al. Pilot-scale waste activated sludge alkaline fermentation, fermentation liquid separation, and application of fermentation liquid to improve biological nutrient removal[J]. Environmental Science & Technology, 2011, 45 (5): 1834-1839.
[6]	YUAN Y, PENG Y Z, LIU Y, et al. Change of pH during excess sludge fermentation under alkaline, acidic and neutral conditions[J]. Bioresource Technology, 2014, 174: 1-5.
[7]	SUN X Y, WANG W, CHEN C, et al. Acidification of waste activated sludge during thermophilic anaerobic digestion[J]. Procedia Environmental Sciences, 2012, 16: 391-400.
[8]	LIU X G, DONG B, DAI X H. Hydrolysis and acidification of dewatered sludge under mesophilic, thermophilic and extreme thermophilic conditions: effect of pH[J]. Bioresource Technology, 2013, 148: 461-466.
[9]	YAN Y Y, FENG L Y, ZHANG C J, et al. Ultrasonic enhancement of waste activated sludge hydrolysis and volatile fatty acids accumulation at pH 10.0[J]. Water Research, 2010, 44 (11): 3329-3336.
[10]	YANG Q, YI J, LUO K, et al. Improving disintegration and acidification of waste activated sludge by combined alkaline and microwave pretreatment[J]. Process Safety and Environmental Protection, 2013, 91 (6): 521-526.
[11]	LI X L, PENG Y Z, REN N Q, et al. Effect of temperature on short chain fatty acids (SCFAs) accumulation and microbiological transformation in sludge alkaline fermentation with Ca(OH)2 adjustment[J]. Water Research, 2014, 61: 34-45.
[12]	FENG L Y, WANG H, CHEN Y G, et al. Effect of solids retention time and temperature on waste activated sludge hydrolysis and short-chain fatty acids accumulation under alkaline conditions in continuous-flow reactors[J]. Bioresource Technology, 2009, 100 (1): 44-49.
[13]	YUAN Q, BARANOWSKI M, OLESZKIEWICZ J A. Effect of sludge type on the fermentation products[J]. Chemosphere, 2010, 80 (4): 445-449.
[14]	State Environmental Protection Administration of China. Monitoring and Analytic Methods of Water and Wastewater[M]. 4th ed. Beijing: Environmental Science Press of China, 2002.
[15]	DUBOIS M, GILLES K A, HAMILTON J K. Colorimetric method for determination of sugars and related substances[J]. Analytical Chemistry, 1956, 28 (3): 350-356.
[16]	BRADFORD M M. A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding[J]. Analytical Biochemistry, 1976, 72 (1/2): 248-254.
[17]	CHEN Y G, LIU K, SU Y L, et al. Continuous bioproduction of short-chain fatty acids from sludge enhanced by the combined use of surfactant and alkaline pH[J]. Bioresource Technology, 2013, 140: 97-102.
[18]	YAN S T, MIYANAGA K, XING X H, et al. Succession of bacterial community and enzymatic activities of activated sludge by heat-treatment for reduction of excess sludge[J]. Biochemical Engineering Journal, 2008, 39 (3): 598-603.
[19]	HUANG L, CHEN B, PISTOLOZZI M, et al. Inoculation and alkali coeffect in volatile fatty acids production and microbial community shift in the anaerobic fermentation of waste activated sludge[J]. Bioresource Technology, 2014, 153: 87-94.
[20]	JIANG J G, ZHANG Y J, LI K, et al. Volatile fatty acids production from food waste: effects of pH, temperature, and organic loading rate[J]. Bioresource Technology, 2013, 143: 525-530.
[21]	ZHANG P, CHEN Y G, ZHOU Q, et al. Understanding short-chain fatty acids accumulation enhanced in waste activated sludge alkaline fermentation: kinetics and microbiology[J]. Environmental Science & Technology, 2010, 44 (24): 9343-9348.
[22]	CHEN Y G, JIANG S, YUAN H Y, et al. Hydrolysis and acidification of waste activated sludge at different pHs[J]. Water Research, 2007, 41 (3): 683-689.
[23]	DO?AN I, SANIN F D. Alkaline solubilization and microwave irradiation as a combined sludge disintegration and minimization method[J]. Water Research, 2009, 43 (8): 2139-2148.
[24]	YUAN Q, SPARLING R, OLESZKIEWICZ J A. Waste activated sludge fermentation: Effect of solids retention time and biomass concentration[J]. Water Research, 2009, 43 (20): 5180-5186.
[25]	GAO Y Q, PENG Y Z, ZHANG J Y, et al. Biological sludge reduction and enhanced nutrient removal in a pilot-scale system with 2-step sludge alkaline fermentation and A2/O process[J]. Bioresource Technology, 2011, 102 (5): 4091-4097.
[26]	KEVBRIN V, BOLTYANSKAYA Y, ZHILINA T, et al. Proteinivorax tanatarense gen. nov., sp. nov., an anaerobic, haloalkaliphilic, proteolytic bacterium isolated from a decaying algal bloom, and proposal of Proteinivoraceae fam. nov[J]. Extremephiles, 2013, 17 (5): 747-756.
[27]	HARMS C, SCHLEICHER A, COLLINS M D, et al. Tissierella creatinophila sp. nov., a gram-positive, anaerobic, non-spore-forming, creatinine-fermenting organism[J]. International Journal of Systematic Bacteriology, 1998, 48: 983-993.
[28]	SLEAT R, MAH R A, ROBINSON R. Acetoanaerobium noterae gen. nov., sp. nov.: an anaerobic bacterium that forms acetate from H2 and CO2[J]. International Journal of Systematic and Evolutionary Microbiology, 1985, 35: 10-15.
[29]	JIE W G, PENG Y Z, REN N Q, et al. Volatile fatty acids (VFAs) accumulation and microbial community structure of excess sludge (ES) at different pHs[J]. Bioresource Technology, 2014, 152: 124-129.
[30]	XIONG H L, CHEN J L, WANG H, et al. Influences of volatile solid concentration, temperature and solid retention time for the hydrolysis of waste activated sludge to recover volatile fatty acids[J]. Bioresource Technology, 2012, 119: 285-292.

华南地区低有机质污泥碱性厌氧产酸(VFAs)性能机理与菌群分析

Mechanism and microbial community analysis of anaerobic acid production (VFAs) by low carbon sludge in South China at alkaline condition

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[2]	张艳梅, 袁涛, 李江, 刘亚洁, 孙占学. 高效SRB混合菌群构建及其在酸胁迫条件下的性能研究[J]. 化工学报, 2023, 74(6): 2599-2610.
[3]	张建华, 陈萌萌, 孙雅雯, 彭永臻. 部分短程硝化同步除磷耦合Anammox实现生活污水高效脱氮除磷[J]. 化工学报, 2023, 74(5): 2147-2156.
[4]	张立, 吴建华, 崔舒惠, 严锋, 孙浩, 钱飞跃. PN/A颗粒污泥-固相反硝化组合工艺的菌群功能解析[J]. 化工学报, 2022, 73(11): 5128-5137.
[5]	段文松, 李带, 张方芳, 许志恒, 郝敏, 崔嘉吉, 吴安安, 黄观超. 正渗透膜生物反应器运行过程中溶质反渗对微生物群落的影响[J]. 化工学报, 2019, 70(5): 1981-1990.
[6]	陈希, 王建芳, 钱飞跃, 高军军, 沈耀良, 周丰. 连续流与序批式组合运行启动高性能CANON反应器[J]. 化工学报, 2018, 69(4): 1695-1702.
[7]	曹达啟, 王振, 郝晓地, 汪群慧. 剩余污泥吸附痕量典型药物影响因素[J]. 化工学报, 2017, 68(8): 3266-3274.
[8]	崔有为, 张宏宇. pH对嗜盐混合菌发酵挥发性有机酸混合物合成PHA的影响[J]. 化工学报, 2016, 67(10): 4431-4438.
[9]	相坤, 杨艳玲, 李星, 张达, 黄柳, 陈楠, 王帅. 氯胺及其与二氧化氯联用对原水管道溶解性有机物降解的影响[J]. 化工学报, 2015, 66(6): 2262-2267.
[10]	崔有为, 冀思远, 卢鹏飞, 张宏宇. F/F对嗜盐污泥以乙酸钠为底物生产PHB能力的影响[J]. 化工学报, 2015, 66(4): 1491-1497.
[11]	昌盛, 李建政, 付青, 赵兴茹, 郑国臣. ACR在不同进水COD浓度下的产氢性能与菌群结构[J]. 化工学报, 2015, 66(3): 1156-1162.
[12]	唐海, 沙俊鹏, 欧阳龙, 仲达, 刘桂中. Fe(Ⅱ)活化过硫酸盐氧化破解剩余污泥[J]. 化工学报, 2015, 66(2): 785-792.
[13]	杜瑾, 贾晓强, 元英进. 人工合成微生物混菌体系的研究进展[J]. CIESC Journal, 2014, 65(2): 390-395.
[14]	苑宏英1，2，王小佩 1，2，王亭 1，2，牛四芳1，2，祁丽 1，2. 不同絮凝剂对剩余污泥水解和脱水特性的影响[J]. 化工进展, 2014, 33(10): 2790-2794.
[15]	刘英杰1，贾晓强1，2，3，闻建平1，2，3，班睿1. 混合菌群合成聚羟基脂肪酸酯研究进展[J]. 化工进展, 2014, 33(10): 2729-2734.