两级分凝自复叠制冷系统特性

doi:10.3969/j.issn.0438-1157.2013.06.018

化工学报 ›› 2013, Vol. 64 ›› Issue (6): 2029-2035.DOI: 10.3969/j.issn.0438-1157.2013.06.018

两级分凝自复叠制冷系统特性

芮胜军^1,2, 张华¹, 张庆钢¹, 黄理浩¹

1. 上海理工大学制冷技术研究所,上海 200093;
2. 河南科技大学车辆与动力工程学院,河南洛阳 471023

收稿日期:2012-09-23 修回日期:2012-10-09 出版日期:2013-06-05 发布日期:2013-06-05
通讯作者: 芮胜军(1975—),男,博士研究生,讲师。
作者简介:芮胜军(1975—),男,博士研究生,讲师。
基金资助:
国家自然科学基金项目(51176124);上海市优秀学科带头人项目(10XD1403100);上海市重点学科建设项目(S30503)。

Characteristics of two-stage segregation auto-cascade refrigeration system

RUI Shengjun^1,2, ZHANG Hua¹, ZHANG Qinggang¹, HUANG Lihao¹

1. Institute of Refrigeration Technology, University of Shanghai for Science and Technology, Shanghai 200093, China;
2. Vehicle & Motive Power Engineering College, Henan University of Science and Technology, Luoyang 471023, Henan, China

Received:2012-09-23 Revised:2012-10-09 Online:2013-06-05 Published:2013-06-05
Supported by:
supported by the National Natural Science Foundation of China(51176124),the Shanghai Outstanding Subject Leaders Project(10XD1403100)and the Shanghai Leading Academic Discipline Project(S30503).

摘要/Abstract

摘要： 以两级分凝自复叠制冷系统为研究对象,分析了三元混合工质空间和平面汽液平衡特性,对三元混合工质的组分变化规律及运行特性进行了理论研究。应用混合工质物性分析软件Refprop 8.0根据冷凝蒸发器冷量平衡特性讨论了混合工质组分比例,得到比较合理的配比组成65/20/15。通过5个平面压焓图的空间变化关系分析了自复叠制冷系统工质分离、混合和运行特性。根据实验研究,循环系统高低压旁通和相分离器出口气体旁通可有效改善压缩机启动初期系统压力和温度过高的问题。对系统各级节流降温过程进行了分析,并对压缩机的吸排气温度和蒸发温度进行了研究。

关键词: 自复叠制冷, 混合工质, 分凝循环, 单级压缩

Abstract: A two-stage segregation auto-cascade refrigeration system was studied.The vapor-liquid equilibrium characteristics of a ternary mixed-refrigerant, composition change rules and operating characteristics of the ternary system were investigated.Refprop 8.0, general software for mixed-refrigerant property analysis with abroad applications, was used.The composition proportion of mixed-refrigerant was discussed according to the cooling capacity balance characteristics of evaporative condense and a reasonable proportion was obtained.The separation, mixing and operating characteristics of auto-cascade refrigeration system mixed-refrigerant were analyzed on the basis of spatial changes of five plane pressure-enthalpy diagrams.According to the experimental research, high-low pressure bypass and phase separator outlet vapor bypass of circulatory system could effectively improve the high discharge pressure and discharge temperature in the starting process.The throttle cooling process of each stage was analyzed, and the suction and discharge temperatures and evaporative temperature of compressor were studied.

Key words: auto-cascade refrigeration, mixed refrigerant, segregation cycle, single-stage compression

中图分类号:

TB657.3

芮胜军, 张华, 张庆钢, 黄理浩. 两级分凝自复叠制冷系统特性[J]. 化工学报, 2013, 64(6): 2029-2035.

RUI Shengjun, ZHANG Hua, ZHANG Qinggang, HUANG Lihao. Characteristics of two-stage segregation auto-cascade refrigeration system[J]. CIESC Journal, 2013, 64(6): 2029-2035.

参考文献 15

[1]	Zhang Yu(张宇), Gong Maoqiong(公茂琼), Wu Jianfeng(吴剑峰).Vapor-liquid equilibrium measurement and correlation for R23+R116 system[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2008,59(2):269-275
[2]	Dale J Missimer.Refrigerant conversion of auto- refrigerating cascade(ARC)systems[J].International Journal of Refrigeration, 1997,20(3):201-207
[3]	Lai Fen(赖芬), Wu Yuyuan(吴裕远), Ouyang Qianwu(欧阳前武), et al.Theoretical research on a new partial auto-cascade heat pump[J].Journal of Xi'an Jiaotong University(西安交通大学学报), 2012,46(3):15-20
[4]	Kim S G,Kim M S.Experiment and simulation on the performance of an auto-cascade refrigeration system using carbon dioxide as a refrigerant[J].International Journal of Refrigeration, 2002,25:1093-1101
[5]	Gurudath Nayak H, Venkatarathnam G.Performance of an auto refrigerant cascade refrigerator operating in liquid refrigerant supply(LRS)mode with different cascade heat exchangers[J].Cryogenics, 2010,50:720-727
[6]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰), Gong Zhengfeng(贡征峰), et al.Performance of cascade refrigeration with liquid refrigerant by-pass[J].Journal of Mechanical Engineering Cryogenics(机械工程学报), 2007,43(8):192-197
[7]	Du Kai,Zhang Shaoqian, Xu Weirong, et al.A study on the cycle characteristics of an auto-cascade refrigeration system[J].Experimental Thermal and Fluid Science, 2009,33:240-245
[8]	Xu Weirong(徐卫荣), Du Kai(杜垲).Thermal performance analysis of auto-cascade heat pump circular system[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2008,59(S2):230-234
[9]	Tao Kai(陶锴), Yan Gang(晏刚), Zhang Min(张敏), et al.A novel auto-cascade heat pump with intermediate pressure adjustment[J].Journal of Xi'an Jiaotong University(西安交通大学学报), 2010,44(9):43-47
[10]	Gong M Q,Wu J F,Luo E C.Performances of the mixed-gases Joule-Thomson refrigeration cycles for cooling fixed-temperature heat loads[J].Cryogenics, 2004,44:847-857
[11]	Alexandrow A A,Crigoriev B A,Ustjuzhanin E E, et al.Some modelling of cooling cycles used in individual and mixed refrigerants[J].Fluid Phase Equilibria, 2000,174:178-189
[12]	Eric W Lemmo, Reiner Tillner-Roth.A Helmholtz energy equation of state for calculating the thermodynamic properties of fluid mixtures[J].Fluid Phase Equilibria, 1999,165:1-21
[13]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰).Experimental study on starting characteristic of cascade refrigeration system[J].Cryogenics(低温工程), 2009(5):51-54
[14]	Niu Baolian(牛宝联), Zhang Yufeng(张于峰).Experiment on concentration ratio of CO2/R290 in low-temperature circuit of cascade refrigeration[J].Journal of Refrigeration(制冷学报), 2010,31(1):35-38
[15]	Gong Maoqiong, Wu Jianfeng, Luo Ercang.Study of the single-stage mixed-gases refrigeration cycle for cooling temperature-distributed heat loads[J].International Journal of Thermal Sciences, 2004,43:31-41

两级分凝自复叠制冷系统特性

Characteristics of two-stage segregation auto-cascade refrigeration system

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 15

相关文章 15

编辑推荐

Metrics

本文评价

[1]	谈莹莹, 刘晓庆, 王林, 黄鲤生, 李修真, 王占伟. R1150/R600a自复叠制冷循环开机动态特性实验研究[J]. 化工学报, 2023, 74(S1): 213-222.
[2]	党玉荣, 莫春兰, 史科锐, 方颖聪, 张子杨, 李作顺. 综合评价模型联合遗传算法的混合工质ORC系统性能研究[J]. 化工学报, 2023, 74(5): 1884-1895.
[3]	吴子睿, 孙瑞, 石凌峰, 田华, 王轩, 舒歌群. CO₂混合工质的气液相平衡的混合规则对比与预测研究[J]. 化工学报, 2022, 73(4): 1483-1492.
[4]	孙铭泽, 马宁, 李浩然, 姜海峰, 洪文鹏, 牛晓娟. 中低温超临界CO₂及其混合工质布雷顿循环热力学分析[J]. 化工学报, 2022, 73(3): 1379-1388.
[5]	罗介霖, 杨凯寅, 赵朕, 王勤, 陈光明. 低GWP混合工质回热热泵采暖性能[J]. 化工学报, 2021, 72(S1): 84-90.
[6]	李子航, 王占博, 苗政, 纪献兵. 亚临界有机朗肯循环系统工质筛选及热经济性分析[J]. 化工学报, 2021, 72(9): 4487-4495.
[7]	曹健, 冯新, 吉晓燕, 陆小华. 基于混合工质的多级蒸发ORC理论极限性能研究[J]. 化工学报, 2021, 72(7): 3780-3787.
[8]	陈超男, 罗向龙, 杨智, 黄仁龙, 卢沛, 陈健勇, 陈颖. 非共沸混合工质组分调控ORC系统热经济性分析和优化[J]. 化工学报, 2020, 71(5): 2373-2381.
[9]	明勇, 彭艳楠, 苏文, 魏国龙, 王强, 周乃君, 赵力. 闭式热源下混合工质与纯工质的ORC性能比较[J]. 化工学报, 2020, 71(4): 1570-1579.
[10]	陈玉婷, 徐燕燕, 王磊, 叶爽, 黄伟光. 蒸发器换热过程对ORC系统混合工质选择和运行工况的影响[J]. 化工学报, 2019, 70(5): 1723-1733.
[11]	潘垚池, 刘金平, 许雄文, 付志明. 自复叠制冷系统降温过程组分浓度优化及控制策略[J]. 化工学报, 2017, 68(8): 3152-3160.
[12]	谈莹莹, 王林, 白得坡, 闫晓娜. R23/R134a一级分凝和二级分凝自复叠喷射制冷循环性能理论分析[J]. 化工学报, 2016, 67(S2): 107-112.
[13]	芮胜军, 张华, 董彬, 梁坤峰. 自复叠制冷系统4种组分配比性能[J]. 化工学报, 2016, 67(5): 1830-1836.
[14]	曹乐, 刘金平, 许雄文, 李日新. 用于低干度混合工质制冷的板翅式换热器传热系数[J]. 化工学报, 2016, 67(4): 1277-1286.
[15]	任彬, 陈福胜, 王辉, 宋琦, 王勤, 徐象国, 陈光明. 精馏型自复叠小型天然气液化系统配比优化[J]. 化工学报, 2014, 65(z2): 169-174.