ZrO2-TiO2复合纳滤膜在模拟放射性废水中的应用

doi:10.11949/j.issn.0438-1157.20160952

化工学报 ›› 2016, Vol. 67 ›› Issue (12): 5040-5047.DOI: 10.11949/j.issn.0438-1157.20160952

ZrO₂-TiO₂复合纳滤膜在模拟放射性废水中的应用

陈婷, 张云, 陆亚伟, 邱鸣慧, 范益群

南京工业大学化工学院, 材料化学工程国家重点实验室, 江苏南京 210009

收稿日期:2016-07-08 修回日期:2016-09-09 出版日期:2016-12-05 发布日期:2016-12-05
通讯作者: 范益群。yiqunfan@njtech.edu.cn
基金资助:
国家高技术研究发展计划项目（2012AA03A606）；国家自然科学基金项目（91534108，21506093）；江苏高校优势学科建设工程(PAPD)；江苏省“六大人才高峰”项目(2012JNHB016)。

Application of ZrO₂-TiO₂ composite nanofiltration membrane for treatment of simulative radioactive waste water

CHEN Ting, ZHANG Yun, LU Yawei, QIU Minghui, FAN Yiqun

State Key Laboratory of Materials-Oriented Chemical Engineering, College of Chemical Engineering, Nanjing Tech University, Nanjing 210009, Jiangsu, China

Received:2016-07-08 Revised:2016-09-09 Online:2016-12-05 Published:2016-12-05
Supported by:
supported by the National High Technology Research and Development Program of China(2012AA03A606), the National Natural Science Foundation of China(91534108, 21506093), the Project of Priority Academic Program Development of Jiangsu Higher Education Institutions(PAPD) and the "Peak Specialists in Six Industries" High-level Specialist Fund of Jiangsu Province(2012JNHB016).

摘要/Abstract

摘要：

核工业、核研究及医疗等过程会产生大量的放射性废水，会对环境和生物体造成严重伤害，必须经过合适的处理后才能排放。采用高性能陶瓷纳滤膜处理模拟放射性废水，考察了跨膜压差、pH和离子浓度等操作参数对Co²⁺和Sr²⁺截留性能的影响，并对操作参数进行了优化。所用陶瓷纳滤膜材料为ZrO₂-TiO₂复合材料，截留分子量为500，纯水渗透率为270 L·m^-2·h^-1·MPa^-1。研究表明，陶瓷纳滤膜对Co²⁺和Sr²⁺两种离子的截留率随着跨膜压差的升高而增大，膜的渗透通量随着跨膜压差的增大呈线性增加。pH变化时，截留率在一定pH范围内先降低后升高，在等电点（pH=7）附近达到最小值；pH=3的情况下，两种离子的截留率均达到最高，Co²⁺和Sr²⁺的截留率均在99%以上，而纳滤膜渗透通量保持稳定。离子截留率和渗透通量均随进料浓度的增大而减小，在2000 min的连续循环操作过程中，陶瓷纳滤膜材料的渗透通量及其对Co²⁺和Sr²⁺的截留率均维持在较高水平。陶瓷纳滤膜在放射性废水处理方面展现出了良好的应用前景。

关键词: 纳滤, 陶瓷膜, 放射性废水, 离子截留

Abstract:

The radioactive waste water is generated in nuclear industry, nuclear research centers, medicine and other fields. It's harmful to living organisms, environment and natural resources. Thus, the radioactive waste water should be managed and treated well. Nanofiltration is a new kind separation technology with low-cost and high-efficiency, which ranges between ultrafiltration and reverse osmosis. In this work, TiO₂/ZrO₂ composite nanofiltration membranes with MWCO of about 500 and permeability of 270 L·m^-2·h^-1·MPa^-1 were used to remove the cobalt and strontium ions in the low-level radioactive wastewater without the addition of complexing agent. The effects of pH, transmembrane pressure and initial concentration on the permeability and retention property were investigated. It was demonstrated that the ion retention behaviors were enhanced with the increase of transmembrane pressure from 0.4 to 1.0 MPa, while the permeability changed slightly. The retention gradually increased along with the deviation from the isoelectric point(pH=7), where the retention was minimum value. Under the condition of pH=3, the retention of Co²⁺ and Sr²⁺ achieved the highest level, which was up to 99%. The ion retention and permeability decreased with the increase of initial concentration. With the operation time exceeding 2000 min, ions retention and permeability of ceramic nanofiltration membrane were almost stable. The ceramic nanofiltration membrane showed a good potential in the application of radioactive effluent treatment.

Key words: nanofiltration, ceramic membrane, radioactive wastewater, ions retention

中图分类号:

TQ174

陈婷, 张云, 陆亚伟, 邱鸣慧, 范益群. ZrO₂-TiO₂复合纳滤膜在模拟放射性废水中的应用[J]. 化工学报, 2016, 67(12): 5040-5047.

CHEN Ting, ZHANG Yun, LU Yawei, QIU Minghui, FAN Yiqun. Application of ZrO₂-TiO₂ composite nanofiltration membrane for treatment of simulative radioactive waste water[J]. CIESC Journal, 2016, 67(12): 5040-5047.

参考文献 31

[1]	BICKERSTAFF K, LORENZONI I, PIDGEON N F, et al. Reframing nuclear power in the UK energy debate:nuclear power, climate change mitigation and radioactive waste[J]. Public Understanding of Science, 2008, 17(2):145-169.
[2]	李俊峰, 孙奇娜, 王建龙. 放射性废水膜处理工艺中试实验研究[J]. 原子能科学技术, 2010, 44:148-152. LI J F, SUN Q N, WANG J L. Radioactive wastewater treatment by pilot two stage reverse osmosis membrane system[J]. Atomic Energy Science and Technology, 2010, 44:148-152.
[3]	李小燕, 花明, 刘义保, 等. 改性玉米芯吸附溶液中U(Ⅵ)的动力学和热力学[J]. 化工学报, 2012, 63(12):4068-4074. LI X Y, HUA M, LIU Y B, et al. Kinetics and thermodynamics of U(Ⅵ) adsorption from aqueous solution by modified corncob[J]. CIESC Journal, 2012, 63(12):4068-4074.
[4]	ZAKRZEWSKA-TRZNADEL G. Advances in membrane technologies for the treatment of liquid radioactive waste[J]. Desalination, 2013, 321:119-130.
[5]	RANA D, MATSUURA T, KASSIM M A, et al. Radioactive decontamination of water by membrane processes-a review[J]. Desalination, 2013, 321:77-92.
[6]	ZAKRZEWSKA T G Y, HARASIMOWICZ M, CHMIELEWSKI A G. Membrane processes in nuclear technology-application for liquid radioactive waste treatment[J]. Separation and Purification Technology, 2001, 22/23:617-625.
[7]	LU Y, CAO Q, CHEN Y, et al. Study on treating of low-level radioactive reactor wastewater by combined membrane process(UF-RO)[J]. Nuclear Power Engineering, 2013, 34(6):161-164,172.
[8]	ASFARI Z, BRESSOT C, VICENS J, et al. Cesium removal from nuclear waste water by supported liquid membranes containing calix-bis-crown compounds[J]. ACS Symposium, 1996, 642:376-390.
[9]	INOUE H, KAGOSHIMA M, YAMASAKI M, et al. Radioactive iodine waste treatment using electrodialysis with an anion exchange paper membrane[J]. Applied Radiation and Isotopes, 2004, 61(6):1189-1193.
[10]	MONTANA M, CAMACHO A, SERRANO I, et al. Removal of radionuclides in drinking water by membrane treatment using ultrafiltration, reverse osmosis and electrodialysis reversal[J]. J. Environ. Radioact., 2013, 125:86-92.
[11]	侯立安, 左莉. 纳滤膜分离技术处理放射性污染废水的试验研究[J]. 给水排水, 2004, 30(10):47-49. HOU L A, ZUO L. Experimental research on nano-membrane filtration for radioactive contaminated wastewater treatment[J]. Water and Wastewater Engineering, 2004, 30(10):47-49.
[12]	LEFEBVRE X, PALMERI J, SANDEAUX J, et al. Nanofiltration modeling:a comparative study of the salt filtration performance of a charged ceramic membrane and an organic nanofilter using the computer simulation program nanoflux[J]. Separation and Purification Technology, 2003, 32:117-126.
[13]	KHAYET M. Treatment of radioactive wastewater solutions by direct contact membrane distillation using surface modified membranes[J]. Desalination, 2013, 321:60-66.
[14]	KOSCHUH W, THANG V H, KRASTEVA S, et al. Flux and retention behaviour of nanofiltration and fine ultrafiltration membranes in filtrating juice from a green biorefinery:a membrane screening[J]. Journal of Membrane Science, 2005, 261(1/2):121-128.
[15]	AL-ZOUBI H, OMAR W. Rejection of salt mixtures from high saline by nanofiltration membranes[J]. Korean Journal of Chemical Engineering, 2009, 26(3):799-805.
[16]	SEREEWATTHANAWUT I, BAPTISTA I I R, BOAM A T, et al. Nanofiltration process for the nutritional enrichment and refining of rice bran oil[J]. Journal of Food Engineering, 2011, 102(1):16-24.
[17]	GAUBERT E, BARNIER H, MAUREL A, et al. Selective strontium removal from a sodium nitrate aqueous medium by nanofiltration[J]. Separation Science and Technology, 1997, 32(1/2/3/4):585-597.
[18]	HWANG J, DAIGUJI H. Ion transport in sub-10 nm nanofluidic channels:synthesis, measurement, and modeling[J]. Israel Journal of Chemistry, 2014, 54(11/12):1509-1518.
[19]	SZOKE S, PATZAY G, WEISER L. Cobalt(Ⅲ) EDTA complex removal from aqueous alkaline borate solutions by nanofiltration[J]. Desalination, 2005, 175:179-185.
[20]	GHERASIM C V, HANCKOV K, PALAR? K J, et al. Investigation of cobalt(Ⅱ) retention from aqueous solutions by a polyamide nanofiltration membrane[J]. Journal of Membrane Science, 2015, 490:46-56.
[21]	OLIVEIRA E E D, BARBOSA C C R, AFONSO J C. Stability of a nanofiltration membrane after contact with a low-level liquid radioactive waste[J]. Quimica Nova, 2013, 36(9):1434-1440.
[22]	胡保安, 成琼, 张东, 等. 聚偏氟乙烯中空纤维膜的耐辐射性能研究[J]. 化学工程, 2007, 35(10):34-38. HU B A, CHENG Q, ZHANG D, et al. Study on the radiation resistance of poly-vinylidene fluoride hollow fiber membrane[J]. Chemical Engineering(China), 2007, 35(10):34-38.
[23]	陆亚伟, 陈献富, 闻娟娟, 等. 改进的颗粒溶胶工艺制备高性能ZrO2-TiO2复合纳滤膜[J]. 化工学报, 2015, 66(9):3769-3775. LU Y W, CHEN X F, WEN J J, et al. Fabrication of high performance ZrO2-TiO2 NF membranes via a modified colloidal sol-gel process[J]. CIESC Journal, 2015, 66(9):3769-3775.
[24]	CHEVEREAU E, ZOUAOUI N, LIMOUSY L, et al. Surface properties of ceramic ultrafiltration TiO2 membranes:effects of surface equilibriums on salt retention[J]. Desalination, 2010, 255:1-8.
[25]	PUHLF R P, VOIGT A, WEBER R, et al. Microporous TiO2 membranes with a cut off
[26]	SCHAEP J, VANDECASTEELE C, PEETERS B, et al. Characteristics and retention properties of a mesoporous γ-Al2O3 membrane for nanofiltration[J]. Journal of Membrane Science, 1999, 163(2):229-237.
[27]	PEETERS J M M, BOOM J P, MULDER M H V, et al. Retention measurements of nanofiltration membranes with electrolyte solutions[J]. Journal of Membrane Science, 1998, 145(2):199-209.
[28]	CAI Y Y, WANG Y, CHEN X F, et al. Modified colloidal sol-gel process for fabrication of titania nanofiltration membranes with organic additives[J]. Journal of Membrane Science, 2015, 476:432-441.
[29]	孙宝红, 笪晓薇, 范益群. 纳滤膜材质对高含盐体系中有机物截留性能的影响研究[J]. 膜科学与技术, 2015, 35(2):14-19. SUN B H, DA X W, FAN Y Q. Effect of nanofiltration membrane materials on the retention properties of organics in high salinity system[J]. Membrane Science and Technology, 2015, 35(2):14-19.
[30]	SUJISH D, MOHANAKRISHNAN G, SHARMA B K, et al. Application of nanofiltration membrane and ethyleneimine oligomer mixture for selective separation of Strontium from a simulated nuclear waste solution[J]. Desalination and Water Treatment, 2014, 52(1/2/3):401-406.
[31]	白庆中, 陈红盛, 叶裕才, 等. 无机纳滤膜处理低水平放射性废水的试验研究[J]. 环境科学, 2006, 27(7):1334-1338. BAI Q Z, CHEN H S, YE Y C, et al. Experimental study on the treatment of low level radioactive waste water by inorganic nanofiltration membrane[J]. Environmental Science, 2006, 27(7):1334-1338.

ZrO₂-TiO₂复合纳滤膜在模拟放射性废水中的应用

Application of ZrO₂-TiO₂ composite nanofiltration membrane for treatment of simulative radioactive waste water

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 31

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吕阳光, 左培培, 杨正金, 徐铜文. 三嗪框架聚合物膜用于有机纳滤甲醇/正己烷分离[J]. 化工学报, 2023, 74(4): 1598-1606.
[2]	王思琪, 顾天宇, 陈献富, 王通, 李佳, 柯威, 李小锋, 范益群. 陶瓷膜用于杜仲叶提取液澄清的分离特性与膜污染机制研究[J]. 化工学报, 2023, 74(3): 1113-1125.
[3]	陈献富, 王冬雨, 范益群, 邢卫红, 乔旭. 基于3D打印的多孔陶瓷膜研究进展[J]. 化工学报, 2023, 74(1): 105-115.
[4]	马语峻, 刘向军. 多孔陶瓷膜烟气水分回收理论与模型研究[J]. 化工学报, 2022, 73(9): 4103-4112.
[5]	季超, 刘炜, 漆虹. 基于空冷的疏水陶瓷膜冷凝器用于烟气脱湿过程强化的实验研究[J]. 化工学报, 2022, 73(5): 2174-2182.
[6]	周国莉, 韩项珂, 武文佳, 王景涛, 张毛娃, 李凤丽. 异质结构g-C₃N₄@AM层状膜构筑及纳滤性能研究[J]. 化工学报, 2022, 73(2): 941-950.
[7]	张后虎, 吴晓莉, 陈冲冲, 陈静静, 王景涛. CD-MOF二维层状膜制备及混合溶剂精准分离研究[J]. 化工学报, 2022, 73(10): 4539-4550.
[8]	李燕, 王敏, 赵有璟, 王怀有, 杨红军, 祝增虎. 纳滤膜对高镁锂比盐湖卤水镁锂分离性能研究[J]. 化工学报, 2021, 72(6): 3130-3139.
[9]	刘嘉玮, 郝雨峰, 苏延磊. 石墨烯量子点纳滤膜的仿生修饰及稳定性研究[J]. 化工学报, 2021, 72(6): 3390-3398.
[10]	冉瑾,黄强,艾新宇,吴玉莹,张朋朋,窦焰. Zn-BTC/MoS₂复合二维膜构筑及有机溶剂纳滤性能研究[J]. 化工学报, 2021, 72(4): 2148-2155.
[11]	陆至彬, 谢星, 鲁思达, 何畅, 张冰剑, 陈清林. 基于代理模型的含盐废水多级纳滤系统的过程优化设计[J]. 化工学报, 2021, 72(3): 1400-1408.
[12]	何鹏鹏, 赵颂, 毛晨岳, 王志, 王纪孝. 耐溶剂复合纳滤膜的研究进展[J]. 化工学报, 2021, 72(2): 727-747.
[13]	杨丰瑞, 王志, 燕方正, 韩向磊, 王纪孝. 纳滤用于一价/二价无机盐溶液分离研究进展[J]. 化工学报, 2021, 72(2): 799-813.
[14]	刘宁, 褚昌辉, 王乾, 孙世鹏. 用于混合一价盐分离的纳滤膜的制备及性能研究[J]. 化工学报, 2021, 72(1): 578-588.
[15]	滕达, 李铁林, 李昂, 安连锁, 沈国清, 张世平. 单通道陶瓷膜管低压透水性能实验分析[J]. 化工学报, 2020, 71(S1): 261-271.