中低负荷下脉动热管壁温信号的分形特性分析

doi:10.11949/j.issn.0438-1157.20150957

摘要/Abstract

摘要：

运用功率谱、小波分解、相空间重构、关联维数计算等非线性分析方法对脉动热管壁面温度波动信号分析。表明:功率谱呈现连续谱线,时间序列存在自相似性,展现温度波动信号的混沌行为;小波分解表现出温度波动的分形特性;重构吸引子展现出4种不同的空间分形结构,说明温度信号波动属于分形下的混沌行为。计算分形维数与传热性能的关系,发现系统存在3~6个分形维;随嵌入维数的增加,分形速度关系为R134a大于丙酮大于去离子水,基本表现为分形维数越大,传热性能越好。并发现关联维和热阻成负相关关系。

关键词: 脉动热管, 非线性动力学, 分形, 混沌, 吸引子, 功率谱, 关联维

Abstract:

Various method, including analyses of power spectrum, wavelet decomposition, pseudo-phase-plane trajectories and correlation dimension, were used to analyze the non-linear dynamics characteristics of temperature oscillation signal of pulsating heat pipes (PHPs). A continuous line, self-similarity were identified under different sampling frequency, and the chaotic behavior of temperature oscillation signal was shown by power spectrum diagram. Wavelet decomposition indicated fractal characteristics of temperature oscillation. Four types of attractors were identified under different power inputs, which showed different space fractal structure. It was found that the temperature fluctuations belong to fractal chaotic behavior. All of the calculated fractal dimension showed that the system existed 3—6 fractal dimension. With the increase of embedding dimension, the fractal speed relations as R134a was greater than acetone, and acetone was higher than deionized water. For most runs, the large correlation dimensions were corresponded to better thermal performance.

Key words: pulsating heat pipe, non-linear dynamics, fractal, chaos, attractor, power spectrum, correlation dimension

中图分类号:

TH137.8

方海洲, 杨洪海, 王军, 李建华, 邹晶. 中低负荷下脉动热管壁温信号的分形特性分析[J]. 化工学报, 2016, 67(4): 1251-1257.

FANG Haizhou, YANG Honghai, WANG Jun, LI Jianhua, ZOU Jing. Fractal characteristics of temperature oscillation in pulsating heat pipe under medium-low load[J]. CIESC Journal, 2016, 67(4): 1251-1257.

参考文献 21

[1]	MIYAZAKI Y, AKACHI H. Heat transfer characteristics of looped capillary heat pipe[C]//Proceeding of 5th International Heat Pipe Symposium. Melbourne, Australia, 1996: 378-383.
[2]	CHAROENSAWAN P, KHANDEKAR S, GROLL M, et al. Closed loop pulsatingheat pipes (A): Parametric experimental investigations[J]. Applied Thermal Engineering, 2003, 23(16): 2009-2020.
[3]	杨洪海, 韩洪达, GROLL M. 倾斜角及充液率对脉动热管运行性能的影响[J]. 动力工程, 2009, 29(2): 159-162. YANG H H, HAN H D, GROLL M. Tilt angle and liquid rate affect the performance of pulsating heat pipe operation[J]. Journal of Power Engineering, 2009, 29(2): 159-162.
[4]	史维秀, 潘利生, 李惟毅. 倾角及冷却工况对多通路并联回路板式脉动热管传热性能的影响[J]. 化工学报, 2014, 65(2): 532-537. DOI: 10.3969/j.issn.0438-1157.2014.02.023. SHI W X, PAN L S, LI W Y. Influences of inclination and cooling condition on heat transfer performance of closed loop plate pulsating heat pipe with parallel channels[J]. CIESC Journal, 2014, 65(2): 532-537. DOI: 10.3969/j.issn.0438-1157.2014.02.023.
[5]	王迅, 李达, 李云昭. 甲醇水溶液脉动热管的传热特性[J].化工进展, 2014, 33(12): 3170-3175. DOI: 10.3969/j.issn.1000-6613. 2014.12.007 WANG X, LI D, Li Y Z. Heat transfer characteristics of pulsating heat pipe with aqueous methanol as working fluid[J]. Chemical Industry and Engineering Progress, 2014, 33(12): 3170-3175. DOI: 10.3969/j.issn.1000-6613.2014.12.007.
[6]	汪双凤, 胡艳鑫, 李选友. 自湿润流体热管的热输送性能[J].化工学报, 2012, 63(12): 3791-3797. DOI: 10.3969/j.issn.0438-1157. 2012.12.008 WANG S F, HU Y X, LI X Y. Heat-transport capability of self-rewetting fluid heat pipe[J]. CIESC Journal, 2012, 63(12): 3791-3797. DOI: 10.3969/j.issn.0438-1157.2012.12.008.
[7]	崔晓钰, 于洋, 朱悦等. 振荡热管传热性能与工质物性关系分析[J]. 化工进展, 2013, 32(9): 2035-2042. DOI: 10.3969/j.issn. 1000-6613.2013.09.006. CUI X Y, YU Y, ZHU Y, et al. Correlation study on physical properties of working fluids and heat transfer performance of pulsating heat pipes[J]. Chemical Industry and Engineering Progress, 2013, 32(9): 2035-2042. DOI: 10.3969/j.issn.1000-6613.2013.09.006.
[8]	韩振兴, 王冬骁, 王飞, 等. 重力热管冷凝段运行特征的可视化实验研究[J].化工学报, 2014, 65(8): 2934-2939. DOI: 10.3969/j.issn.0438-1157.2014.08.012. HAN Z X, WANG D X, WANG F, et al. Visual experimental study on operation characteristics of condensation segment of gravity-assisted heat pipe[J]. CIESC Journal, 2014, 65(8): 2934-2939. DOI: 10.3969/j.issn.0438-1157.2014.08.012.
[9]	史维秀, 李惟毅, 潘利生. 多通路并联回路板式脉动热管可视化及启动性能试验研究[J]. 机械工程学报, 2014, (4): 155-161. DOI: 10.3901/JME.2014.04.155. SHI W X, LI W Y, PAN L S. Experiment study on visualization and start-up performance of closed loop plate pulsating heat pipe with parallel channels[J]. Journal of Mechanical Engineering, 2014, (4): 155-161. DOI: 10.3901/JME.2014.04.155.
[10]	崔晓钰, 温建华, GROLL M. 基于神经网络的振荡热管传热性能建模[J]. 化工学报, 2003, 54(9): 1319-1322. CUI X Y, WEN J H, GROLL M. The oscillating heat pipe heat transfer performance modeling based on neural network[J]. Journal of Chemical Industry and Engineering (China), 2003, 54(9): 1319-1322.
[11]	苏磊, 张红. 回路脉动热管运行稳定性分析[J]. 化工学报, 2007, 58(8): 1931-1934. SU L, ZHANG H. Stability analysis of loop pulsating heat pipe operation[J]. Journal of Chemical Industry and Engineering (China), 2007, 58(8): 1931-1934.
[12]	方立德, 张垚, 张万岭, 等. 基于声发射技术的垂直管气液两相流动检测方法[J]. 化工学报, 2014, 65(4): 1243-1250. DOI: 10.3969/j.issn.0438-1157.2014.04.013. FANG L D, ZHANG Y, ZHANG W L, et al. Flow detection technology based on acoustic emission of gas-liquid two-phase flow in vertical pipe[J]. CIESC Journal, 2014, 65(4): 1243-1250. DOI: 10.3969/j.issn.0438-1157.2014.04.013.
[13]	方立德, 梁玉娇, 李小亭, 等.基于近红外技术的气液两相流检测装置[J]. 电子测量与仪器学报, 2014, (5): 528-532. DOI: 10.13382/j.jemi.2014.05.010. FANG L D, LIANG Y J, LI X T, et al. Detection device for gas-liquid two-phase flow based on near-infrared technology[J]. Journal of Electronic Measurement and Instrumentation, 2014, (5): 528-532. DOI: 10.13382/j.jemi.2014.05.010.
[14]	宋延熙, 徐进良. 脉冲热管温度时间序列的非线性混沌分析[J]. 化工学报, 2008, 59(10): 2470-2477. SONG Y X, XU J L. Chaotic analysis of temperature time series of pulsating heat pipe[J]. Journal of Chemical Industry and Engineering (China), 2008, 59(10): 2470-2477.
[15]	SONG Y X, XU J L. Chaotic behavior of pulsating heat pipes[J]. International Journal of Heat and Mass Transfer, 2009, 52(13/14): 2932-2941
[16]	QU J, WU H Y, CHENG P. Non-linear analyses of temperature oscillations in a closed-loop pulsating heat pipe[J]. International Journal of Heat and Mass Transfer, 2009, 52(15/16): 3481-3489
[17]	SHI W X, LI W Y, PAN L S, et al. Heat transfer properties and chaotic analysis of parallel type pulsating heat pipe[J]. Transactions of Tianjin University, 2011, (6): 435-439. DOI: 10.1007/s12209-011-1638-9.
[18]	强爱红, 刘明言, 孙永利. 汽液固三相流动沸腾传热系统的非线性特性[J]. 化工学报, 2005, 56(5): 779-785. QIANG A H, LIU M Y, SUN Y L. Nonlinear characteristics in vapor-liquid-solid flow boiling system[J]. Journal of Chemical Industry and Engineering (China), 2005, 56(5): 779-785.
[19]	董芳. 气液两相流流动结构多尺度及非线性特性分析[D]. 天津: 天津大学, 2007. DONG F. Multi-scale and nonlinear characteristic analysis of gas/liquid two-phase flow structure[D]. Tianjin: Tianjin University, 2007.
[20]	方立德, 张计科, 王农, 等. K型热电偶动态响应特性研究[J]. 电子测量技术, 2010, (11): 18-20. FANG L D, ZHANG J K, WANG N, et al. Study of dynamic response on characteristics of K-type thermocouple[J] Electronic Measurement Technology, 2010, (11): 18-20.
[21]	刘加怒, 李强, 傅涛, 等. 测量温度传感器的时间响应特性[J]. 物理实验, 2009, (8): 7-9. LIU J N, LI Q, FU T, et al. The time response characteristics of measuring temperature sensor[J]. Physical Experiment, 2009, (8): 7-9.