高含水菌渣流化床燃烧NOx、SO2排放特性

doi:10.11949/j.issn.0438-1157.20170035

化工学报 ›› 2017, Vol. 68 ›› Issue (8): 3250-3257.DOI: 10.11949/j.issn.0438-1157.20170035

高含水菌渣流化床燃烧NO_x、SO₂排放特性

葛亚昕^1,2, 张光义¹, 崔丽杰², 高士秋¹

1 中国科学院过程工程研究所多相复杂系统国家重点实验室, 北京 100190;
2 中国科学院大学化学与化工学院, 北京 100049

收稿日期:2017-01-09 修回日期:2017-05-02 出版日期:2017-08-05 发布日期:2017-08-05
通讯作者: 张光义
基金资助:
政府间国际科技合作项目（2016YFE0118000）。

Characteristics of NO_x and SO₂ emission from combustion of antibiotic mycelial residue with high water content in fluidized bed reactor

GE Yaxin^1,2, ZHANG Guangyi¹, CUI Lijie², GAO Shiqiu¹

1 State Key Laboratory of Multi-phase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China;
2 School of Chemistry and Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, China

Received:2017-01-09 Revised:2017-05-02 Online:2017-08-05 Published:2017-08-05
Supported by:
supported by the China-Japanese Research Cooperative Program-China (2016YFE0118000).

摘要/Abstract

摘要：

采用流化床反应器，研究了高含水抗生素菌渣直接燃烧的NO_x、SO₂排放特性。结果表明，增加过量空气系数，NO_x排放浓度升高，SO₂排放浓度降低；升高燃烧温度，NO_x及SO₂排放浓度均升高；随着燃料含水率的增加，NO_x及SO₂排放浓度均呈现先降低后升高的趋势。空气分级燃烧能有效降低NO_x排放，二次风率增加，NO_x排放浓度显著降低；当二次风率为3/7时，NO_x排放浓度较传统燃烧降低50%。添加CaCO₃进行炉内脱硫，实验结果显示：随钙硫摩尔比（Ca/S）增加，SO₂排放浓度下降，当Ca/S 3时，SO₂排放浓度降低到25 mg·m^-3以下，脱硫效率超过99%。

关键词: 抗生素菌渣, 流化床, 燃烧, 高含水, NO_x排放, SO₂排放, 空气分级, 脱硫

Abstract:

The characteristics of NO_x and SO₂ emission from combustion of antibiotic mycelial residue with high water content in a fluidized bed reactor were studied. The results showed that with the increase in excess air ratio, the NO_x emission concentration increased while the SO₂ emission concentration decreased. Enhancing the combustion temperature led to the increases in both the NO_x and SO₂ emission concentrations. With increasing fuel moisture content, both the NO_x and SO₂ emission concentrations first decreased and then increased. The air-staging combustion enabled good control of NO_x emission. The NO_x emission concentration was significantly lower with increasing the secondary air ratio. At the secondary air ratio 3/7, the air-staging combustion cut the NO_x emission amount off by more than 50% compared to the traditional combustion. Desulfurization by adding CaCO₃ into the furnace indicated that the SO₂ emission concentration decreased with increasing molar ratio of calcium to sulfur (Ca/S), and when Ca/S 3, the SO₂ emission concentration decreased to below 25 mg·m^-3 and the sulfur removal efficiency surpassed 99%.

Key words: antibiotic mycelia residue, fluidized-bed, combustion, high water content, NO_x emission, SO₂ emission, air-staging, desulfurization

中图分类号:

X705

葛亚昕, 张光义, 崔丽杰, 高士秋. 高含水菌渣流化床燃烧NO_x、SO₂排放特性[J]. 化工学报, 2017, 68(8): 3250-3257.

GE Yaxin, ZHANG Guangyi, CUI Lijie, GAO Shiqiu. Characteristics of NO_x and SO₂ emission from combustion of antibiotic mycelial residue with high water content in fluidized bed reactor[J]. CIESC Journal, 2017, 68(8): 3250-3257.

参考文献 28

[1]	李再兴, 田宝阔, 左剑恶, 等. 抗生素菌渣处理处置技术进展[J]. 环境工程, 2012, 30(2):72-75. LI Z X, TIAN B K, ZUO J E, et al. Progress in treatment and disposal technology of antibiotic bacterial residues[J]. Environmental Engineering, 2012, 30(2):72-75.
[2]	PRUDEN A, LARSSON D G, AMÉZQUITA A, et al. Management options for reducing the release of antibiotics and antibiotic resistance genes to the environment[J]. Environmental Health Perspectives, 2013, 121(8):878-885.
[3]	HERNÁNDEZ F, SANCHO J V, IBÁÑEZ M, et al. Antibiotic residue determination in environmental waters by LC-MS[J]. TrAC Trends in Analytical Chemistry, 2007, 26(6):466-485.
[4]	成建华, 张文莉. 抗生素菌渣处理工艺设计[J]. 化工与医药工程, 2003, 24(2):31-34. CHENG J H, ZHANG W L. Design of engineering process for antibiotic bacterial disposal[J].Chemical and Pharmaceutical Engineering, 2003, 24(2):31-34.
[5]	贡丽鹏, 郭斌, 任爱玲,等. 抗生素菌渣理化特性[J]. 河北科技大学学报, 2012, 33(2):190-196. GONG L P, GUO B, REN A L, et al. Physical and chemical properties of antibiotics bacterial residue[J].Journal of Hebei University of Science and Technology,2012, 33(2):190-196.
[6]	ZHANG G, MA D, PENG C, et al. Process characteristics of hydrothermal treatment of antibiotic residue for solid biofuel[J]. Chemical Engineering Journal, 2014, 252(252):230-238.
[7]	BROEK R V D, FAAIJ A, WIJK A V. Biomass combustion for power generation[J]. Biomass & Bioenergy, 1996, 11(4):271-281.
[8]	BHATTACHARYA S C. State of the art of biomass combustion[J]. Energy Sources, 1998, 20(2):113-135.
[9]	WERTHER J, SAENGER M, HARTGE E U, et al. Combustion of agricultural residues[J]. Progress in Energy & Combustion Science, 2000, 26(1):1-27.
[10]	MUSGRAVE F F, HINSHELWOOD C N. The interaction of carbon monoxide and nitric oxide[J]. J. Chem. Soc., 1933:56-59.
[11]	ZHANG G, ZHU C, GE Y, et al. Fluidized bed combustion in steam-rich atmospheres for high-nitrogen fuel:nitrogen distribution in char and volatile and their contributions to NOx[J]. Fuel, 2016, 186:204-214.
[12]	PERMCHART W, KOUPRIANOV V I. Emission performance and combustion efficiency of a conical fluidized-bed combustor firing various biomass fuels[J]. Bioresource Technology, 2004, 92(1):83-91.
[13]	MA D, ZHANG G, AREEPRASERT C, et al. Characterization of NO emission in combustion of hydrothermally treated antibiotic mycelial residue[J]. Chemical Engineering Journal, 2016, 284:708-715.
[14]	HOU H, LI S, LU Q. Gaseous emission of monocombustion of sewage sludge in a circulating fluidized bed[J]. Ind. Eng. Chem. Res., 2013, 52(16):5556-5562.
[15]	侯海盟. 城市下水污泥循环流化床焚烧及排放特性试验研究[D]. 北京:中国科学院研究生院(工程热物理研究所), 2013. HOU H M. Experimental study on incineration characteristics and pollutant emission of sewage sludge in circulating fluidized bed[D]. Beijing:Graduate University of Chinese Academy of Sciences (Institute of Engineering Thermophysics), 2013.
[16]	李伟, 李诗媛, 徐明新,等. 循环流化床富氧燃烧SO2排放和石灰石脱硫特性研究[J]. 中国电机工程学报, 2014, 34(23):3932-3937. LI W, LI S Y, XU M X, et al. Study on SO2 emission and limestone desulfurization characteristics for oxy-fuel circulating fluidized bed combustion[J]. Proceedings of the CSEE,2014, 34(23):3932-3937.
[17]	ZHU C, LIU S, LIU H, et al. NOx emission characteristics of fluidized bed combustion in atmospheres rich in oxygen and water vapor for high-nitrogen fuel[J]. Fuel, 2015, 139:346-355.
[18]	GLARBORG P, KUBEL D, KRISTENSEN P G, et al. Interactions of CO, NOx and H2O under post-flame conditions[J]. Combustion Science and Technology, 1995, 110/111(1):461-485.
[19]	LI S, WEI X, GUO X. Effect of H2O vapor on NO reduction by CO:experimental and kinetic modeling study[J]. Energy & Fuels, 2012, 26(7):4277-4283.
[20]	刘欢. 流化床中燃烧高含水含氮酒糟的NO排放特性[D]. 北京:中国科学院大学, 2014. LIU H. NO emission from burning distilled spirit lees with high contents of moisture and nitrogen in a fluidized bed[D]. Beijing:University of Chinese Academy of Sciences, 2014.
[21]	刘欢, 崔丽杰, 朱传强,等. 流化床中燃烧高水高氮酒糟的NO排放特性[J]. 化工学报, 2015, 66(7):2694-2701. LIU H, CUI L J, ZHU C Q, et al. NO emission from burning distilled spirit lees with high contents of moisture and nitrogen in fluidized bed[J]. CIESC Journal, 2015, 66(7):2694-2701.
[22]	SHIMIZU T, TOYONO M. Emissions of NOx, and N2O during co-combustion of dried sewage sludge with coal in a circulating fluidized bed combustor[J]. Fuel, 2007, 86(7/8):957-964.
[23]	TOURUNEN A, SAASTAMOINEN J, NEVALAINEN H. Experimental trends of NO in circulating fluidized bed combustion[J]. Fuel, 2009, 88(7):1333-1341.
[24]	WERTHER J, OGADA T. Sewage sludge combustion[J]. Progress in Energy & Combustion Science, 1999, 25(1):55-116.
[25]	GARCA-CORTÉS J M, PREZ-RAMÍREZ J. Effect of the support in de-NOx HC-SCR over transition metal catalysts[J]. Reaction Kinetics, Mechanisms and Catalysis, 2000, 70(2):199-206.
[26]	ZHAO Z, WEN L, LI B. Catalytic reduction of NO by coal chars loaded with Ca and Fe in various atmospheres[J]. Fuel, 2002, 81(11/12):1559-1564.
[27]	CZAKIERT T, MUSKALA W, JANKOWSKA S, et al. Combustible matter conversion in an oxy-fuel circulating fluidized-bed (CFB) environment[J]. Energy & Fuels, 2012, 26(9):5437-5445.
[28]	郭浩然. 氧分级富氧燃烧条件下钙基吸附剂联合脱除的实验研究[D]. 哈尔滨:哈尔滨工业大学, 2013. GUO H R. Experimental research on the simultaneous reduction of pollutants by calcium-based sorbents with oxidant stated oxy-fuel combustion[D]. Harbin:Harbin Institute of Technology,2013.

高含水菌渣流化床燃烧NO_x、SO₂排放特性

Characteristics of NO_x and SO₂ emission from combustion of antibiotic mycelial residue with high water content in fluidized bed reactor

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 28

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吴曦, 区祖迪, 张鑫杰, 徐士鸣, 朱晓静. HFO-1243zf爆燃特性实验研究[J]. 化工学报, 2023, 74(S1): 346-352.
[2]	杨峥豪, 何臻, 常玉龙, 靳紫恒, 江霞. 生物质快速热解下行式流化床反应器研究进展[J]. 化工学报, 2023, 74(6): 2249-2263.
[3]	陈巨辉, 张谦, 舒崚峰, 李丹, 徐鑫, 刘晓刚, 赵晨希, 曹希峰. 基于DEM方法的旋转流化床纳米颗粒流动特性研究[J]. 化工学报, 2023, 74(6): 2374-2381.
[4]	于源, 陈薇薇, 付俊杰, 刘家祥, 焦志伟. 几何相似涡流空气分级机环形区流场变化规律研究及预测[J]. 化工学报, 2023, 74(6): 2363-2373.
[5]	张媛媛, 曲江源, 苏欣欣, 杨静, 张锴. 循环流化床燃煤机组SNCR脱硝过程气液传质和反应特性[J]. 化工学报, 2023, 74(6): 2404-2415.
[6]	李晨曦, 刘永峰, 张璐, 刘海峰, 宋金瓯, 何旭. O₂/CO₂氛围下正庚烷的燃烧机理研究[J]. 化工学报, 2023, 74(5): 2157-2169.
[7]	袁子涵, 王淑彦, 邵宝力, 谢磊, 陈曦, 马一玫. 基于幂律液固曳力模型流化床内湿颗粒流动特性的研究[J]. 化工学报, 2023, 74(5): 2000-2012.
[8]	陈宇豪, 陈晓平, 马吉亮, 梁财. 市政污泥回转窑焚烧气态污染物排放特性研究[J]. 化工学报, 2023, 74(5): 2170-2178.
[9]	任金胜, 刘克润, 焦志伟, 刘家祥, 于源. 涡流空气分级机近导叶处团聚体解团机理研究[J]. 化工学报, 2023, 74(4): 1528-1538.
[10]	白天昊, 王晓雯, 杨梦滋, 段新伟, 米杰, 武蒙蒙. 类水滑石衍生锌基氧化物高温煤气脱硫过程中COS释放行为及其抑制研究[J]. 化工学报, 2023, 74(4): 1772-1780.
[11]	禹进, 余彬彬, 蒋新生. 一种基于虚拟组分的燃烧调控化学作用量化及分析方法研究[J]. 化工学报, 2023, 74(3): 1303-1312.
[12]	孙嘉辰, 裴春雷, 陈赛, 赵志坚, 何盛宝, 巩金龙. 化学链低碳烷烃氧化脱氢技术进展[J]. 化工学报, 2023, 74(1): 205-223.
[13]	王永倩, 王平, 程康, 毛晨林, 刘文锋, 尹智成, Ferrante Antonio. 氨气/甲烷贫预混旋转湍流火焰稳定性及NO生成[J]. 化工学报, 2022, 73(9): 4087-4094.
[14]	袁妮妮, 郭拓, 白红存, 何育荣, 袁永宁, 马晶晶, 郭庆杰. 化学链燃烧过程Fe₂O₃/Al₂O₃载氧体表面CH₄反应：ReaxFF-MD模拟[J]. 化工学报, 2022, 73(9): 4054-4061.
[15]	唐恺鸿, 何晓峰, 徐桂秋, 于洋, 刘啸凤, 葛铁军, 张爱玲. 酚醛泡沫的燃烧行为及阻燃研究进展[J]. 化工学报, 2022, 73(8): 3483-3500.