Heat transfer characteristics of water flowing along icicle at low Reynolds number

doi:10.11949/j.issn.0438-1157.20171238

Abstract

Abstract:

The heat characteristics and moving regulation of phase change interface during the progress of water flowing along icicle at low Reynolds number are investigated. The mapping relationship between the experimental data and the heat transfer coefficient in phase change interface of icicle is built. Moving regulation of phase change interface of icicle is recorded by using industrial cameras through changing initial dimension of icicle, initial temperature in icicle, velocity and temperature of water. By analyzing the experimental results, some conclusions are as follow:the number of azimuths is different for each measurement point, as the melting process is carried out, the Nusselt number values of the measurement points increase first and then decrease, and there is a maximum value in the middle of the whole melting process. The convective heat transfer coefficient along the azimuth angle increases with the increase of the velocity or temperature of the water flow under the condition that the remaining experimental control parameters are unchanged. Empirical correlation of Nu_φ,Gr, Re, Pr, Ste and φ is obtained.

Key words: water flowing along icicle, phase change, convection, heat transfer

摘要：

通过实验研究了低Reynolds数条件下水流纵掠长冰柱过程的沿方位角相界面移动规律及传热特性。改变水流速度、水流温度、冰柱尺寸及冰柱初始温度等控制参数，采用非接触测量方法获得了冰柱融化图像，基于影像实验数据与冰柱相界面传热系数之间的映射关系，分析了沿方位角对流传热系数等传热参数的变化规律。结果表明：各测量点的沿方位角Nusselt数不同，随着融化过程的进行，各测量点的沿方位角Nusselt数值均先增大后减小，整个融化过程中间某处存在最大值；其余实验控制参数不变的条件下，沿方位角对流传热系数均随着水流速度或水流温度的增大而增加；获得了水流纵掠冰柱融化过程Nu_φ、Gr、Re、Pr、Ste及φ之间的关联式。

关键词: 水流纵掠冰柱, 相变, 对流, 传热

CLC Number:

TK02

MENG Fankang, CHU Qi, WANG Jinli. Heat transfer characteristics of water flowing along icicle at low Reynolds number[J]. CIESC Journal, 2018, 69(6): 2424-2431.

孟凡康, 褚琦, 王锦力. 低Reynolds数条件下水流纵掠长冰柱沿方位角传热特性[J]. 化工学报, 2018, 69(6): 2424-2431.

References 32

[1]	Sugawara M, Komatsu Y, Beer H. Melting of ice stuck on cylinders placed horizontally in a water flowing duct[J]. Heat and Mass Transfer, 2016, 52(4):693-700.
[2]	章学来, 孟祥来, 赵群志, 等. 冰蓄冷空调蓄冰成核[J]. 化工学报, 2014, 65(11):4321-4324. ZHANG X L,MENG X L,ZHAO Q Z,et al. Ice nucleation of ice thermal storage air-condition[J]. CIESC Journal, 2014, 65(11):4321-4324.
[3]	Sotiropoulou G, Tjernström M, Sedlar J, et al. Atmospheric conditions during the Arctic Clouds in Summer Experiment (ACSE):contrasting open water and sea ice surfaces during melt and freeze-up seasons[J]. Journal of Climate, 2016, 29(24):8721-8744.
[4]	Yamaha M, Nakahara N, Chiba R. Studies on thermal characteristics of ice thermal storage tank and a methodology for estimation of tank efficiency[J]. International Journal of Energy Research, 2008, 32(3):226-241.
[5]	Sang W H, Lee Y T, Chung J D, et al. Efficient numerical approach for simulating a full scale vertical ice-on-coil type latent thermal storage tank[J]. International Communications in Heat and Mass Transfer, 2016, 78:29-38.
[6]	Bourdillon A C, Verdin P G, Thompson C P. Numerical simulations of water freezing processes in cavities and cylindrical enclosures[J]. Applied Thermal Engineering, 2015, 75:839-855.
[7]	Habeebullah B A. An experimental study on ice formation around horizontal long tubes[J]. International Journal of Refrigeration, 2007, 30(5):789-797.
[8]	Stickland M T, Scanlon T J, MacKenzie J. An experimental investigation of natural convection with solidification in a differentially heated cavity[J]. International Journal of Heat and Mass Transfer, 2007, 50(1):36-44.
[9]	Alawadhi E M. A solidification process with free convection of water in an elliptical enclosure[J]. Energy Conversion and Management, 2009, 50(2):360-364.
[10]	Mandaoui M, Kousksou T, Blancher S. A numerical analysis of solid-liquid phase change heat transfer around a horizontal cylinder[J]. Applied Mathematical Modelling, 2014, 38(3):1101-1110.
[11]	Sugawara M, Onodera T, Komatsu Y, et al. freezing of water saturated in aluminum wool mats[J]. Heat and Mass Transfer, 2008, 44(7):835-843.
[12]	Sugawara M, Beer H. Numerical analysis for freezing/melting around vertically arranged four cylinders[J]. Heat and Mass Transfer, 2009, 45(9):1223-1231.
[13]	Kowalczyk W, Hartmann C, Delgado A. Modelling and numerical simulation of convection driven high pressure induced phase changes[J]. International Journal of Heat and Mass Transfer, 2004, 47(5):1079-1089
[14]	Li B, Xu X, Liu Y, et al. Effects of initial parameters on the internal-melt ice-on-tube while icing[J]. Journal of Mechanical Science and Technology, 2009, 23(7):1808-1812.
[15]	Lei G L, Dong W, Zheng M, et al. Numerical investigation on heat transfer and melting process of ice with different porosities[J]. International Journal of Heat and Mass Transfer, 2017, 107:934-944.
[16]	Saitoh T. Natural convection heat transfer from a horizontal ice cylinder[J]. Applied Scientific Research, 1976, 32(4):429-451.
[17]	GEBHART B, Wang T. An experimental study of melting vertical ice cylinders in cold water[J]. Chemical Engineering Communications, 1982, 13(4/5/6):197-218.
[18]	Yamada M, Fukusako S, Sayed M E B. Free convection heat transfer around a horizontal ice cylinder formed through melting within an immiscible liquid[J]. Heat and Mass Transfer, 1996, 31(6):419-426.
[19]	Yamada M, Fukusako S, Kawanami T, et al. Melting heat transfer characteristics of a horizontal ice cylinder immersed in quiescent saline water[J]. International Journal of Heat and Mass Transfer, 1997, 40(18):4425-4435.
[20]	Scanlon T J, Stickland M T. An experimental and numerical investigation of natural convection melting[J]. International Communications in Heat and Mass Transfer, 2001, 28(2):181-190.
[21]	孟凡康, 于航. 强迫与混合对流条件下水流顺掠冰柱传热特性[J]. 土木建筑与环境工程, 2015, 37(3):102-107. MENG F K, YU H. Heat transfer characteristics of water flowing along icicle under forced and mixed convection[J]. Journal of Civil, Architectural & Environmental Engineering, 2015, 37(3):102-107.
[22]	宋又王. 用奇异摄动法解圆柱体的凝固问题[J]. 工程热物理学报, 1981, 2(4):359-365. SONG Y W. On the solution of heat conduction in a cylindrical body undergoing solidification by the method of singular perturbation[J]. Journal of Engineering Thermophysics, 1981, 2(4):359-365.
[23]	Cheng K C, Indaba H, Gilpin R. Effects of natural convection on ice formation around an isothermally cooled horizontal cylinder[J]. Journal of Heat Transfer, 1988, 110(4a):931-937.
[24]	Ameen F R. Stagnation-line melting of ice cylinders transverse to warm air flow[J]. International Journal of Refrigeration, 1994, 17(6):381-390.
[25]	Yamada M, Okada M. Enhancement of the melting of an ice cylinder by the combination with the condensation of a saturated steam flow[J]. Journal of Thermal Science and Technology, 2001, 6(1):43-56.
[26]	刘道平, 周文铸, 陈之航. 有限空间内水平顺排管束外蓄冰过程特性的实验研究[J]. 制冷学报, 2003, 24(2):1-4. LIU D P, ZHOU W Z, CHEN Z H. Experimental study on characteristics of water freezing around nine tubes aligned horizontally in a rectangular space[J]. Journal of Refrigeration, 2003, 24(2):1-4.
[27]	李永辉. 融冰过程取冷特性数值模拟及分析[D]. 大连:大连理工大学, 2006. LI Y H. Numerical simulation of ice melting and heat transfer[D]. Dalian:Dalian University of Technology, 2006.
[28]	Erek A, Ezan M A. Experimental and numerical study on charging processes of an ice-on-coil thermal energy storage system[J]. International Journal of Energy Research, 2007, 31(2):158-176.
[29]	Shi W X, Wang B L, Li X T. A measurement method of ice layer thickness based on resistance-capacitance circuit for closed loop external melt ice storage tank[J]. Applied Thermal Engineering, 2005, 25(11):1697-1707.
[30]	别烈齐娜. 水生生物学[M]. 北京:科学出版社, 1953:73. Березина Н А. Aquatic Biology[M]. Beijing:Science Press, 1953:73.
[31]	中华人民共和国国家质量监督检验检疫总局. 测量不确定度评定与表示(JJF1059. 1-2012)[S]. 2012. General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Evaluation and expression of uncertainty in measurement (JJF1059. 1-2012)[S]. 2012.
[32]	Myers T G, Mitchell S L, Muchatibaya G. Unsteady contact melting of a rectangular cross-section material on a flat plate[J]. Physics of Fluids, 2008, 20(10):1-12.