Effect of velocity on behavior of droplet impacting superhydrophobic surface

doi:10.3969/j.issn.0438-1157.2012.10.003

CIESC Journal ›› 2012, Vol. 63 ›› Issue (10): 3027-3033.DOI: 10.3969/j.issn.0438-1157.2012.10.003

Previous Articles Next Articles

Effect of velocity on behavior of droplet impacting superhydrophobic surface

YANG Baohai^1,2, WANG Hong^1,2, ZHU Xun^1,2, DING Yudong^1,2, ZHOU Jin^1,2

1. Institute of Engineering Thermophysics, Chongqing University, Chongqing University, Chongqing 400030, China;
2. Key Laboratory of Low-grade Energy Utilization Technologies and Systems, Ministry of Education, Chongqing University, Chongqing 400030, China

Received:2012-04-19 Revised:2012-07-11 Online:2012-10-05 Published:2012-10-05
Supported by:
supported by the National Natural Science Foundation of China(50906102),the Natural Science Foundation of Chongqing(CSTC2011jjA90015),the Project-sponsored by SRF for ROCS,SEM([2010] 1561)and the Graduate Innovation Foundation(CDJXS11140003).

速度对液滴撞击超疏水壁面行为特性的影响

杨宝海^1,2, 王宏^1,2, 朱恂^1,2, 丁玉栋^1,2, 周劲^1,2

1. 重庆大学工程热物理研究所, 重庆 400030;
2. 低品位能源利用技术及系统教育部重点实验室, 重庆 400030

通讯作者: 王宏
作者简介:王宏,杨宝海(1986- ),男,博士研究生。
基金资助:
国家自然科学基金项目(50906102);重庆市自然科学基金项目(CSTC2011jjA90015);教育部留学回国人员科研启动基金项目(教外司留[2010] 1561号);研究生科技创新基金项目(CDJXS11140003)。

Abstract

Abstract: Superhydrophobic surface has been widely used both in industry and household products,and attracted intensive attention by researchers.In the present study,a water droplet impacting a superhydrophobic surface with the static contact angle of 156皐as experimentally studied at Weber number from 8 to 310.For capturing more information about the whole impacting process,a mirror was set underneath the transparent superhydrophobic surface to simultaneously obtain the images of both the top view and bottom view for the droplet impact and its motion in the air after rebounding.The experimental results showed that the advancing and receding angles as well as the velocity of triple-phase contact ring for the extended droplet on the surface,and the motion pattern in the air of the rebounding droplet were significantly affected by the initial velocity of water droplet.When a droplet impacted the superhydrophobic surface with a high velocity,three groups of satellite droplets were generated during the extension and retraction stages,and the coalescence of neighboring droplet fingers was observed to form a new larger droplet finger during the retraction stage.

Key words: superhydrophobic surface, droplet impacting, dynamic behaviors, visual experiment

摘要： 通过可视化实验研究了直径为2.58 mm的液滴在不同速度下撞击静态接触角为156°超疏水壁面后的运动特性,其液滴Weber数在8~310之间。实验利用光学原理在同一画面上同时记录了液滴撞击壁面过程的正面及底面图像。实验结果表明:液滴撞击壁面的速度对液滴的前进角、后退角,三相接触线的速度以及液滴反弹后的空中运动特性都有较大的影响;液滴高速撞击超疏水壁面后会产生明显的液指及多组卫星液滴,回缩阶段相邻的液指发生聚并直至液滴完全回缩。

关键词: 超疏水壁面, 液滴撞击, 动力行为, 可视化实验

CLC Number:

O359.1

YANG Baohai, WANG Hong, ZHU Xun, DING Yudong, ZHOU Jin. Effect of velocity on behavior of droplet impacting superhydrophobic surface[J]. CIESC Journal, 2012, 63(10): 3027-3033.

杨宝海, 王宏, 朱恂, 丁玉栋, 周劲. 速度对液滴撞击超疏水壁面行为特性的影响[J]. 化工学报, 2012, 63(10): 3027-3033.

References 21

[1]	WorthinGton A M.On the forms assumed by drops of liquids falling vertically on a horizontal plate[J].Proceedings of the Royal Society of London,1876,25:261-272
[2]	WorthinGton A M.A second paper on the forms assumed by drops of liquids falling vertically on a horizontal plate[J].Proceedings of the Royal Society of London,1876,25:498-503
[3]	Alam P,Toivakka M,Backfolk K,Sirvi P.Impact spreading and absorption of Newtonian droplets on topographically irregular porous materials[J].Chem.Eng.Sci.,2007,62(12):3142-3158
[4]	Levin Z,Hobbs P V.Splashing of water drops on solid and wetted surfaces:hydrodynamics and charge separation[J].Phil.R.Soc.London,1971,269:555-585
[5]	Hitoshi F,Yu S,Albert Y T,Takayuki H,Hirohiko T.Three-dimensional numerical analysis of the deformation behavior of droplets impinging onto a solid substrate[J].Int.J.Multiphase Flow,2007,33:317-332
[6]	Kannan R,Sivakumar D.Droplet impact process on a hydrophobic grooved surface[J].Colloids and Surfaces A:Physicochem.Eng.Aspects,2008,317:694-704
[7]	Manfredo G,Giorgio S.Experimental analysis on the shape and evaporation of water drops on high effusivity,microfinned surfaces[J].Exp.Therm. Fluid Sci.,2010,34:93-103
[8]	Kwak Geunjae,Lee Dong Woog,Kang In Seok,Yong Kijung.A study on the dynamic behaviors of water droplets impacting nanostructured surfaces[J].AIP Advances,2011,1(4):042139
[9]	Mohidus Samad Khan,Dushmantha Kannangara,Gil Garnier,Wei Shen.Effect of liquid droplet impact velocity on solid wicking kinetics in surface V-grooves[J].Chem.Eng.Sci.,2011,66(23):6120-6127
[10]	Li Xiying,Ma Xuehu,Lan Zhong.Behavioral patterns of drop impingement onto rigid substrates with a wide range of wettability and different surface temperature[J].AIChE J.,2009,55:1983-1992
[11]	Wachters L H J,Smulders L,Vermeulen J R,Kleiweg H C.The heat transfer from a hot wall to impinging water drops in the spheroidal state[J].Chem.Eng.Sci.,1966,21(12):1047-1056
[12]	Pan K L,Tseng K C,Wang C H.Breakup of a droplet at high velocity impacting a solid surface[J].Exp.Fluids,2009,48(1):143-156
[13]	Pan K L,Chou P C,Tseng Y J.Binary droplet collision at high Weber number[J].Phys.Rev.E:Stat.Phys.,Plasmas,Fluids,2009,80(3):036301
[14]	Wang Z,Lopez C,Hirsa A,Koratkar N.Impact dynamics and rebound of water droplets on surperhydrophobic carbon nanotube arrays[J].Appl.Phys.Lett.,2007,91(2):023105
[15]	Jung Y C,Bhushan B.Dynamic effects of bouncing water droplets on superhydrophobic surfaces[J].Langmuir,2008,24(12):6262-6269
[16]	Li Xiying,Ma Xuehu,Lan Zhong.Dynamic behavior of the water droplet impact on a textured hydrophobic/ superhydrophobic surface:the effect of the remaining liquid film arising on the pillars' tops on the contact time[J].Langmuir,2010,26(7):4831-4838
[17]	Sui Tao(隋涛),Wang Jiadao(汪家道),Chen Darong(陈大融).Energy analysis for transition from Cassie state to Wenzel state[J].CIESC Journal(化工学报),2011,62(5):1352-1357
[18]	Wang Songling(王松岭),Li Chunxi(李春曦),Ye Xuemin(叶学民).Drop spreading characteristics driven by gradients of temperature and surfactant concentration[J].CIESC Journal(化工学报),2011,62(9):2512-2519
[19]	Hung Yi-Lin,Wang Meng-Jiy,Liao Yu-Ching,Lin Shi-Yow.Initial wetting velocity of droplet impact and spreading:water on glass and parafilm[J].Colloids Surf.,A,2011,384(1/2/3):172-179
[20]	Bateni A,Susnar S S,Amirfazli A,Neumann A W.A high-accuracy polynomial fitting approach to determine contact angles[J].Colloids Surf.,A,2003,219(1):215-23
[21]	Elliott G E P,Riddiford A C.Dynamic contact angle(Ⅰ):The effect of impressed motion[J].Journal of Colloid and Interface Science,1967,23:389-398

Effect of velocity on behavior of droplet impacting superhydrophobic surface

速度对液滴撞击超疏水壁面行为特性的影响

PDF (PC)

Knowledge

Cited

Abstract

Cite this article

share this article

References 21

Related Articles 9

Recommended Articles

Metrics

Comments

[1]	Yingjie LI, Qixia LI, Hong WANG, Xun ZHU, Rong CHEN, Qiang LIAO, Yudong DING. Influence of wavy-structured superhydrophobic surfaces on coalescence-induced droplet jumping [J]. CIESC Journal, 2022, 73(10): 4345-4354.
[2]	Hongxia CHEN, Hongyang XIAO, Yuan SUN, Lin LIU. Experimental study on droplets boiling on micro-pillar structure surface with constant temperatures [J]. CIESC Journal, 2019, 70(9): 3363-3369.
[3]	Yexia CHAI, Huayan CHEN, Yue JIA, Dandan LI, Chunrui WU, Xiaolong LYU. Enhancement on steam dropwise condensation heat transfer with superhydrophobic surfaces of PVDF hollow fiber heat exchange tubes [J]. CIESC Journal, 2019, 70(4): 1331-1339.
[4]	Xin YAN, Jinliang XU. Character of sessile gold-water nanofluid droplet evaporation with solar heating on superhydrophobic surface [J]. CIESC Journal, 2019, 70(3): 892-900.
[5]	Chenhui HU, Yifei WANG, Zebin BAO, Guangsuo YU. Effect of solid particles in evaporative hot water tower on bubble movement [J]. CIESC Journal, 2019, 70(1): 39-48.
[6]	TANG Haida, ZHANG Tao, LIU Xiaohua, JIANG Yi. Size of departing condensate droplets from radiant cooling ceiling [J]. CIESC Journal, 2016, 67(9): 3552-3558.
[7]	LI Chunxi, ZHANG Shuo, XUE Quanxi, YE Xuemin. Drag reduction of superhydrophobic microchannels based on parabolic gas-liquid interfaces [J]. CIESC Journal, 2016, 67(10): 4126-4134.
[8]	LIU Yunhong, LI Guangji, CHEN Chao, PENG Xinyan, WANG Liying, CHEN Zhifeng. Preparation and antibacterial activity of superhydrophobic PET fabric [J]. CIESC Journal, 2014, 65(4): 1517-1525.
[9]	QU Xiaohang, TIAN Maocheng, ZHANG Guanmin, LUO Lincong. Direct contact condensation of steam bubbles with non-condensable gas [J]. CIESC Journal, 2014, 65(12): 4749-4754.