刚性波纹面与柔性波纹面传热及流动特性

doi:10.3969/j.issn.0438-1157.2012.11.006

化工学报 ›› 2012, Vol. 63 ›› Issue (11): 3418-3427.DOI: 10.3969/j.issn.0438-1157.2012.11.006

刚性波纹面与柔性波纹面传热及流动特性

汪健生, 李康宁, 高小明

天津大学机械工程学院, 中低温热能高效利用教育部重点实验室, 天津 300072

收稿日期:2012-01-12 修回日期:2012-08-13 出版日期:2012-11-05 发布日期:2012-11-05
通讯作者: 高小明
作者简介:汪健生(1964-),男,博士,副教授。
基金资助:
天津市科技支撑计划基金项目(11ZCKFCX02600)。

Heat transfer and flow characteristics on solid and flexible wavy surfaces

WANG Jiansheng, LI Kangning, GAO Xiaoming

Key Laboratory of Efficient Utilization of Low and Medium Grade Energy, Ministry of Education, School of Mechanical Engineering, Tianjin University, Tianjin 300072, China

Received:2012-01-12 Revised:2012-08-13 Online:2012-11-05 Published:2012-11-05
Supported by:
supported by the Tianjin Science and Technology Support Plan Foundation(11ZCKFCX02600).

摘要/Abstract

摘要： 采用大涡模拟方法,对流体在刚性及柔性波纹面上的流动与传热特性进行了数值研究。结果表明:对于刚性波纹面,当振幅与波长比值(a/λ)较小时,波谷区域无回流现象;当a/λ增大至0.03时,波谷区域出现回流区,且回流区域随波幅的增加而增大;波纹面上坡部位沿展向出现较高Nusselt数的斑块;当a/λ从0.01增至0.04时,时均Nusselt数提高了近63.5%,综合系数增加了0.5112。对于柔性波纹面,其压力分布也呈现周期性变化;且在上坡位置也出现较大Nusselt数斑块;当a/λ从0.01增至0.04时,时均Nusselt数值提高了173.1%,综合系数增加了1.1232。与刚性波纹面相比,在消耗相同流体输送泵功时,柔性波纹面具有更好的传热效果。

关键词: 大涡模拟, 波纹面, 强化传热, 流动减阻

Abstract: The flow and heat transfer characteristics over solid wavy surface and flexible wavy surface are investigated with large eddy simulation.For the solid wavy surface,it is found that smaller wave amplitude of wavy surface does not form the recirculation in the valley.When a/λ is increased to 0.03,the flow separation appears in the valley,and the range of recirculation area becomes broader as the amplitude increases.The spindle-shaped spots with higher Nusselt number value are observed in the up-slope of the wavy surface.As the value of a/λ varies from 0.01 to 0.04,the local time-averaged Nusselt number is enhanced about 63.5% and comprehensive coefficient is increased by 0.5112.For the flexible wavy surface,the results indicate that periodic fluctuation of the wavy surface induces a periodic variation of pressure.It is also found that the spindle-shaped spots with higher Nusselt number value appear in the up-slope part of the wavy surface.When the value of a/λ varies from 0.01 to 0.04,the time-averaged local Nusselt number and comprehensive coefficient are increased by 173.1% and 1.1232,respectively. Compared with the solid wavy surface,the flexible wavy wall will remarkably enhance the heat transfer in the same amplitude and consumption of fluid pumping power.

Key words: large eddy simulation, wavy surface, heat transfer enhancement, flow drag reduction

中图分类号:

TK124

汪健生, 李康宁, 高小明. 刚性波纹面与柔性波纹面传热及流动特性[J]. 化工学报, 2012, 63(11): 3418-3427.

WANG Jiansheng, LI Kangning, GAO Xiaoming. Heat transfer and flow characteristics on solid and flexible wavy surfaces[J]. CIESC Journal, 2012, 63(11): 3418-3427.

参考文献 15

[1]	Angelis V De,Lombardi P,Baneriee S.Direct numerical simulation of turbulent flow over a wavy wall[J].Phys. Fluids,1997,9(8):2429-2442
[2]	Hudson J D,Dykhno L,Hanratty T J.Turbulence production in flow over a wavy wall[J].Exp. Fluids,1996,20:257-265
[3]	Buckles J,Hanratty T J,Adrian R J.Turbulent flow over large-amplitude wavy surfaces[J].J. Fluid Mech.,1984,140:27-44
[4]	Kuzan J D,Hanratty T J,Adrian R J.Turbulent flows with incipient separation over solid waves[J].Exp. Fluids,1989,7:88-89
[5]	Brooke J W,Hanratty T J.Origin of turbulence-producing eddies in a channel flow[J].Phys. Fluids,1993,5(4):1011-1022
[6]	Kurose R,Imashiro T,Komori S.The effects of swell on turbulence over wavy walls[J].Int. J. Heat Fluid Flow,2008,29:774-782
[7]	Floryan J M.Centrifugal instability of Couette flow over a wavy wall[J].Phys. Fluids,2001,14:312-322
[8]	Krettenauer K,Schumann U.Numerical simulation of turbulent convection over wavy terrain[J].J. Fluid Mech.,1992,237:261-299
[9]	Walko R L,Cotton W R,Pielke R A.Large-eddy simulations of the effects of hilly terrain on the convective boundary layer[J].Bound-Lay Meteorol.,1992,58(1/2):133-150
[10]	Dornbrack A,Schumann U.Numerical simulation of turbulent convective flow over wavy terrain[J].Bound-Lay Meteorol.,1993,65(4):323-355
[11]	Choi H S,Suzuki K.Large eddy simulation of turbulent flow and heat transfer in a channel with one wavy wall[J].Int. J. Heat Fluid Flow,2005,26(5):681-694
[12]	Henn D S,Sykes R I.Large-eddy simulation of flow over wavy surfaces[J].J. Fluid Mech.,1999,383:75-112
[13]	Gong W,Taylor P A,Dornbrack A.Turbulent boundary-layer flow over fixed aerodynamically rough two-dimensional sinusoidal waves[J].J. Fluid Mech.,1996,312:1-37
[14]	Kuhn S,Kenjeres S,Von Rohr P R.Large eddy simulations of wall heat transfer and coherent structures in mixed convection over a wavy wall[J].Int. J. Therm. Sci.,2010,49(7):1209-1226
[15]	Kasagi N,Tomita Y,Kuroda A.Direct numerical simulation of passive scalar field in a turbulent channel flow[J].ASME J. Heat Transfer,1992,114:598-606

刚性波纹面与柔性波纹面传热及流动特性

Heat transfer and flow characteristics on solid and flexible wavy surfaces

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 15

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张双星, 刘舫辰, 张义飞, 杜文静. R-134a脉动热管相变蓄放热实验研究[J]. 化工学报, 2023, 74(S1): 165-171.
[2]	王海, 林宏, 王晨, 许浩洁, 左磊, 王军锋. 高压静电场强化多孔介质表面沸腾传热特性研究[J]. 化工学报, 2023, 74(7): 2869-2879.
[3]	张贲, 王松柏, 魏子亚, 郝婷婷, 马学虎, 温荣福. 超亲水多孔金属结构驱动的毛细液膜冷凝及传热强化[J]. 化工学报, 2023, 74(7): 2824-2835.
[4]	施炜斌, 龙姗姗, 杨晓钢, 蔡心悦. 计及气泡诱导与剪切湍流的气泡破碎、湍流相间扩散及传质模型[J]. 化工学报, 2022, 73(6): 2573-2588.
[5]	林志敏, 王崇兆, 强国智, 刘树山, 王良璧. 润滑油在内插同轴交叉翼型涡产生器管内流动与传热特性分析[J]. 化工学报, 2022, 73(11): 4957-4973.
[6]	林伟翔, 苏港川, 陈强, 文键, 王斯民. 基于超声技术的沉浸式换热器强化传热研究[J]. 化工学报, 2021, 72(8): 4055-4063.
[7]	高峰, 陈永昌, 赵金龙, 马重芳. 磁场对熔盐射流冲击传热的影响[J]. 化工学报, 2020, 71(S2): 92-97.
[8]	郎中敏, 吴刚强, 赫文秀, 韩晓星, 苟延梦, 李双莹. 二氧化铈/水基纳米流体核沸腾传热特性[J]. 化工学报, 2020, 71(5): 2061-2068.
[9]	姚强, 郭雪岩, 杨帆, 王志远. 球床反应堆面心立方单元局部流动与传热的数值分析[J]. 化工学报, 2019, 70(S2): 161-168.
[10]	刘占斌, 何雅玲, 王坤, 马朝, 姜涛. 泡沫填充方式对管内超临界CO₂流动换热的影响研究[J]. 化工学报, 2019, 70(9): 3329-3336.
[11]	高兴辉, 周帼彦, 涂善东. 缠绕管式换热器壳程强化传热性能影响因素分析[J]. 化工学报, 2019, 70(7): 2456-2471.
[12]	张静, 周圆圆, 龚斌, 李雅侠, 刘海良, 吴剑华. 三维凹壁面切向射流流动特性分析[J]. 化工学报, 2019, 70(4): 1340-1348.
[13]	陈景祥, 李蔚, 朱华, 金春花, 杜锦才, 张政江, 刘丽. 三维双侧强化管内R410A蒸发换热特性[J]. 化工学报, 2018, 69(S2): 76-81.
[14]	黄金, 李晓朋, 王婷, 胡艳鑫, 盛鑫鑫. 基于MWCNTs/PA复合材料铜表面处理的传热性能[J]. 化工学报, 2018, 69(7): 2956-2963.
[15]	许鑫磊, 严嘉玮, 张巍, 李伟锋, 张经纬, 刘海峰, 王辅臣. T型反应器内非稳态吞噬流机理[J]. 化工学报, 2018, 69(12): 5073-5080.