不同来源家庭户用沼气池沼液成分分析及风险评价

doi:10.3969/j.issn.0438-1157.2014.05.040

摘要/Abstract

摘要： 采集了中国8个省市的43个不同原料家庭户用沼气池的沼液，进行化学需氧量（COD）、氨氮（NH₄⁺-N）、磷酸盐（PO₄^3-）和重金属等指标分析，阐述不同原料导致沼液成分的差异，评价了不同来源沼液存在的生态风险，旨在为不同来源沼液的资源化利用提供理论依据。研究结果表明，以牛粪和秸秆为原料的沼液COD浓度较高，分别达到6800 mg·L^-1和5800 mg·L^-1；以猪粪和混合粪便为原料的沼液氨氮浓度较高，都超过1800 mg·L^-1，而牛粪原料沼液氨氮浓度明显低于其他原料，平均值仅有450 mg·L^-1，因此以牛粪为原料的沼液COD/NH₄⁺-N显著高于其他三种原料，COD/NH₄⁺-N达到15，而其他三种原料的沼液COD/ NH₄⁺-N均低于5；所有原料沼液磷酸盐浓度的平均值均低于80 mg·L^-1；沼液中汞的污染较严重，且在不同原料和不同地区的沼液中具有普遍性；潜在生态风险指数RI分析结果表明，云南、河南和湖北的沼液RI介于130～260之间，属于中等生态危害，存在一定的生态风险。

关键词: 户用沼气池, 沼液分析, COD, 氨氮, 磷酸盐, 重金属

Abstract: Forty-three biogas slurries from household biogas plants using different substrates were collected from different parts of China. The contents of chemical oxygen demand (COD), ammonium nitrogen (NH₄⁺-N), phosphate (PO₄^3-) and heavy metals were determined. The concentrations of COD in cow dung and straw as raw materials were higher than other treatments, reaching 6800 mg·L^-1 and 5800 mg·L^-1 respectively. The concentrations of NH₄⁺-N in pig manure and mix manure were higher than other treatments, reaching more than 1800 mg·L^-1. The concentration of NH₄⁺-N in cow dung was significantly lower than that in other materials, with the average being 450 mg·L^-1. Therefore, COD/ NH₄⁺ ratio of 15 in the slurry with cow dung as raw material was significantly higher than those in other three materials (less than 5). The average PO₄^3- concentrations of all raw biogas were lower than 80 mg·L^-1. Mercury pollution was serious and universal in different materials and different provinces. Environment risk evaluation showed that the pollution in biogas slurries from Yunnan, Henan and Hubei was medium and could not be ignored.

Key words: household biogas, biogas analysis, COD, ammonium nitrogen, phosphate, heavy metals

中图分类号:

S216.4

柯蓝婷, 王海涛, 王远鹏, 何宁, 李清彪. 不同来源家庭户用沼气池沼液成分分析及风险评价[J]. 化工学报, DOI: 10.3969/j.issn.0438-1157.2014.05.040.

KE Lanting, WANG Haitao, WANG Yuanpeng, HE Ning, LI Qingbiao. Component analysis and risk assessment of anaerobically digested slurry from households in China[J]. CIESC Journal, DOI: 10.3969/j.issn.0438-1157.2014.05.040.

参考文献 41

[1]	Wu Shuhang(吴淑杭), Jiang Zhenfang(姜震方), Yu Qingying(俞清英). Livestock manure pollution situation and development trend[J]. Shanghai Agricultural Science and Technology(上海农业科技), 2002, 1: 9-10
[2]	Li Jingming(李景明). The status quo of China's rural biogas construction and development prospects[EB/OL]. [2008-10-04]. http://www.sdpe.cn/zixun_content.asp?id=105
[3]	Gan Fuding(甘福丁), Wei Shiqing(魏世清), Qin Wenneng(覃文能), Zeng Guangyu(曾广宇), Li Jinhuai(李金怀), Jiang Hubo(蒋湖波). Effect of biogas slurry on tabe bean quality and soil fertility[J]. China Biogas(中国沼气), 2011, 29(1): 59-60
[4]	Zhou S Y, Zhang B, Cai Z F. Emergy analysis of a farm biogas project in China: A biophysical perspective of agricultural ecological engineering[J]. Communications in Nonlinear Science and Numerical Simulation, 2010, 15(5): 1408-1418
[5]	Ye Xiaomei(叶小梅), Chang Zhizhou(常志州), Qian Yuting(钱玉婷), Pan Juncai(潘君才), Zhu Jin(朱谨). Investigation on large and medium scale biogas plants and biological properties of digestate in Jiangsu province[J]. Transactions of the Chinese Society of Agricultural Engineering(农业工程学报), 2012, 28(6): 222-227
[6]	Guo Qiang(郭强), Chai Xiaoli(柴晓利), Cheng Haijing(程海静), Zhao Youcai(赵由才). Comprehensive utilizing of biogas liquid residue[J]. Renewable Resources(再生资源研究), 2005(6): 37-41
[7]	Lu Mei(陆梅), Mao Yurong(毛玉荣), Yang Kanglin(杨康林), Xia Zefen(夏泽芬), Chen Zhonglun(陈忠伦). The use of biogas slurry residue[J]. Agricultural Service(农技服务), 2007, 24(5): 37-39
[8]	Guo Qiang(郭强), Niu Dongjie(牛冬杰), Cheng Haijing(程海静), Zhao Youcai(赵由才). Comprehensive utilizing of biogas residue[J]. China Resources Comprehensive Utilization(中国资源综合利用), 2005(12): 11-15
[9]	Lin Jianfeng(林剑锋). Apptication technique for biogas fermenting product[J]. Renewable Energy Resources(可再生能源), 2003, 4: 36-38
[10]	Zhang Lingling(张玲玲), Li Zhaohua(李兆华), Lu Min(鲁敏), Zhao Quan(赵泉), Guo Ting(郭婷), He Youcai(何友才), Zhang Huaxiang(张华祥). Analysis on utilization of biogas slurry[J]. Resource Development and Market(资源开发与市场), 2011, 27(3): 260-262
[11]	Wang Liwei(王莉玮), Jiang Xiaoli(蒋小丽), Yang Zhimin(杨志敏), Chen Yucheng(陈玉成). On COD removal from biogas slurry by bamboo charcoal-microbe technology[J]. Journal of Southwest China Normal University: Natural Science Edition (西南师范大学学报:自然科学版), 2012, 37(10): 130-134
[12]	Tenca A, Schievano A, Lonati S, Malagutti L, Oberti R, Adani F. Looking for practical tools to achieve next-future applicability of dark fermentation to produce bio-hydrogen from organic materials in continuously stirred tank reactors[J]. Bioresource Technology, 2011, 102: 7910-7916
[13]	Gao Tongguo, Chen Nan, Li Weiqun, Li Baozhen, Yuan Hongli. Effect of highly efficient nutrition solution of biogas slurry on yield and quality of vegetables[J].Agricultural Science & Technology, 2011, 12(4): 567-570
[14]	Zhang Quanguo(张全国), Liu Zhenbo(刘振波), Li Gailian(李改莲), Li Pengpeng(李鹏鹏). Research on field trial application of anaerobic fermentation slurry extender[J]. Journal of Safety and Environment (安全与环境学报), 2007, 7(2): 18-21
[15]	Zhang Jifang(张继芳), Yuan Hairong(袁海荣), Zou Dexun (邹德勋), Liu Yanping(刘研萍). Security risk analysis on the nutrients and heavy metals of biogas slurry in agricultural application[J]. Journal of Anhui Agricultural Science(安徽农业科学), 2012, 40(19): 10246- 10250
[16]	Duan Ran(段然), Wang Gang(王刚), Yang Shiqi(杨世琦), Yang Zhengli(杨正礼). Reliminary research of potential pollution on farmland soil after using biogas[J]. Journal of Jilin Agricultural University(吉林农业大学学报), 2008, 30(3): 310-315
[17]	State Environmental Protection Administration, Water and Wastewater Monitoring Analysis Method Editorial Board(国家环境保护总局水和废水监测分析方法编委会). Water and Wastewater Monitoring and Analysis Methods(水和废水监测分析方法)[M]. Beijing: China Environmental Science Press, 2002
[18]	Xing Ze(邢赜), Chen Yucheng(陈玉成), Xiong Bailian(熊佰炼), Chen Yao(陈瑶), Chang Chen(常琛). The static research on adsorption characteristics and removal efficiency of COD by different zeolite substrates in biogas slurry[J]. Agricultural Mechanization Research(农机化研究), 2013, 11: 227-230
[19]	Zhang Quanguo(张全国), Yang Qunfa(杨群发), Li Suiliang(李随亮), Fan Zhenshan(范振山). Influence of fermentation conditions on the content of ammonia nitrogen in anaerobic fermentation slurry[J]. Transactions of the Chinese Society of Agricultural Engineering(农业工程学报), 2005, 21(6): 114-117
[20]	Chen Silin(陈思琳), Liu Fang(刘方), Zhang Dengyu(张登宇), Fang Congbo(方聪波). Adsorption effect of charcoal and activated carbon on NH4+-N, TP and COD in biogas slurry[J]. Guizhou Agricultural Sciences(贵州农业科学), 2012, 40(3): 204-206
[21]	Yang Mingzhen(杨明珍), Bao Zhenyu(包震宇), Shi Xiaochun(师晓春), Wang Desheng(汪德生). Experimental study on treatment for anaerobic fermentation slurry by struvite precipitation[J]. Industrial Safety and Environmental Protection(工业安全与环保), 2011, 37(3): 31-32
[22]	Sun Hongwei(孙洪伟), Wang Shuying(王淑莹), Wang Ximing(王希明), Shi Xiaoning(时晓宁), Peng Yongzhen(彭永臻). Advanced nitrogen removal from landfill leachate with highly concentrated ammonia nitrogen via nitrite in SBR[J]. CIESC Journal(化工学报), 2009, 60(7): 1806-1811
[23]	Zhu Rulong(朱如龙), Wang Shuying(王淑莹), Li Jun(李军), Wang Kai(王凯), Miao Lei(苗蕾), Peng Yongzhen(彭永臻). Advanced nitrogen removal of landfill leachate in single stage oxic pulsed SBR process[J]. CIESC Journal(化工学报), 2012, 63(10): 3262-3268
[24]	Liu Bo(刘波), Chen Yucheng(陈玉成), Wang Liwei(王莉玮), He Juan(何娟), Liu Jiangguo(刘江国), Liang Qinshuang(梁勤爽). Phosphorus adsorption characteristics of four substrates in constructed wetland[J]. Chinese Journal of Environmental Engineering (环境工程学报), 2010, 4(1): 44-48
[25]	Chen Jiangang(陈建刚). Research on the mechanism of phosphate immobilization and the intensified phosphate immobilization technology of zeolite synthesized from coal fly ash[D]. Shanghai: Shanghai Jiao Tong University, 2007
[26]	Ding Wenming(丁文明), Huang Xia(黄霞). Progress of studies on phosphorus removal from wastewater by adsorbents[J]. Techniques and Equipment for Environmental Pollution Control(环境污染治理技术与设备), 2002, 3(10): 23-27
[27]	Karageorgiou K, Paschalis M, Anastassakis G N. Removal of phosphate species from solution by adsorption onto calcite used as natural adsorbent[J]. Journal of Hazardous Materials, 2007, 139(10): 447-452
[28]	Biswas B K, Inoue K, Gbimire K N, Harada H, Ohto K, Kawakita H. Removal and recovery of phosphorus from water by means of adsorption onto orange waste gel loaded with zirconium[J]. Bioresource Technology, 2008, 99(18): 8685-8690
[29]	Xing Ze(邢赜), Chen Yucheng(陈玉成), Xiong Bailian(熊佰炼), Sun Xiaodong(孙晓东), Sun Xiaojing(孙晓静). Static adsorption characteristics and removal efficiency of phosphate in biogas slurry by different zeolite substrates[J]. Chinese Journal of Environmental Engineering(环境工程学报), 2013, 7(2): 494-500
[30]	Zhang Yusheng(张玉生), Li Chaoqun(李超群), Lin Jinqing(林金清). Amount of alkali needed and variation patterns in phosphorus recovery process by struvite[J]. CIESC Journal(化工学报), 2012, 63(7): 2217-2223
[31]	Ueno Y. Three years operating experience selling recovered struvite from full-scale plants// The Second International Conference on the Recovery of Phosphorus from Sewage and Animal Wastes[C]. 2001, Scope 39: 14
[32]	Jaffer Y, Clark T A, Pearce P, et al. Potential phosphorus recovery by struvite formation[J]. Water Research, 2002, 36: 1834-1842
[33]	Munch E V, Barr K. Controlled struvite crystallization for removing phosphorus from anaerobic digester sidestreams[J]. Water Research, 2001, 35(1): 151-159
[34]	Sui Qianwen(隋倩雯), Dong Hongmin(董红敏), Zhu Zhiping(朱志平), Huang Hongkun(黄宏坤). Present status of biogas effluent treatment technology research and application[J]. Journal of Agricultural Science and Technology(中国农业科技导报), 2011, 13(1): 83-87
[35]	Li Yiwen(李祎雯), Qu Yinghua(曲英华), Xu Yilin(徐奕琳), Han Yanxiao(韩艳霄), Lin Cong(林聪). Change of nutrition contents of biogas slurry with different fermentation raw materials[J]. China Biogas(中国沼气), 2012, 30(3): 17-21
[36]	Zhang Chang'ai(张昌爱), Wang Yanqin(王艳芹), Yuan Changbo(袁长波), Yao Li(姚利), Liu Ying(刘英). Analysis on the difference of nutrition contents between different anaerobic fermentation residue from different raw materials[J]. Modern Agricultural Sciences(现代农业科学), 2009, 16(1): 44-46
[37]	Liu Xilong(刘喜龙), Liu Jianwei(刘建伟), Liu Bin(刘宾). Research status and progress on safe use of biogas slurry[J]. Journal of Anhui Agricultural Science(安徽农业科学), 2012, 40(2): 968-971
[38]	Lars Hakanson. An ecological risk index for aquatic pollution control. A sedimentological approach[J]. Water Research, 1980, 14(8): 975- 1001
[39]	Ma Deyi(马德毅), Wang Juying(王菊英). Evaluation on potential ecological risk of sediment pollution in main estuaries of China[J]. China Environmental Science(中国环境科学), 2003, 23(5): 521-531
[40]	Fan Wenhong(范文宏), Zhang Bo(张博), Zhang Rong(张融), Deng Baoshan(邓宝山). Speciation characteristics and potential ecological risk of heavy metals in surface sediments of Jinzhou bay[J]. Marne Environmental Science(海洋环境科学), 2008, 27(1): 54-58
[41]	Chen Peirong(陈培榕), Wu Yaoguo(吴耀国), Liu Baochao(刘保超). Progress in the modification of bentonite-based heavy metal adsorbent[J]. Chemical Industry and Engineering Progress(化工进展), 2009, 28(9): 1647-1652