基于LFG的沼气机热泵系统配置与实验研究

doi:10.3969/j.issn.0438-1157.2014.z2.031

化工学报 ›› 2014, Vol. 65 ›› Issue (z2): 208-214.DOI: 10.3969/j.issn.0438-1157.2014.z2.031

基于LFG的沼气机热泵系统配置与实验研究

吴集迎^1,2, 马益民^1,2

1. 集美大学机械与能源工程学院, 福建厦门 361021;
2. 福建省能源清洁利用与开发重点实验室, 福建厦门 361021

收稿日期:2014-08-22 修回日期:2014-08-28 出版日期:2014-12-30 发布日期:2014-12-30
通讯作者: 吴集迎
基金资助:
福建省自然科学基金项目(2010J01301)。

System configuration and experimental study on LFG based biogas engine driven heat pump

WU Jiying^1,2, MA Yimin^1,2

1. College of Mechanical and Energy Engineering, Jimei University, Xiamen 361021, Fujian, China;
2. Fujian Province Key Laboratory of Energy Cleaning Utilization and Development, Xiamen 361021, Fujian, China

Received:2014-08-22 Revised:2014-08-28 Online:2014-12-30 Published:2014-12-30
Supported by:
supported by the Natural Science Foundation of Fujian Province(2010J01301).

摘要/Abstract

摘要：

探讨了以垃圾填埋气(LFG)为燃料的沼气机热泵节能系统的设备配置,分析了LFG的收集及净化流程。通过搭建实验装置,进行了系统性能测试。实验结果表明:当沼气机在额定转速的70%~90%区间运行时,虽然系统总供热量不是最大,但排烟余热回收率相对较高,系统能源利用率最高。与其他供热系统相比,沼气机热泵可明显减少化石燃料的消耗,显著提高供热能力,是一种可再生能源综合利用的节能方式。

关键词: LFG, 沼气机热泵, 性能实验, 排烟余热回收, 节能

Abstract:

The system equipment configuration of a landfill gas (LFG) fueled biogas engine driven heat pump energy-saving system was studied, and the LFG collecting and purifying flow process was analyzed. By constructing an experimental plant, the performance of the system was tested. The results of experiments indicated that when the biogas engine operated at 70%—90% of its rated speed, the energy efficiency of the system would reach its maximum. That is because the waste heat recovery rate of exhaust fume was relatively higher, although the heat supplied by the system was not the maximum. Compared with other heating systems, biogas engine driven heat pump system can significantly reduce the consumption of fossil fuels and improve heating capability. Therefore, the heating system developed can lower energy consumption and utilize renewable energy sources comprehensively.

Key words: LFG, biogas engine driven heat pump, performance test, fume waste heat recovery, energy conservation

中图分类号:

TU832.2

吴集迎, 马益民. 基于LFG的沼气机热泵系统配置与实验研究[J]. 化工学报, 2014, 65(z2): 208-214.

WU Jiying, MA Yimin. System configuration and experimental study on LFG based biogas engine driven heat pump[J]. CIESC Journal, 2014, 65(z2): 208-214.

参考文献 18

[1]	Fan Xiaoping(范晓平),Su Hongyu(苏红玉),Kang Zhentong(康振同),Tong Lin(童琳),Zhang Qing(张庆).Utilization of landfill gas as renewable energy resources[J].Shanxi Energy and Conservation(山西能源与节能),2010,61(4): 20-22
[2]	Han Dan(韩丹),Shi Feng(石峰),Chai Xiaoli(柴晓利), Chen Haoquan(陈浩泉),Zhao Youcai(赵由才).A new way of natural mitigation of methane in a refuse landfill:anaerobic and aerobic co-oxidation[J].Acta Scientiae Circumstantiae(环境科学学报),2011,31(4): 791-797
[3]	Cao Dongmei(曹冬梅),Liu Kun(刘坤).Resource reuse research on methane produced from the anaerobic digestion of municipal sludge[J].Industrial Safety and Environmental Protection(工业安全与环保),2006,32(11): 41-43
[4]	Wu Jiying(吴集迎),Zeng Jieqing(曾杰清).System construction and economic analysis of heat pump driven by biogas engine[J].Refrigeration and Air-Conditioning(制冷与空调),2008,8(1): 27-29
[5]	Wu Jiying(吴集迎),Ma Yimin(马益民).Configuration and flow process study of direct-fired heat pump system driven by biogas from sewage treatment plant[J].CIESC Journal(化工学报),2012,63(S2): 80-84
[6]	Wu Jiying(吴集迎),Ma Yimin(马益民).System construction and flow process study of a direct-fired heat pump system based landfill gas[J].Renewable Energy Resources (可再生能源),2012,30(9): 50-54
[7]	Chen Yegang(陈业钢),Chen Manman(陈漫漫).Burning system design of biogas[J].China Water & Wastewater(中国给水排水),2002,18(7): 65-66
[8]	Liu Ruiqiang(刘瑞强),Guo Miao(郭淼).Characteristics of landfill gas and its recovery[J].Journal of Tianjin Urban Construction Institute (天津城市建设学院学报),2001,7(4): 247-251
[9]	Shi Lei(石磊),Zhao Youcai(赵由才),Niu Dongjie(牛冬杰).Technique progress in landfill gas purification[J]. Natural Gas Chemical Industry(天然气化工),2004,29(2): 58-62
[10]	Liu Huanwei(刘焕卫),Yang Zhao(杨昭),Wang Mingtao(王明涛).Experimental study of the partial load characteristics of a gas-engine-driven heat pump[J].Journal of Engineering for Thermal Energy and Power(热能动力工程),2011,26(5): 523-527
[11]	Li Yinglin(李应林),Zhang Xiaosong(张小松),Yin Yonggao(殷勇高),Guan Zhenshui(管振水),Jiang Yijun(蒋一军).Experimental research on variable speed operation of cold-hot water unit driven by gas engine[J].Journal of Southeast University (东南大学学报),2005,35(2): 298-301
[12]	Hou Genfu(侯根富),Duan Changgui(段常贵),Ma Zuiliang(马最良).Experiment of performance characteristics of a compression heat pump unit driven by a gas engine[J].Heating Ventilating & Air Conditioning (暖通空调),2001,31(3): 5-8
[13]	Ren Yong(任勇),Yang Zhao(杨昭).Performance experiment of ICEEI system[J].Journal of Tianjin University (天津大学学报),2011,44(1): 29-34
[14]	Xu Zhenjun(徐振军),Yang Zhao(杨昭).Numerical calculation and energy consumption analysis for air condition system driven by biogas engine[J].Transactions of the Chinese Society for Agricultural Machinery(农业机械学报),2008, 39(9): 118-121
[15]	Zhang R R,Lu X S,Li S Z.Analysis on the heating performance of a biogas engine driven air to water heat pump based on a steady-state model[J].Energy Conversion and Management,2005,46(11/12): 1714- 1730
[16]	Li Shuze,Zhang Wugao,Zhang Rongrong.Cascade fuzzy control for biogas engine driven heat pump[J]. Energy Conversion and Management,2005,46(11/12): 1757-1766
[17]	Lian Zhiwei,Park Seong Ryong,Huang Wei. Conception of combination of biogas-engine-driven heat pump and water-loop heat pump system[J]. International Journal of Refrigeration,2005,28(6): 810-819
[18]	Li Yinglin, Zhang Xiaosong, Cai Liang.A novel parallel-type hybrid-power biogas engine-driven heat pump system[J].International Journal of Refrigeration, 2007,30(7): 1134-1142

基于LFG的沼气机热泵系统配置与实验研究

System configuration and experimental study on LFG based biogas engine driven heat pump

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

[1]	吴延鹏, 刘乾隆, 田东民, 陈凤君. 相变材料与热管耦合的电子器件热管理研究进展[J]. 化工学报, 2023, 74(S1): 25-31.
[2]	高润淼, 宋孟杰, 高恩元, 张龙, 张旋, 邵苛苛, 甄泽康, 江正勇. 冷链装备制冷剂相关温室气体减排研究进展[J]. 化工学报, 2023, 74(S1): 1-7.
[3]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[4]	魏彬, 周鑫, 王耀伟, 郭振莲, 陈小博, 刘熠斌, 杨朝合. 基于改进NSGA-Ⅱ算法的FCC分离系统多目标优化[J]. 化工学报, 2021, 72(5): 2735-2744.
[5]	陆至彬, 谢星, 鲁思达, 何畅, 张冰剑, 陈清林. 基于代理模型的含盐废水多级纳滤系统的过程优化设计[J]. 化工学报, 2021, 72(3): 1400-1408.
[6]	杜加磊,翟持,朱远蹠,谢德龙,梅毅. 基于分析的热法磷酸全热能回收技术模拟研究[J]. 化工学报, 2021, 72(11): 5790-5799.
[7]	吴集迎, 马益民, 曹文胜. 沼气机驱动的风冷热泵系统变工况性能[J]. 化工学报, 2020, 71(8): 3789-3796.
[8]	倪辉, 杨自力, 钟珂, 陶睿杨, 谷雨倩. 内热型超声雾化溶液再生系统最优内热量的研究[J]. 化工学报, 2020, 71(3): 1035-1044.
[9]	孙诗瑞, 杨傲, 石涛, 申威峰. 特殊精馏热耦合强化技术研究进展[J]. 化工学报, 2020, 71(10): 4575-4589.
[10]	杨路, 刘硕士, 罗小艳, 杨思宇, 钱宇. MTO烯烃分离过程的多目标操作优化[J]. 化工学报, 2020, 71(10): 4720-4732.
[11]	王超前, 王文龙, 李哲, 孙静, 宋占龙, 赵希强, 毛岩鹏. 基于微波诱导定向加热的污泥新型热解方法能耗分析[J]. 化工学报, 2019, 70(S1): 168-176.
[12]	张宇轩, 翟晓强. 感温变色建筑涂料的制备及光谱反射性能实验研究[J]. 化工学报, 2019, 70(9): 3537-3544.
[13]	陈东良, 张忠林, 杨景轩, 马旭莉, 李鹏, 郝晓刚, 官国清. 基于自热再生的化学吸收法CO₂捕集工艺模拟及节能分析[J]. 化工学报, 2019, 70(8): 2938-2945.
[14]	金靓婕, 白鹏, 郭翔海. 带有侧线采出回流的部分透热精馏的节能优化[J]. 化工学报, 2019, 70(5): 1804-1814.
[15]	张亮, 史忠科. 相变储能技术在汽车节能中的应用进展[J]. 化工学报, 2018, 69(S2): 17-25.